Engine Controls - Tests W/Codes - 3.3L/3.8L

• Introduction
  • System Diagnostics
    • Notes
    • Hard Failures
    • Intermittent Failures
• Model Identification
• Self-Diagnostic System
  • Service Precautions
  • Visual Inspection
  • Diagnostic Procedure
  • Entering On-Board Diagnostics
    • Notes
    • CHECK ENGINE Light Diagnostic Mode
    • DRB-II Diagnostic Mode
  • Clearing Faults
• Inactive Fault Condition
• Using DRB-II
• Fuel Pressure Release
  • Notes
  • Engine Controls - Tests W/Codes - 3.3L/3.8L
    • Multi-Point Injection (MPI)
• DTC & Fault Codes/Messages
  • Notes
  • Fault Codes/Messages
    • Notes
    • Code 11
    • Code 13
    • Code 14
    • Code 15
    • Code 16
    • Code 17
    • Code 21
    • Code 22
    • Code 23
    • Code 24
    • Code 25
    • Code 27
    • Code 31
    • Code 32
    • Code 33
    • Code 34
    • Code 35
    • Code 36
    • Code 37
    • Code 41
    • Code 42
    • Code 43
    • Code 44
    • Code 45
    • Code 46
    • Code 47
    • Code 51
    • Code 52
    • Code 53
    • Code 54
    • Code 55
    • Code 61
    • Code 62
    • Code 63
    • Code 64
    • Code 65
    • Code 66
    • Code 77
• Connector Identification
• Self-Diagnostic Tests
• Fault Code Tests
  • Test FC-1A - Checking For Faults
  • Test FC-2A - No Crank Reference Signal At Pcm (DTC 11)
  • Test FC-2B - No Crank Reference Signal At Pcm
  • Test FC-3A - No Cam Sync Signal At Pcm (DTC 54)
  • Test FC-3B - No Cam Sync Signal At Pcm
  • Test FC-4A - No Change In Map From Start To Run (DTC 13)
  • Test FC-5A - Map Sensor Voltage Too Low (DTC 14)
  • Test FC-6A - Map Sensor Voltage Too High (DTC 14)
  • Test FC-7A - No Vehicle Speed Sensor Signal (DTC 15)
  • Test FC-7B - No Vehicle Speed Sensor Signal
  • Test FC-8A - 02S Shorted To Voltage (DTC 21)
  • Test FC-9A - 02S Stays At Center (DTC 21)
  • Test FC-10A - 02S Stays Above Center (Rich) (DTC 52)
  • Test FC-11A - 02S Stays Below Center (Lean) (DTC 51)
  • Test FC-12A - ECT Sensor Voltage Too High (DTC 22)
  • Test FC-13A - ECT Sensor Voltage Too Low (DTC 22)
  • Test FC-14A - Throttle Position Sensor Voltage High (DTC 24)
  • Test FC-15A - Throttle Position Sensor Voltage Low (DTC 24)
  • Test FC-16A - Idle Air Control Motor Circuits (DTC 25)
  • Test FC-17A - Injector #1 Control Circuit (DTC 27)
  • Test FC-17B - Injector #1 Control Circuit
  • Test FC-18A - Injector #2 Control Circuit (DTC 27)
  • Test FC-18B - Injector #2 Control Circuit
  • Test FC-19A - Injector #3 Control Circuit (DTC 27)
  • Test FC-19B - Injector #3 Control Circuit
  • Test FC-20A - Injector #4 Control Circuit (DTC 27)
  • Test FC-20B - Injector #4 Control Circuit
  • Test FC-21A - Injector #5 Control Circuit (DTC 27)
  • Test FC-21B - Injector #5 Control Circuit
  • Test FC-22A - Injector #6 Control Circuit (DTC 27)
  • Test FC-22B - Injector #6 Control Circuit
  • Test FC-23A - EVAP Purge Solenoid Circuit (DTC 31)
  • Test FC-24A - EGR Solenoid Circuit (DTC 32)
  • Test FC-25A - EGR System Failure (DTC 32)
  • Test FC-26A - A/C Clutch Relay Circuit (DTC 33)
  • Test FC-27A - Rad Fan Control Relay Circuit (DTC 35)
  • Test FC-30A - Auto Shutdown Relay Control Circuit (DTC 42)
  • Test FC-30B - Auto Shutdown Relay Control Circuit
  • Test FC-31A - No ASD Relay Volt Sense At Pcm (DTC 42)
  • Test FC-32A - Ignition Coil #1 Primary Circuit (DTC 43)
  • Test FC-33A - Ignition Coil #2 Primary Circuit (DTC 43)
  • Test FC-34A - Ignition Coil #3 Primary Circuit (DTC 43)
  • TEST FC-35A - PCM FAILURE SRI MILE NOT STORED OR PCM FAILURE EEPROM WRITE DENIED (DTC 62 or 63)
• No Fault Tests
  • Test NF-1A - No Fault Code Test Menu
    • No Fault Complete Test
    • No Fault Quick Individual Test
    • No Fault Quick Symptom Test
  • Test NF-2A - Checking Secondary Ignition & Timing
  • Test NF-3A - Checking Fuel Pressure
  • Test NF-3B - Checking Fuel Pressure
  • Test NF-4A - Checking Coolant Sensor Calibration & Radiator
  • Test NF-5A - Checking TPS Calibration
  • Test NF-6A - Checking Manifold Absolute Pressure (Map) Sensor
  • Test NF-7A - Checking Oxygen (O2) Sensor Switching
  • Test NF-7B - Checking Oxygen (O2) Sensor Switching
  • Test NF-8A - Checking Idle Air Control Motor
  • Test NF-8B - Checking Idle Air Control Motor
  • Test NF-9A - Checking Solenoid Operations
  • Test NF-10A - Checking Park/Neutral Switch
  • Test NF-11A - Checking Pcm Ground & Power Circuits
  • Test NF-12A - Checking EGR System
  • Test NF-13A - Checking Engine Vacuum
  • Test NF-14A - Checking Minimum Idle Airflow
  • Test NF-15A - No Fault Code Mechanical Test
• No-Start Tests
  • Test NS-1A - Qualifying No-Start Condition
  • Test NS-2A - Inspecting Fuel System
  • Test NS-3A - Inspecting Mechanical System
  • Test NS-4A - Correcting Fuel Delivery
  • Test NS-4B - Correcting Fuel Delivery
  • Test NS-5A - Inspecting Fuel Pump
  • Test NS-5B - Inspecting Fuel Pump
  • Test NS-6A - Correcting No Response Condition
  • Test NS-6B - Correcting No Response Condition
  • Test NS-7A - Inspecting Idle Air Control Motor Operation
  • Test NS-7B - Inspecting Idle Air Control Motor Operation
  • Test NS-7C - Inspecting Idle Air Control Motor Operation
  • Test NS-7D - Inspecting Idle Air Control Motor Operation
  • Test NS-7E - Inspecting Idle Air Control Motor Operation
  • Test NS-8A - Correcting Start & Stall Condition
• Verification Tests
  • Verification Procedure VER-1
  • Verification Procedure VER-2
• Wiring Diagrams