Engine Controls - Tests W/O Codes - BCC

• Diagnostic Test Procedure
• CCD Bus Testing
• Test 1: Id Vehicle Equip & SYS Problems
• Test 2: Repair Blank Message Screen On EVIC Head
• Test 3: Warning Messages
• Test 4, 5, 6, 7 & 8: Brake Lights
  • Test 4: Brake Light Out
  • Test 5: Right Upper Brake Light Out
  • Test 6: Right Lower Brake Light Out
  • Test 7: Left Upper Brake Light Out
  • Test 8: Left Lower Brake Light Out
• Test 9: Coolant Level Low
• Test 10: Left Front Door Ajar
• Test 11: Engine Oil Level Low
• Test 12: Eng Temp Hi Or Eng Temp Critical
• Test 13: Exterior Lights On
• Test 14: Fasten Seat Belts
• Test 15: Right Headlight Out
• Test 16: Key In Ignition
• Test 17: Left Rear Door Ajar
• Test 18: Low Brake Fluid
• Test 19: Low Fuel Level
• Test 20: Low Oil Pressure
• Test 21: Headlight Out Message With No Headlights Out
• Test 22: Parking Brake Engaged
• Test 23: Passenger Door Ajar
• Test 24: Right Rear Door Ajar
• Test 25: Service Reminder
• Test 26, 27 & 28: Taillight Out
  • Test 26: Taillight Out
  • Test 27: Right Taillight Out
  • Test 28: Left Taillight Out
• Test 29: Trunk Ajar
• Test 30: Voltage Improper
• Test 31: Washer Fluid Low
• Test 32: Turn Signal On
• Test 33: No Message On EVIC Head Monitor
• Test 34: Headlights Out With No Message
• Test 35: All Brake Lights Out
• Test 36: Right Or Left Side Brake Light Out
• Test 37: All Taillights Out
• Test 38: Check Air Suspension
• Test 39: EVIC Head Monitor Switch Test
• Test 40: Electronic Cluster Diagnosis
• Test 41: Fault Messages
• Test 42: Electronic Instrument Cluster Problems Not Covered By Fault Code
• Test 43: Identifying Faulty Gauge
• Test 44, 45, 46 & 47: Gauges INOP
  • Test 44: Fuel Gauge Not Operating Correctly
  • Test 45: Coolant Gauge Not Operating Correctly
  • Test 46: Oil Pressure Gauge Not Operating Correctly
  • Test 47: Voltage Gauge Not Operating Correctly
• Test 48: Determining Which Cluster Light Is Not Operating Correctly
• Test 49: Washer Fluid Low Light Operating Incorrectly
• Test 50: Door/Deck Light Operating Incorrectly
• Test 51: Check Engine Light Not Operating Properly
• Test 52: Brake Light Not Operating Correctly
• Test 53: Gauges Light Not Operating Correctly
• Test 54: Electronic Cluster Illumination Problem
• Test 55, 56, 57: Diag Theft Alarm Module
  • Test 55: Diagnosing Vehicle Theft Alarm Module
  • Test 56: Diagnosing Vehicle Theft Alarm Module
  • Test 57: Diagnosing Vehicle Theft Alarm Module
• Test 58: Theft Alarm Indicator Light
• Test 59: Diagnosing Vehicle Theft Alarm Ignition Input
• Test 60A: Diagnosing Trunk Key Cylinder Switch
• Test 60B: Diagnosing Horn Output Circuit
• Test 61 Thru 66: Theft Alarm Module Door Ajar Switch
  • Test 61: Vehicle Theft Alarm Module Driver's Door Ajar Switch Test
  • Test 62: Vehicle Theft Alarm Module Passenger's Door Ajar Switch Test
  • Test 63: Vehicle Theft Alarm Module Right Rear Door Ajar Switch Test
  • Test 64: Vehicle Theft Alarm Module Left Rear Door Ajar Switch Test
  • Test 65: Diagnosing Short To Ground On Door Ajar Circuit
  • Test 66: Vehicle Theft Alarm Module Hood Ajar Switch
• Test 67: Vehicle Theft Alarm Module Power Door Lock
• Test 68: Vehicle Theft Alarm Module Power Door Unlock
• Test 69: Vehicle Theft Alarm Module Driver's Key Cylinder Switch Test
• Test 70: Vehicle Theft Alarm Module Passenger's Key Cylinder Switch Test
• Test 71: Vehicle Theft Alarm Module Ignition Sense Test
• Test 72 Thru 75: Diag Short To GRN On Door Ajar Circuit
  • Test 72: Diagnosing Short To Ground On Driver's Door Ajar Circuit
  • Test 73: Diagnosing Short To Ground On Passenger's Door Ajar Circuit
  • Test 74: Diagnosing Short To Ground On Right Rear Door Ajar Circuit
  • Test 75: Diagnosing Short To Ground On Left Rear Door Ajar Circuit
• Test 76: Theft Alarm Driver's Door Ajar Switch Test With Incandescent Message Center
• Test 77: Theft Alarm Passenger's Door Ajar Switch Test With Incandescent Message Center
• Test 78: Theft Alarm Right Rear Door Ajar Switch Test With Incandescent Message Center
• Test 79: Theft Alarm Left Rear Door Ajar Switch Test With Incandescent Message Center
• Test 80: Theft Alarm Module Short To GND. SW. Test For Incandescent Message Center
• Test 81: Theft Alarm Module Door Key Cylinder Switch Shorted To Ground Test
• Test 82 Thru 86: Diag Headlight Doors
  • Test 82: Diagnosing Headlight Door System
  • Test 83: Headlight Doors Will Not Open
  • Test 84: Headlight Doors Will Not Close
  • Test 85: Headlight Doors Do Not Open For Flash To Pass
  • Test 86: Headlight Doors Do Not Operate By Headlight Switch
• Test 87 & 88: Diag Automatic Door Lock System
  • Test 87: Diagnosing Automatic Door Lock System
  • Test 88: Diagnosing Automatic Door Lock System
• Test 89: Diag Driver's Door Ajar Switch For Short To GRN
• Test 90: Diagnosing Passenger's Door Ajar Switch For Short To Ground
• Test 91: Diagnosing Left Rear Door Ajar Switch For Short To Ground
• Test 92: Diagnosing Right Rear Door Ajar Switch For Short To Ground
• Test 93: Diagnosing Faulty Door Ajar Message W/Incandescent Message Center
• Test 94: Diagnosing Driver's Door Ajar SW. For Short CKT. W/Incandescent Message Center
• Test 95: Diagnosing Passenger's Door Ajar SW. For Short CKT. W/Incandescent Message Center
• Test 96: Diagnosing Right Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
• Test 97: Diagnosing Left Rear Door Ajar SW. For Short CKT. W/Incandescent Message Center
• Test 98: Checking Intermittent Wiper Circuits In Body Controller & Power Feed
• Test 99: Checking Stalk Switch, Body Controller & Related Wiring
• Test 100: Checking Wiper Motor & Ground
• Test 101: Testing Illuminated Entry System
• Test 102: Testing Passenger's Door Illuminated Entry Switch For Open Circuit
• Test 103 Thru 107: Courtesy Light & Door Jamb Switches
  • Test 103: Testing Courtesy Light & Door Jamb Switches
  • Test 104: Testing Driver's Door Jamb Switch
  • Test 105: Testing Left Rear Door Jamb Switch
  • Test 106: Testing Right Rear Door Jamb Switch
  • Test 107: Testing Passenger's Door Jamb Switch
• Test 108: Testing DRB-II For Proper Operation
• Test 109: Repairing DRB-II Failures
• Test 110: Checking CCD Bus Failure Messages Using DRB-II
• Test 111: Repair Bus System For Short To Battery
• Test 112 Thru 115: Repairing Bus System
  • Test 112: Repair Bus System For Short To 5 Volts
  • Test 113: Repair Bus System For Short To Ground
  • Test 114: Repair Bus System For Bus (+) & Bus (-) Shorted Together
  • Test 115: Repair Bus System For No Response Message
• Test 116: Check For No Response At Body Controller
• Test 117: Check For No Response From Elect Cluster
• Test 118: Check For No Response From Engine Node
• Test 119: Check For No Response From EVIC Head
• Test 120: Check For No Response From Theft Alarm
• Test 121: Check For No Response From Eng Controller
• Test 122: Repair Bus SYS For Not Receiving Bus Messages
• Test 123: Check Eng Controller For Open Bus Message
• Test 124: Repairing Bus System For No Termination Messages
• Test 125: Repairing Bus System For Bias Level Too High Or Too Low Message
• Test 126: Repairing Bus System For Bias Level Too High Or Too Low Message
• Test 127: Headlights Will Not Turn Off