Technical Service Bulletins

A/C Compressor
- A/C System Additives (24-003-03)
- A/C Performance Test Ports (24-010-02)
- A/C System Leak Detection (24-009-02)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Interior/Exterior Lamps Flicker (18-016-03)
Accessory Drive Belts
- Accessory Drive Belt Squeaking/Chirping Sound (07-001-04)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Anti-Theft Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Inadvertent Siren Activation (08-012-03)
Automatic Trans
- Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Transmission Delayed Engagement (21-007-04)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
- Engine Overheat (07-001-03)
- Mil Illumination, Erroneous Diagnostic Trouble Codes DTCS (18-018-03)
- Flash Programming Failure Recovery (18-32-98)
Axle Shafts
- Front Hub/Half Shaft Click/Pop Sound (03-006-04)
Blowers, Superchargers & Turbochargers
- Engine Hesitation, Loss Of Boost, Screeching Sound From Turbo, Diagnostic Trouble Code (DTC) PO234 (11-002-02)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Interior/Exterior Lamps Flicker (18-016-03)
- Flash Programming Failure Recovery (18-32-98)
Brakes Control Systems
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Communication Devices
- Radio Communication Equipment Installation Recommendations (08-024-05)
Cooling Fan
- Engine Overheat (07-001-03)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Engine Overheat (07-001-03)
Engine Control Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash: DRIVEABILITY Improvements (18-024-05)
- Powertrain Control Module Initialization (08-015-05)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- Flash: Engine Sag Or Rough Idle Or Vehicle Surge At Engine Speeds Around 3000 Rpm (18-020-04)
- New Spark Plug For 2.4L Engine (08-034-03)
- Engine Overheat (07-001-03)
- Flash: Long Crank No Start/Mil Illumination (18-029-02)
- Slight Engine Mis-Fire Above 5200 Rpm (18-029-03)
- Mil Illumination, Erroneous Diagnostic Trouble Codes DTCS (18-018-03)
- Interior/Exterior Lamps Flicker (18-016-03)
- Flash Programming Failure Recovery (18-32-98)
Entertainment Systems
- Radio Cd Err Message (08-028-03)
- Compact Disc (Cd) Loading & Ejecting For 6 Disc Radio (Sales Code RBQ) (08-008-03)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Frames & Bumpers (13-002-03)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Interior/Exterior Lamps Flicker (18-016-03)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
- Front Or Rear Fascia Discoloration (23-034-04)
- Frames & Bumpers (13-002-03)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Fuel System
- Mil Illumination, Erroneous Diagnostic Trouble Codes DTCS (18-018-03)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Moisture In Headlamps (08-044-05)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- A/C System Additives (24-003-03)
- A/C Performance Test Ports (24-010-02)
- A/C System Leak Detection (24-009-02)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Ignition System
- New Spark Plug For 2.4L Engine (08-034-03)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Front Or Rear Fascia Discoloration (23-034-04)
- Frames & Bumpers (13-002-03)
Interior/Illumination Lights
- Interior/Exterior Lamps Flicker (18-016-03)
Manual Steering
- Revised Power Steering System Bleeding Procedures (19-008-05 REV. A)
- Accessory Drive Belt Squeaking/Chirping Sound (07-001-04)
- Whistling Sound When The Steering Wheel Is Turned (19-001-04)
- Power Steering Fluid Usage (19-007-01)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Accessory Drive Belt Squeaking/Chirping Sound (07-001-04)
- Irregular Engine Snapping Sound (09-007-04)
- Mil Illumination, Erroneous Diagnostic Trouble Codes DTCS (18-018-03)
Paint & Coatings
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Transit Film Removal (23-043-04)
Passive Restraints
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
- Seat Belt Cinch Bar Service (08-010-03)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Rear Stabilizer Bar (02-004-02)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Seat Belt Cinch Bar Service (08-010-03)
Starter
- Flash: DRIVEABILITY Improvements (18-024-05)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Steering Column Click Sound (19-007-02)
Steering Gear
- Whistling Sound When The Steering Wheel Is Turned (19-001-04)
Steering Linkage
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Suspension Control Systems
- Rear Stabilizer Bar (02-004-02)
System
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash: DRIVEABILITY Improvements (18-024-05)
- Flash: Engine Sag Or Rough Idle Or Vehicle Surge At Engine Speeds Around 3000 Rpm (18-020-04)
- New Spark Plug For 2.4L Engine (08-034-03)
- Engine Overheat (07-001-03)
- Flash: Long Crank No Start/Mil Illumination (18-029-02)
- Slight Engine Mis-Fire Above 5200 Rpm (18-029-03)
- Mil Illumination, Erroneous Diagnostic Trouble Codes DTCS (18-018-03)
- Interior/Exterior Lamps Flicker (18-016-03)
- Flash Programming Failure Recovery (18-32-98)
Transmission Control Systems
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Transmission Delayed Engagement (21-007-04)
- Transmission Harsh 4-3 Downshift (21-006-03 REV. A)
- Flash Programming Failure Recovery (18-32-98)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
- Chrome Wheel Care (22-01-99)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
- The Rear Window Washer Nozzle May Leak (08-021-02)