Powertrain Diagnostic Procedures - Component Testing
- Sentry Key Immobilizer - Symptoms
- Symptom List: ANTENNA FAILURE; COP FAILURE; EEPROM FAILURE; INTERNAL FAULT; RAM FAILURE; SERIAL LINK INTERNAL FAULT; STACK OVERFLOW FAILURE
- Symptom List: PCM STATUS FAILURE; SERIAL LINK EXTERNAL FAULT
- Symptom List: ROLLING CODE FAILURE; VIN MISMATCH
- Symptom List: TRANSPONDER COMMUNICATION FAILURE; TRANSPONDER CYCLIC REDUNDANCY CHECK (CRC) FAILURE; TRANSPONDER ID MISMATCH; TRANSPONDER RESPONSE MISMATCH
- Starting - Symptoms
- Symptom: *CHECKING FUEL DELIVERY
- Symptom: *CHECKING FUEL PRESSURE LEAK DOWN
- Symptom: *CHECKING HARD START (FUEL DELIVERY SYSTEM)
- Symptom: *ENGINE CRANKS DOES NOT START - 1.6L
- Symptom: *ENGINE CRANKS DOES NOT START - 2.0L/2.4L
- Symptom: *NO CRANK CONDITION 1.6L
- Symptom: *NO CRANK CONDITION 2.0L/2.4L
- Symptom: *NO RESPONSE FROM PCM WITH A NO START CONDITION
- Symptom: *START AND STALL CONDITION 1.6L
- Symptom: *START AND STALL CONDITION 2.0L/2.4L
- Verification Test
- Component Locations
- Powertrain And Skim
- Control And Solenoids
- Throttle Body And Component Locations (2.0L/2.4L)
- Generator Location (1.6L)
- Generator and 1/1 O2 Sensor Locations (2.0L/2.4L)
- ETC Assembly And Ignition Coil Locations (1.6L)
- MAP Sensor And Ignition Coil Location (2.0L/2.4L)
- EVAP Purge Solenoid Location (2.0L/2.4L)
- NVLD Location (2.0L/2.4L)
- Speed Control Servo Locations (2.0L/2.4L)
- Speed Control Servo And Solenoids Component Locations (2.4L Turbo Only)
- Data Link Connector
- Sensors
- Battery Temperature Sensor Location (2.0L/2.4L)
- CKP Sensor Location (1.6L)
- CKP Sensor Location (2.0L/2.4L)
- CMP Sensor Location (2.0L/2.4L)
- Coolant Temperature Sensor Location (2.0L/2.4L)
- ECT Sensor Location (1.6L)
- IAT Sensor Location (2.0L/2.4L)
- Knock Sensor Location (1.6L)
- Knock Sensor Location (2.4L)
- MAP Sensor And Injectors Locations (1.6L)
- MAP Sensor Location (2.0L/2.4L)
- MAP Sensor Location (2.4L Turbo Only)
- APP Sensor Location (1.6L)
- O2 Sensors Location (1.6L)
- VSS Location
- Fuel System
- Relays
- Switches
- Connector PINOUTS
- A/C Compressor Clutch (Gas) - Black 2 Way
- A/C Low Pressure Switch - DK. Green 2 Way
- A/C Pressure Transducer - 2 Way
- Accelerator Pedal Position Sensor (1.6L/Diesel) - 10 Way
- Ambient Temperature Sensor (Except 2.4L Base) - Black 2 Way
- Ambient Temperature Sensor (NGC) - Black 2 Way
- Brake Lamp Switch (Gas) - Gray 6 Way
- Camshaft Position Sensor (Diesel) - Black 3 Way
- Camshaft Position Sensor (Gas) - Black 3 Way
- Clutch Pedal Position Switch (Up) - Black 3 Way
- Crankshaft Position Sensor (Gas) - Black 3 Way
- Data Link Connector - Black 16 Way
- EGR Solenoid (Diesel) - 2 Way
- Engine Coolant Temperature Sensor (Diesel) - Black 2 Way
- Engine Coolant Temperature Sensor (Gas) - Black 2 Way
- Engine Oil Pressure Switch - LT. Green 2 Way
- EVAP/Purge Solenoid (Gas) - Black 2 Way
- Fuel Injector No. 1 (Gas) - Black 2 Way
- Fuel Injector No. 2 (Gas) - Black 2 Way
- Fuel Injector No. 3 (Gas) - Black 2 Way
- Fuel Injector No. 4 (Gas) - Black 2 Way
- Fuel Pump Module - LT. Gray 4 Way
- Generator (2.4L Turbo) - Black 2 Way
- Generator (Gas Except 2.4L Turbo) - Black 2 Way
- Idle Air Control Motor (2.4L) - Black 2 Way
- Ignition Coil (Gas) - Black 3 Way
- Inlet Air Temperature Sensor (Gas) - Black 2 Way
- Knock Sensor (Gas) - Black 2 Way
- Manifold Absolute Pressure Sensor (Gas) - Black 3 Way
- Natural Vacuum Leak Detection Assembly (Except Export) - Black 3 Way
- Oxygen Sensor 1/1 Upstream (Gas) - Black 4 Way
- Oxygen Sensor 1/2 Downstream (Gas) - Black 4 Way
- Powertrain Control Module (1.6L) - Black 90 Way
- Powertrain Control Module C1 (NGC) - Black/Black 38 Way
- Powertrain Control Module C2 (NGC) - Black/Orange 38 Way
- Powertrain Control Module C3 (NGC) - Black/Natural 38 Way
- Powertrain Control Module C4 (NGC) - Black/Green 38 Way
- Radiator Fan Motor (2.4L Turbo) - DK. Gray 4 Way
- Radiator Fan Motor (Except 2.4L Turbo) - Black 3 Way
- Sentry Key Immobilizer Module - Black 6 Way
- Speed Control Servo (2.4L) - Black 4 Way
- Speed Control Switch - Yellow 3 Way
- Surge Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Inlet Pressure Sensor (2.4L Turbo) - Natural 3 Way
- Throttle Inlet Pressure Solenoid (2.4L Turbo) - Black 2 Way
- Throttle Position Sensor (2.4L) - Black 3 Way
- Vehicle Speed Sensor (Gas MTX) - Black 3 Way
- WASTEGATE Solenoid (2.4L Turbo) - Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Vacuum Gauge Reading Examples
- Camshaft Sensor & Crankshaft Sensor Scope Pattern (Typical)
- Accelerator Pedal Position Sensor Specifications (1.6L)
- Camshaft & Crankshaft Sensor Specifications (1.6L)
- Throttle Position Sensor Specifications (1.6L)
- EVAP Tester
- Turbocharger System Circuit Diagrams
- Fuel Gauge Voltage Specifications
- Evaporative Emission System Schematic