Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- New PAG Oil Released (02-01-39-004B)
- Revised Refrigerant System Capacities (05-01-37-004)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Essential Tool J 43600 ACR 2000 (00-01-38-006)
- Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Part and Accessory Replacement Policy (04-00-89-011)
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Required Reconfiguration of OnStar(R) Modules After Replacement (01-08-46-001A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Information on Error Codes on Radio Display - Their Cause and Corrective Action (64-90-04A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Inaccurate Or Erratic Fuel Gauge Reading, Fuel Pump Related DRIVEABILITY Concerns (Install New Fuel Tank Sender) (01-06-04-008D)
- Adm Msg - OnStar(R) Service Modules with Deactivated Settings (ONG20030007)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Info - Intermittent Communication Or Serial Data DTC Codes Stored In History (02-08-116-001)
- Programming The HOMELINK(R) Transmitter (01-08-97-002)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Accessory Drive Belts
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Frontal Air Bag On-Off Switch Kits (99-09-41-004)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Info - Intermittent Communication Or Serial Data DTC Codes Stored In History (02-08-116-001)
- DBC 7 Diagnostic Assistance & Parts Return Program (99-05-25-003A)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Correct Use Of Labor Operation R4490 RKE Transmitter Replace (01-00-89-013)
- Cold Air Enters Vehicle Around Door Handles (99-08-64-030)
- SMU - Revised Transmitter Programming Procedure (99-08-52-006)
- Trap Resistant Rear Compartment Kit (99-08-66-002A)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Information On 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shifts, Slips, No Drive, No Reverse (07-07-30-025)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- New Product Feedback Form and Process For Automatic Transmission Core Returns (01-07-30-029A)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Neutral Flare And/Or Rpm Flare While In Drive, No 1-2 Upshift, Service Engine Soon (SES) Light Illuminated, Diagnostic Trouble Codes (DTCS) P1810, DTC P1815 Set (Reprogram The Powertrain Control Module (Pcm), Replace Transmission Fluid Pressure (TFP) Manual Valve Position Switch) (03-07-30-021A)
- Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
- MN4 (4T40-E) MN5 (4T45-E) Engineering Changes (03-07-30-006)
- Pressure Control Solenoid Replacement For 4T65-E, 4T40-E And 4T45-E Transmission/Transmission (02-07-30-048)
- Oil Pump Drive Shaft Assembly Inspection (01-07-30-016)
- 4T40E/4T45E - Removal Of PWM Filter From Spacer Plat (00-07-30-016)
- 4T40-E/4T45-E - Forward Clutch Piston Change (00-07-30-013)
- 4T40-E/4T45-E - No Third And Fourth Gear (99-07-30-031)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Powertrain Control Module Product Feedback Program (00-06-04-026)
- Proper Service Of Quick Connect EVAP Connectors (00-06-04-021)
- Evaporative Emissions Testing On Vehicles (00-06-04-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Diagnostic Tip - B1001 With Sir Mil And/Or SVS Mil And/Or Locked Radio (PIC5913)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Required Reconfiguration of OnStar(R) Modules After Replacement (01-08-46-001A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Inaccurate Or Erratic Fuel Gauge Reading, Fuel Pump Related DRIVEABILITY Concerns (Install New Fuel Tank Sender) (01-06-04-008D)
- Adm Msg - OnStar(R) Service Modules with Deactivated Settings (ONG20030007)
- SMU - Revised DTCS B1000, B1004, B1007, B1009, B1013 (02-08-47-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
- Cs-144 Generator Replacement (99-06-03-011)
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Cellular Error Messages Received When Trying to Connect to OnStar(R) (02-08-46-004A)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- OnStar(R) Kit Part Numbers and Compatibility (99-08-46-001A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Required Reconfiguration of OnStar(R) Modules After Replacement (01-08-46-001A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- Adm Msg - OnStar(R) Service Modules with Deactivated Settings (ONG20030007)
- Revised ONSTAR(R) Antenna Coupling Replacement Procedures (01-08-46-006A)
- Cooling Fan
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- DEX-COOL(R) Engine Coolant Information (736214)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Engine Running Hot/Overheating &/Or Loss Of Coolant (00-06-02-001)
- Radiator Repair/Replacement Guidelines (99-06-02-017)
- Correct Fuel Pressure Operating Range (99-06-04-018)
- Differentials & Drive Axles
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise (06-07-30-006)
- SMU - Revised Wheel Drive Shaft Replacement And Fastener Tightening Specifications (03-04-18-002)
- Availability Of New Front Drive Axle Nut (03-04-18-001)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Service Engine Soon Light With Stored Codes P0112, P0113, P111 Or P1112 (Replace IAT Sensor Connector) (02-06-03-005)
- Service Engine Soon (SES) Light On With DTCS P0716 And/Or P0717, P0730, P0753, P0758, P1860, P1887 Or Other Miscellaneous Transmission Trouble Codes Set (Repair Wiring At Transaxle Wiring Pass-Thru Connector (02-07-30-022)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Powertrain Control Module Product Feedback Program (00-06-04-026)
- Evaporative Emissions Testing On Vehicles (00-06-04-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Information On Procedure To Unlock DELCO Radio With THEFTLOCK (PIC4696E)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Information on Error Codes on Radio Display - Their Cause and Corrective Action (64-90-04A)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
- Cassette Player Cleaning & Maintenance (99-08-44-008)
- Compact Disc (Cd) Players And Compatible CD'S (99-08-44-006)
- Fixed Antenna Mast Installation Torque Requirements (99-08-44-007)
- Exhaust
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Inaccurate Or Erratic Fuel Gauge Reading, Fuel Pump Related DRIVEABILITY Concerns (Install New Fuel Tank Sender) (01-06-04-008D)
- Loose Or Broken Rear Compartment Opening Molding (Install New Molding Assembly) (02-08-66-005A)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- General WATERLEAK Diagnosis Guide (01-08-57-007A)
- Hood Will Not Latch (Reroute Hood Release Cable) (01-08-63-003)
- High Rear Door Swing Effort (Replace Check Link) (01-08-64-004)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Stop/Tail Lamp(s) Inoperative or Intermittent and/or Water in Lamp (Replace Circuit Board/Gasket and/or Lamp Assembly) (00-08-42-007C)
- Proper Setting Of I/P Dimmer Control To View PRNDL (99-08-42-009)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Squeak Noise In Front End On Turns (Replace Strut Spring Seat) (04-03-08-015B)
- Front Suspension Clunk/Rattle Noise Diagnosis (01-03-08-002B)
- SMU - Revised Front Suspension Fastener Tightening Specifications (02-03-08-003)
- Squawk Noise From Front And/Or Rear Suspension (Lubricate Stabilizer Bushings) (01-03-08-003A)
- Rear Suspension Spring Squeak/Creak - Lube Seat (00-03-09-002)
- The Importance of Chassis Lubrication (00-00-90-001)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Inaccurate Or Erratic Fuel Gauge Reading, Fuel Pump Related DRIVEABILITY Concerns (Install New Fuel Tank Sender) (01-06-04-008D)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- New Design Quick-Connect Fuel Line Fittings (00-06-04-015)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Inaccurate Or Erratic Fuel Gauge Reading, Fuel Pump Related DRIVEABILITY Concerns (Install New Fuel Tank Sender) (01-06-04-008D)
- SMU - Latch Replacement - Instrument Panel (I/P Compartment) Procedure (02-08-49-008)
- SMU - Revised Fuel Gage Inaccurate Or Inoperative Diagnostic Procedure (02-08-49-001)
- Gap Between Cross-Car Trim Plate and Instrument Panel (Install Plastic Tie Strap) (01-08-49-002)
- Campaign 00101 - Erratic Fuel Gauge (00101)
- General Servicing
- Headlights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
- Proper Setting Of I/P Dimmer Control To View PRNDL (99-08-42-009)
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Revised Refrigerant System Capacities (05-01-37-004)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- HVAC Control Knob Replacement (04-01-37-001)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Automatic Air Conditioning Control Operation (99-01-39-007B)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Essential Tool J 43600 ACR 2000 (00-01-38-006)
- Diagnostic Procedure For A/C Refrigerant Leak (73-12-12A)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Key Replacement Due To Incorrect Keys Purchased (16-NA-260)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Info - Intermittent Communication Or Serial Data DTC Codes Stored In History (02-08-116-001)
- SMU - Revised Ignition Lock Cylinder Or Ignition Switch Assembly Replacement (01-08-49-020)
- Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Correct Fuel Pressure Operating Range (99-06-04-018)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- SMU - Latch Replacement - Instrument Panel (I/P Compartment) Procedure (02-08-49-008)
- Loose Or Broken Rear Compartment Opening Molding (Install New Molding Assembly) (02-08-66-005A)
- General WATERLEAK Diagnosis Guide (01-08-57-007A)
- Gap Between Cross-Car Trim Plate and Instrument Panel (Install Plastic Tie Strap) (01-08-49-002)
- Clunk, Rattle Noise from Front of Vehicle (Replace Brake Pedal Assembly) (01-05-22-001)
- Cold Air Enters Vehicle Around Door Handles (99-08-64-030)
- Trap Resistant Rear Compartment Kit (99-08-66-002A)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Engine Crankcase Flush (02-06-01-028)
- Engine Running Hot/Overheating &/Or Loss Of Coolant (00-06-02-001)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Squeak Noise In Front End On Turns (Replace Strut Spring Seat) (04-03-08-015B)
- Guidelines For Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Revised Cylinder Head Bolt Torque Specification and Tightening Sequence (02-06-01-003B)
- Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal using Revised Rear Main Seal Installer) (05-06-01-019B)
- Powertrain Quality Center For Performance Parts Engine Replacements (03-06-01-006)
- New Polymer Coated Piston And Rod Assembly (03-06-01-002)
- SMU - Revised Rocker Arm Bolt Fastener Tightening Specification (02-06-01-034)
- Engine Crankcase Flush (02-06-01-028)
- Engine Identification Information (02-06-01-026)
- Information On A New Engine PRELUBER Tool (02-06-01-008)
- SMU - Revised Lower Intake Manifold Installation (02-06-01-014)
- Cold Engine Tick Noise (Replace Pistons) (01-06-01-005)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Camshaft Sprocket Design Identification For Service (00-06-01-004)
- Engine Running Hot/Overheating &/Or Loss Of Coolant (00-06-02-001)
- Correct Fuel Pressure Operating Range (99-06-04-018)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
- Revised Brake System Specifications (05-05-23-001)
- Brake Noise/Creak During Slow Speed Braking (Lubricate Brake Caliper) (04-05-23-004)
- Front Disc Brake Pulsation (New Rotor Run-Out Specification & Correction Method) (00-05-23-002A)
- Proper Installation Of Front Brake Pads With Wear Indicator (Possibility Of Reversing Front Brake Pads) (73-50-34)
- Clunk, Rattle Noise from Front of Vehicle (Replace Brake Pedal Assembly) (01-05-22-001)
- Brake Fluid Level & Filling Recommendations (00-05-22-004)
- Memory Modules
- Mirrors
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Parking Brake System
- Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Seat Belt System Replacement Guidelines For Vehicles Involved In Collisions (01-09-40-002)
- Rear Suspension Spring Squeak/Creak - Lube Seat (00-03-09-002)
- Procedures
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Squawk Noise From Front And/Or Rear Suspension (Lubricate Stabilizer Bushings) (01-03-08-003A)
- Rear Suspension Spring Squeak/Creak - Lube Seat (00-03-09-002)
- Rear Suspension Creak/Pop Noise (Install Rear Suspension Support Insulators) (00-03-09-003)
- The Importance of Chassis Lubrication (00-00-90-001)
- Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Passenger Front Seat Rattles When Unoccupied (Reposition Rear Of Seat Track Adjuster On Floor) (01-08-50-009)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- CALIF Consent Order On Settlement Of Lawsuit On Batt (00-06-03-006)
- Correct Fuel Pressure Operating Range (99-06-04-018)
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Parts Availability For Sunroof Repairs (03-08-67-004)
- Vehicles Equipped With WEBASTO Sunroof System (99-08-67-003)
- Suspension Control Systems
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Prior To Any Circuit Testing (PIP5094A)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001G)
- Information On 4T40-E (MN4) and 4T45-E (MN5) Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, Harsh Shifts, Slips, No Drive, No Reverse (07-07-30-025)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Service Engine Soon Light With Stored Codes P0112, P0113, P111 Or P1112 (Replace IAT Sensor Connector) (02-06-03-005)
- SMU - Revised Lower Intake Manifold Installation (02-06-01-014)
- Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Cold Engine Tick Noise (Replace Pistons) (01-06-01-005)
- Engine Hesitates, Stalls &/Or Will Not Start (00-06-04-044)
- Powertrain Control Module Product Feedback Program (00-06-04-026)
- Proper Service Of Quick Connect EVAP Connectors (00-06-04-021)
- New Design Quick-Connect Fuel Line Fittings (00-06-04-015)
- Evaporative Emissions Testing On Vehicles (00-06-04-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- Correct Fuel Pressure Operating Range (99-06-04-018)
- Towing
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001G)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Neutral Flare And/Or Rpm Flare While In Drive, No 1-2 Upshift, Service Engine Soon (SES) Light Illuminated, Diagnostic Trouble Codes (DTCS) P1810, DTC P1815 Set (Reprogram The Powertrain Control Module (Pcm), Replace Transmission Fluid Pressure (TFP) Manual Valve Position Switch) (03-07-30-021A)
- Pressure Control Solenoid Replacement For 4T65-E, 4T40-E And 4T45-E Transmission/Transmission (02-07-30-048)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Service Engine Soon (SES) Light On With DTCS P0716 And/Or P0717, P0730, P0753, P0758, P1860, P1887 Or Other Miscellaneous Transmission Trouble Codes Set (Repair Wiring At Transaxle Wiring Pass-Thru Connector (02-07-30-022)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Availability Of New Front Drive Axle Nut (03-04-18-001)
- Tire Sidewall Damage (01-03-10-011)
- Improper Tire Pressure (99-03-10-104)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Service Engine Soon Light With Stored Codes P0112, P0113, P111 Or P1112 (Replace IAT Sensor Connector) (02-06-03-005)