Technical Service Bulletins
- A/C Compressor
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Automatic Trans
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Trans. Oil Seals, Lubrication Prior To Installation (GROUP 34, NO. 96-01)
- Trans. Oil Seals, Lubrication Prior To Installation (GROUP 39, NO. 96-02)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-02)
- Automatic Transmission Identification (GROUP 37, NO. 95-01)
- Differential Oil Level Maintenance Requirements (GROUP 00, NO. 93-07)
- Revised Maintenance Schedule For 3-Speed Automatic (93-03)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01)
- A/T Final Drive Synthetic Oil Requirement (GROUP 37, NO. 93-02)
- Differential Oil Level 3-Speed Automatic Trans (A93-10)
- Revised Engine/Transmission Tightening Torques (GROUP 37, NO. 92-09)
- Trans 087/089 - Delayed/Erratic Upshifts - ATF Pump (GROUP 37, NO. 91-03)
- Complete Systems Fluid Capacity Reference Chart (GROUP 00, NO. 90-01)
- Automatic Transmission - Buzzing Noise - Shift Cable (GROUP 37, NO. 90-T01)
- Fuel Quality And Carbon Deposits (GROUP 15, NO. 88-01)
- A/T Oil Cooler Come With Replacement Transmissions (GROUP 38, NO. 87-01)
- Auxiliary Emission Control Systems
- Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01)
- Heated Oxygen Sensor Contact Cleaner Precaution (GROUP 24, NO. 94-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01)
- Rotten Egg Odor At Exhaust - Sulfur In Fuel (GROUP 24, NO. 92-04)
- Long Cranking Time, Intermittent Stumble & Misfiring (GROUP 25, NO. 91-13)
- Fault Code 2132 - Incorrect Fuel And/Or Ignition Ecu (GROUP 25, NO. 91-12)
- Intermittent Stalling On Deceleration (GROUP 25, NO. 91-03)
- Electronic Control Units - Precautions (GROUP 28, NO. 91-03)
- Vehicle Loses Power - Codes 2141, 2142, 2143 Stored (GROUP 28, NO. 90-03)
- VAG 1598 Test Box-Description,Connecting,Application (GROUP D2, NO. 90-02)
- Dead Battery - Fuel Pump Relay Stuck On (GROUP 20, NO. 90-T01)
- Battery Discharged - Fuel Pump Relay Remains On (GROUP 20, NO. 89-T03)
- Axle Shafts
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01)
- Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01)
- Coolant Circulation Pump Leakage Troubleshooting (GROUP 19, NO. 93-03)
- Dynamic Oil Pressure System - Troubleshooting Tips (GROUP 17, NO. 92-03)
- Antifreeze Testers - Accuracy Information (GROUP 19, NO. 91-02)
- VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08)
- Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02)
- Broken Radiator Expansion Tank Return Line-Repair (GROUP 19, NO. 90-03)
- 4/5-CYL. Engine Rear Crankshaft Seal Leaks Oil (GROUP 17, NO. 90-03)
- Broken Radiator Neck Repairing (GROUP 19, NO. 90-02)
- Radiator Fan Bearings Noisy (GROUP 19, NO. 90-01)
- 2.2/2.3L Eng Water Pump Leaky/Noisy - New Pump/Seal (GROUP 19, NO. 89-T04)
- Radiator Fan Stays On - Fan Relay (GROUP 19, NO. 89-T01)
- Throttle Body Dashpot Adjustment (GROUP 25, NO. 88-01)
- Radiator Fan Stays On - Relay Sticks (GROUP 19, NO. 87-03)
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Portable Gasoline Containers Filling (GROUP 20, NO. 95-02)
- Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01)
- Heated Oxygen Sensor Contact Cleaner Precaution (GROUP 24, NO. 94-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01)
- Long Cranking Time, Intermittent Stumble & Misfiring (GROUP 25, NO. 91-13)
- Fault Code 2132 - Incorrect Fuel And/Or Ignition Ecu (GROUP 25, NO. 91-12)
- Electronic Control Units - Precautions (GROUP 28, NO. 91-03)
- Vehicle Loses Power - Codes 2141, 2142, 2143 Stored (GROUP 28, NO. 90-03)
- VAG 1598 Test Box-Description,Connecting,Application (GROUP D2, NO. 90-02)
- Dead Battery - Fuel Pump Relay Stuck On (GROUP 20, NO. 90-T01)
- Battery Discharged - Fuel Pump Relay Remains On (GROUP 20, NO. 89-T03)
- Entertainment Systems
- Exhaust
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Headlights
- Heated Glass/Defoggers
- Horns
- HVAC Control Systems
- Identification
- Ignition System
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-01)
- Vehicle DRIVEABILITY - Distributor Caps (GROUP 28, NO. 93-03)
- Vehicle DRIVEABILITY - Distributor Rotor (GROUP 28, NO. 93-04)
- Engine Misfire/Hard To Start - Ignition Cable Wires (GROUP 28, NO. 92-01)
- VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08)
- Loss Of Power/Rough Idle - Fuel Pump Screen Clogged (GROUP 20, NO. 91-07)
- No Start/Poor Performance - Ignition Wires (GROUP 28, NO. 90-T01)
- Deviations In Fuel Economy As Mileage Accumulates (GROUP 25, NO. 89-T04)
- Engine Poor Performance/Vehicle Will Not Start (GROUP 28, NO. 89-T02)
- Excessive Cranking Time - Replace Fuel Injectors (GROUP 25, NO. 89-T02)
- Fuel System Chemical Cleaning Procedure (GROUP 25, NO. 89-04)
- Engine Misfire Due To Usage Of Contact Cleaner-Info (GROUP 28, NO. 88-01)
- Throttle Body Dashpot Adjustment (GROUP 25, NO. 88-01)
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-02)
- Oil Consumption Explanation (GROUP 17, NO. 94-02)
- Dynamic Oil Pressure System - Troubleshooting Tips (GROUP 17, NO. 92-03)
- VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08)
- 5 CYL Eng - Check Engine Light On - Power Loss (GROUP 28, NO. 91-04)
- Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02)
- 4/5-CYL. Engine Rear Crankshaft Seal Leaks Oil (GROUP 17, NO. 90-03)
- Complete Systems Fluid Capacity Reference Chart (GROUP 00, NO. 90-01)
- Noisy Valve Lifters - Oil Return Check Valve Leaking (GROUP 15, NO. 90-01)
- Fuel Quality And Carbon Deposits (GROUP 15, NO. 88-01)
- Throttle Body Dashpot Adjustment (GROUP 25, NO. 88-01)
- Manual Steering
- Central Hydraulic System Replacement - Inspection (GROUP 48, NO. 88-05)
- Clicking Noise Inside Vehicle - Improved Damper Hose (GROUP 48, NO. 91-02)
- Steering Gear/Hydraulic Pump Leak - Repair (GROUP 48, NO. 90-05)
- Hydraulic Pump Noise/V-Belt Adjusting (GROUP 48, NO. 90-03)
- Hydraulic Reservoir System - Cleaning/Flushing (GROUP 48, NO. 90-02)
- Steering Rack Leak - New Floating Piston Rod Seal (GROUP 48, NO. 90-01)
- Hydraulic Pump Banjo Bolt Replacement (GROUP 48, NO. 89-03)
- Hydraulic System Fluid - New Type (GROUP 48, NO. 89-T07)
- Resealing Central Hydraulic Pump (GROUP 48, NO. 89-02)
- Central Hydraulic System - Fluid Seepage (GROUP 48, NO. 89-T05)
- Hydraulic Pump Piston Cap Seals Leaking (GROUP 48, NO. 89-01)
- Central Hydraulic System - Fluid Loss (GROUP 48, NO. 89-T01)
- Central Hydraulic High Pressure Hose Replacement (GROUP 48, NO. 88-07)
- Recommended Hydraulic Fluid (GROUP 48, NO. 88-05)
- Manual Trans
- Mechanical
- All Models, Dynamic Compression Test Using DSO Function (CTT 00-14-01)
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02)
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-01)
- Oil Consumption Explanation (GROUP 17, NO. 94-02)
- Generator V-Belt Replacement-Special Tool Available (GROUP 27, NO. 93-01)
- Revised Engine/Transmission Tightening Torques (GROUP 37, NO. 92-09)
- VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08)
- Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02)
- Loss Of Power/Rough Idle - Fuel Pump Screen Clogged (GROUP 20, NO. 91-07)
- 4/5-CYL. Engine Rear Crankshaft Seal Leaks Oil (GROUP 17, NO. 90-03)
- Noisy Valve Lifters - Oil Return Check Valve Leaking (GROUP 15, NO. 90-01)
- Deviations In Fuel Economy As Mileage Accumulates (GROUP 25, NO. 89-T04)
- Electric Fuel Pump - Buzzing Or Humming Noise (GROUP 20, NO. 89-T07)
- Hydraulic Valve Lifters Noisy - Replace Lifters (GROUP 15, NO. 89-T01)
- Crankcase Journal Sizes-Connecting Rod Bearing Check (GROUP 13, NO. 89-01)
- Fuel System Chemical Cleaning Procedure (GROUP 25, NO. 89-04)
- Throttle Body Dashpot Adjustment (GROUP 25, NO. 88-01)
- Mechanical - Hydraulic
- Brake Pedal Pulsation/Steering Wheel Shimmy Checking (GROUP 46, NO. 98-01)
- Brake Squeal - Component Cleaning/Lubricant (GROUP 46, NO. 97-01)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01)
- Brake System - Bleeding Information (GROUP 47, NO. 93-02)
- Adapter VAG 1310/6 For Brake Pressure Regulator (GROUP 47, NO. 92-04)
- New Hydraulic Brake Servo - Installation Procedure (GROUP 47, NO. 92-02)
- Central Hydraulic System Replacement - Inspection (GROUP 48, NO. 88-05)
- High Temp Brake Fluid - Super Dot 4 Service Info (GROUP 47, NO. 91-02)
- Clicking Noise Inside Vehicle - Improved Damper Hose (GROUP 48, NO. 91-02)
- Don't Use Brake Dust Covers-Insufficient Ventilation (GROUP 46, NO. 91-04)
- Brake Fluid Change/Topping Off (GROUP 47, NO. 91-01)
- Steering Wheel Shimmy During Braking - Repair (GROUP 46, NO. 90-01)
- Complete Systems Fluid Capacity Reference Chart (GROUP 00, NO. 90-01)
- Hydraulic Reservoir System - Cleaning/Flushing (GROUP 48, NO. 90-02)
- Hydraulic Pump Banjo Bolt Replacement (GROUP 48, NO. 89-03)
- Brake Pedal Clevis Adjustment Specifications (GROUP 47, NO. 89-03)
- Hydraulic System Fluid - New Type (GROUP 48, NO. 89-T07)
- Resealing Central Hydraulic Pump (GROUP 48, NO. 89-02)
- Brake System - Noise & Chatter/Pulsation (GROUP 46, NO. 89-T02)
- Central Hydraulic System - Fluid Seepage (GROUP 48, NO. 89-T05)
- Reducing Brake Noise And Customer Complaints (GROUP 46, NO. 89-01)
- Hydraulic Pump Piston Cap Seals Leaking (GROUP 48, NO. 89-01)
- New Brake Pressure Regulator - Adjusting (GROUP 47, NO. 89-02)
- Central Hydraulic System - Fluid Loss (GROUP 48, NO. 89-T01)
- Central Hydraulic High Pressure Hose Replacement (GROUP 48, NO. 88-07)
- Fuel Quality And Carbon Deposits (GROUP 15, NO. 88-01)
- Brake System - Noise & Chatter/Pulsation (GROUP 46, NO. 89-T01)
- Recommended Hydraulic Fluid (GROUP 48, NO. 88-05)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Battery, Mis-Diagnosis When Din Spec. Is Not Entered Using MCR 340A Test Kit (GROUP 27, NO. 02-01)
- VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08)
- Loss Of Power/Rough Idle - Fuel Pump Screen Clogged (GROUP 20, NO. 91-07)
- Noisy Valve Lifters - Oil Return Check Valve Leaking (GROUP 15, NO. 90-01)
- Electric Fuel Pump - Buzzing Or Humming Noise (GROUP 20, NO. 89-T07)
- Excessive Cranking Time - Replace Fuel Injectors (GROUP 25, NO. 89-T02)
- Fuel System Chemical Cleaning Procedure (GROUP 25, NO. 89-04)
- Throttle Body Dashpot Adjustment (GROUP 25, NO. 88-01)
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02)
- Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01)
- Portable Gasoline Containers Filling (GROUP 20, NO. 95-02)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-01)
- Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01)
- Heated Oxygen Sensor Contact Cleaner Precaution (GROUP 24, NO. 94-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01)
- Vehicle DRIVEABILITY - Distributor Caps (GROUP 28, NO. 93-03)
- Vehicle DRIVEABILITY - Distributor Rotor (GROUP 28, NO. 93-04)
- Dynamic Oil Pressure System - Troubleshooting Tips (GROUP 17, NO. 92-03)
- Engine Misfire/Hard To Start - Ignition Cable Wires (GROUP 28, NO. 92-01)
- Rotten Egg Odor At Exhaust - Sulfur In Fuel (GROUP 24, NO. 92-04)
- Long Cranking Time, Intermittent Stumble & Misfiring (GROUP 25, NO. 91-13)
- Fault Code 2132 - Incorrect Fuel And/Or Ignition Ecu (GROUP 25, NO. 91-12)
- VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08)
- Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02)
- Intermittent Stalling On Deceleration (GROUP 25, NO. 91-03)
- Electronic Control Units - Precautions (GROUP 28, NO. 91-03)
- Loss Of Power/Rough Idle - Fuel Pump Screen Clogged (GROUP 20, NO. 91-07)
- Vehicle Loses Power - Codes 2141, 2142, 2143 Stored (GROUP 28, NO. 90-03)
- Excessive Cranking Times - Vacuum Leak (GROUP 25, NO. 90-05)
- 5 CYL Eng - Excessive Cranking Times - Fuel INJ Seep (GROUP 25, NO. 90-04)
- 4/5-CYL. Engine Rear Crankshaft Seal Leaks Oil (GROUP 17, NO. 90-03)
- VAG 1598 Test Box-Description,Connecting,Application (GROUP D2, NO. 90-02)
- Gasoline Containing Detergent (GROUP 20, NO. 90-01)
- Dead Battery - Fuel Pump Relay Stuck On (GROUP 20, NO. 90-T01)
- No Start/Poor Performance - Ignition Wires (GROUP 28, NO. 90-T01)
- Deviations In Fuel Economy As Mileage Accumulates (GROUP 25, NO. 89-T04)
- Poor Acceleration, Lack Of Power - Plugged Converter (GROUP 26, NO. 89-02)
- Engine Poor Performance/Vehicle Will Not Start (GROUP 28, NO. 89-T02)
- Excessive Cranking Time - Replace Fuel Injectors (GROUP 25, NO. 89-T02)
- Fuel System Chemical Cleaning Procedure (GROUP 25, NO. 89-04)
- Battery Discharged - Fuel Pump Relay Remains On (GROUP 20, NO. 89-T03)
- Fuel Quality And Carbon Deposits (GROUP 15, NO. 88-01)
- F UEL Pump - Hot Start/Noise (GROUP 20, NO. 88-04)
- Engine Misfire Due To Usage Of Contact Cleaner-Info (GROUP 28, NO. 88-01)
- Throttle Body Dashpot Adjustment (GROUP 25, NO. 88-01)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Alloy Wheels, Cleaning (GROUP 44, NO. 99-01)
- Brake Pedal Pulsation/Steering Wheel Shimmy Checking (GROUP 46, NO. 98-01)
- Eliminating Vibrations Caused By Wheel Imbalance (GROUP 44, NO. 94-02)
- Aerosol Tire Inflator/Sealer - Flammability Hazard (GROUP 44, NO. 91-01)
- Front Wheel Bearing Housing - Outer CIRCLIP Omitted (GROUP 40, NO. 90-T01)
- Eliminating Vibrations - Diagnosis (GROUP 44, NO. 89-03)
- Wheel Alignment Data For Front And Rear Axles (GROUP 44, NO. 89-04)
- Wheel Alignment Data For Front And Rear Axles (GROUP 44, NO. 89-03)
- Front Wheel Bearing Housing-CIRCLIP No Longer Needed (GROUP 40, NO. 89-T02)
- Noisy GOODYEAR Tires - Replace (GROUP 44, NO. 89-T01)
- Revised Tire Rotation Procedures (GROUP 44, NO. 88-01)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)