Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft System - Coupe
- Description & Operation
- Testing
- Notes
- Communication With Scan Tool Not Possible
- Communication With One-Shot Pulse Input Signal Not Possible
- System Is Not Armed
- Security Indicator Does Not Illuminate After System Is Armed
- Alarms Sounds When Door Or Trunk Lid Is Unlocked Using Key
- No Alarm When Door Is Opened Without Using Key (Avenger & SEBRING Coupe)
- Horn Or Theft Alarm Horn Does Not Sound
- No Alarm When Trunk Lid Is Opened Without Key (Avenger & SEBRING Coupe)
- No Alarm When Hood Is Opened From Inside Vehicle (Avenger & SEBRING Coupe)
- Engine Does Not Start Due To Faulty Theft Alarm System (Avenger & SEBRING Coupe)
- Headlights Do Not Flash When Door Or Trunk Lid Is Opened Without Key Or Hood Opened From Inside Vehicle (Avenger & SEBRING Coupe)
- System Does Not Deactivate After Activation When Door Or Trunk Lid Is Opened Using Key (Avenger & SEBRING Coupe)
- Inspection Of Door/Trunk Lid Key Cylinder Switch Circuit (Avenger & SEBRING Coupe)
- Removal & Installation
- Wiring Diagram
- Door Locks & Trunk Release - Power
- Keyless Entry System - Remote (Coupe)
- Description & Operation
- Programming
- Trouble Shooting
- Component Testing
- Wiring Diagrams
- Anti-Theft System - Coupe
- Cruise Control Systems
- Identification
- Description & Operation
- Self-Diagnostic System
- System Diagnostics
- Service Precautions
- Diagnostic Procedure
- Visual Inspection
- Retrieving Diagnostic Trouble Codes
- Clearing Diagnostic Trouble Codes
- Connector Identification
- Self-Diagnostic Tests - Non-Turbo
- Notes
- DTC Test - Checking System For Diagnostic Trouble Codes
- Test TC-15A - Speed Control Power Relay Circuit & Speed Control Solenoid Circuits
- Test TC-15B - Speed Control Power Relay Circuit & Speed Control Solenoid Circuits
- Test TC-15C - Speed Control Power Relay Circuit & Speed Control Solenoid Circuits
- Test TC-35A - No Vehicle Speed Sensor Signal
- Test TC-35B - No Vehicle Speed Sensor Signal
- Test TC-35C - No Vehicle Speed Sensor Signal
- Test TC-86A - Speed Control Switch Always High
- Test TC-86B - Speed Control Switch Always High
- Test TC-87A - Speed Control Switch Always Low
- Test SC-7A - Checking Speed Control Operation
- Test SC-7B - Checking Speed Control Operation
- Test SC-7C - Checking Speed Control Operation
- Test SC-8A - Checking Speed Control On/Off Switch
- Test SC-10A - Checking Park/Neutral Position Switch
- Test SC-11A - Checking Speed Control Relay Output
- Test SC-VER - Speed Control Verification
- Test VSS-VER - Road Test Verification
- Self-Diagnostic Tests - Turbo
- Input Switch Inspection (Turbo)
- Inactive Trouble Code Condition
- Trouble Symptom Usage
- Notes
- Inspection Procedure No. 1 - No Scan Tool Communication With Any System
- Inspection Procedure No. 2 - No Scan Tool Communication With Speed Control ECM: Speed Control Main Switch Circuit Malfunction
- Speed Control ECM Ground Circuit Malfunction
- Inspection Procedure NO. 3 - No Input Switch Inspection With Scan Tool
- Inspection Procedure No. 4 - Speed Control Does Not Cancel With Brake Pedal Depressed
- Inspection Procedure No. 5 - Speed Control Does Not Cancel With Clutch Pedal Depressed
- Inspection Procedure No. 6 - Speed Control Does Not Cancel With Selector Lever In Neutral
- Inspection Procedure No. 7 - Speed Control Does Not Cancel With Cancel Switch On
- Inspection Procedure No. 8 - Speed Control Cannot Be Set, Scan Tool Test Results Normal
- Inspection Procedure No. 9 - Speed Control Cannot Be Set
- Inspection Procedure No. 10 - Hunting At Set Speed
- Inspection Procedure No. 11 - Speed Control Indicator Off With Main Switch On, Speed Control Functions Normally
- Inspection Procedure No. 12 - No Main Switch Illumination
- Inspection Procedure No. 13 - No Instrument Cluster Control Indicator Illumination
- Inspection Procedure No. 14 - Brake Switch Input Circuit Check, For Input Switch Inspection Code 23
- Inspection Procedure No. 15 - Clutch Switch Input Circuit Check, For Input Switch Inspection Code 26
- Inspection Procedure No. 15 - Park/Neutral Switch Input Circuit Check, For Input Switch Inspection Code 26
- Pin Voltage Tests (Turbo)
- Trouble Shooting
- Notes
- No Speed Control When Set Button Is Pressed & Released
- Speed Control Engages Without Actuating Speed Set Button
- Speed Control Engages When Engine Is Started
- Erratic Speed Or Engine Shuts Off
- Excessive Sag On Hills Or In Trailer Towing
- Speed Control Disengages On Rough Road
- Engine Does Not Return To Normal Idle
- No Resume When Resume Button Is Pressed
- Speed Control Does Not Disengage With Brake Pedal Depressed
- Testing
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Instrument Panel - Analog
- Description & Operation
- Testing
- Notes
- Coolant Temperature Sending Unit Test
- Dimmer Rheostat Test
- Relay Test
- FOGLIGHT Switch Test
- Fuel Gauge Sending Unit Test
- Thermistor Test
- Hazard Warning Switch Test
- Instrument Cluster Gauge Tests
- Rear Defogger Switch Test
- Rear Wiper/Washer Switch Test
- Speedometer Test
- Tachometer Test
- Vehicle Speed Sensor (VSS)
- Wiper/Washer Switch Test
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Analog
- Heated Glass/Defoggers
- Power Mirrors (Coupe)
- Seats
- Steering Column Switches - Coupe
- Window Motors & Regulators
- Power Windows - Coupe
- Description & Operation
- Trouble Shooting
- Component Testing
- Removal & Installation
- Wiring Diagram
- Power Windows - Coupe
- Wiper/Washer Systems
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Anti-Theft System - Coupe
- Description & Operation
- Testing
- Notes
- Communication With Scan Tool Not Possible
- Communication With One-Shot Pulse Input Signal Not Possible
- System Is Not Armed
- Security Indicator Does Not Illuminate After System Is Armed
- Alarms Sounds When Door Or Trunk Lid Is Unlocked Using Key
- No Alarm When Door Is Opened Without Using Key (Avenger & SEBRING Coupe)
- Horn Or Theft Alarm Horn Does Not Sound
- No Alarm When Trunk Lid Is Opened Without Key (Avenger & SEBRING Coupe)
- No Alarm When Hood Is Opened From Inside Vehicle (Avenger & SEBRING Coupe)
- Engine Does Not Start Due To Faulty Theft Alarm System (Avenger & SEBRING Coupe)
- Headlights Do Not Flash When Door Or Trunk Lid Is Opened Without Key Or Hood Opened From Inside Vehicle (Avenger & SEBRING Coupe)
- System Does Not Deactivate After Activation When Door Or Trunk Lid Is Opened Using Key (Avenger & SEBRING Coupe)
- Inspection Of Door/Trunk Lid Key Cylinder Switch Circuit (Avenger & SEBRING Coupe)
- Removal & Installation
- Wiring Diagram
- Door Locks & Trunk Release - Power
- Keyless Entry System - Remote (Coupe)
- Description & Operation
- Programming
- Trouble Shooting
- Component Testing
- Wiring Diagrams
- Anti-Theft System - Coupe
- Power Mirrors (Coupe)
- Seats
- Sun Roof/T-Top/Convertible Top
- Power Windows - Coupe
- Description & Operation
- Trouble Shooting
- Component Testing
- Removal & Installation
- Wiring Diagram
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- Trouble Shooting
- Diagnosis & Testing
- DTC Tests (AWD)
- DTC 11: Faulty Wheel Speed Sensor
- DTC 12: Faulty Wheel Speed Sensor
- DTC 13: Faulty Wheel Speed Sensor
- DTC 14: Faulty Wheel Speed Sensor
- DTC 15: Faulty Wheel Speed Sensor System
- DTC 21: "G" Sensor
- DTC 22: Stoplight Switch Circuit
- DTC 41: Solenoid Valve Circuit
- DTC 42: Solenoid Valve Circuit
- DTC 43: Solenoid Valve Circuit
- DTC 51: Valve Relay
- DTC 52: Motor Relay
- DTC Tests (Fwd)
- DTC 11: Faulty Wheel Speed Sensor
- DTC 12: Faulty Wheel Speed Sensor
- DTC 13: Faulty Wheel Speed Sensor
- DTC 14: Faulty Wheel Speed Sensor
- DTC 15: Faulty Wheel Speed Sensor System
- DTC 16: Power Supply System
- DTC 21: Wheel Speed Sensor Gap
- DTC 22: Wheel Speed Sensor Gap
- DTC 23: Wheel Speed Sensor Gap
- DTC 24: Wheel Speed Sensor Gap
- DTC 38: Stoplight Switch Circuit
- DTC 41: Solenoid Valve System
- DTC 42: Solenoid Valve System
- DTC 43: Solenoid Valve System
- DTC 51: Valve Relay System
- DTC 53: Motor Relay
- Component Testing
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- Bleeding Brake System
- Trouble Shooting
- Diagnosis & Testing
- DTC Tests (AWD)
- DTC 11: Faulty Wheel Speed Sensor
- DTC 12: Faulty Wheel Speed Sensor
- DTC 13: Faulty Wheel Speed Sensor
- DTC 14: Faulty Wheel Speed Sensor
- DTC 15: Faulty Wheel Speed Sensor System
- DTC 21: "G" Sensor
- DTC 22: Stoplight Switch Circuit
- DTC 41: Solenoid Valve Circuit
- DTC 42: Solenoid Valve Circuit
- DTC 43: Solenoid Valve Circuit
- DTC 51: Valve Relay
- DTC 52: Motor Relay
- DTC Tests (Fwd)
- DTC 11: Faulty Wheel Speed Sensor
- DTC 12: Faulty Wheel Speed Sensor
- DTC 13: Faulty Wheel Speed Sensor
- DTC 14: Faulty Wheel Speed Sensor
- DTC 15: Faulty Wheel Speed Sensor System
- DTC 16: Power Supply System
- DTC 21: Wheel Speed Sensor Gap
- DTC 22: Wheel Speed Sensor Gap
- DTC 23: Wheel Speed Sensor Gap
- DTC 24: Wheel Speed Sensor Gap
- DTC 38: Stoplight Switch Circuit
- DTC 41: Solenoid Valve System
- DTC 42: Solenoid Valve System
- DTC 43: Solenoid Valve System
- DTC 51: Valve Relay System
- DTC 53: Motor Relay
- Component Testing
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrument Panel - Analog
- Description & Operation
- Testing
- Notes
- Coolant Temperature Sending Unit Test
- Dimmer Rheostat Test
- Relay Test
- FOGLIGHT Switch Test
- Fuel Gauge Sending Unit Test
- Thermistor Test
- Hazard Warning Switch Test
- Instrument Cluster Gauge Tests
- Rear Defogger Switch Test
- Rear Wiper/Washer Switch Test
- Speedometer Test
- Tachometer Test
- Vehicle Speed Sensor (VSS)
- Wiper/Washer Switch Test
- Removal & Installation
- Wiring Diagrams
- Instrument Panel - Analog
- Starter
- Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling Fan - 4-CYL
- Cooling System (Mechanical)
- Mechanical
- 2.0L Non-Turbo - Engine Code 420A - VIN [Y]
- Engine Identification
- Adjustments
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- 2.0L Non-Turbo - Engine Code 420A - VIN [Y]
- Starter
- Timing Belt Replacement - 2.0L - DOHC (VIN Y)
- Engine Performance
- Adjustment
- Application
- Emissions
- EGR Function Testing - CHRYSLER Cars
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Engine Controls - Pin Voltage Charts - Turbo
- Remove, Overhaul & Install
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Testing - Non-Turbo
- Engine Controls - Basic Testing - Turbo
- Engine Controls - System/Component Tests - Non-Turbo
- Engine Controls - System/Component Tests - Turbo
- Engine Controls - Tests W/Codes - Non-Turbo
- Introduction
- Self-Diagnostic System
- Inactive Trouble Code Condition
- Fuel Pressure Release
- Connector Identification
- Self-Diagnostic Tests
- Diagnostic Trouble Code (DTC) Identification
- Trouble Code Tests
- Test TC-1A - No Cam Signal At Pcm
- Test TC-5A - Charging System Voltage Too Low
- Test TC-6A - Charging System Voltage Too High
- Test TC-6B - Charging System Voltage Too High
- Test TC-10A - Auto Shutdown Relay Control Circuit
- Test TC-11A - Generator Field Not Switching Properly
- Test TC-15A - Speed Control Power Relay & Solenoid Circuits
- Test TC-15C - Speed Control Power Relay & Solenoid Circuits
- Test TC-16A - A/C Clutch Relay Circuit
- Test TC-17A - EGR Solenoid Circuit
- Test TC-18A - EVAP Purge Solenoid Circuit
- Test TC-19A - Injector No. 3 Control Circuit (V6)
- TEST TC-19B - INJECTOR NO. 3 CONTROL CIRCUIT (4-Cyl)
- Test TC-19D - Injector No. 3 Control Circuit
- Test TC-19E - Injector No. 3 Control Circuit
- Test TC-20A - Injector No. 2 Control Circuit
- Test TC-21A - Injector Control Circuit
- Test TC-21B - Injector No. 1 Control Circuit (V6)
- Test TC-21C - Injector No. 1 Control Circuit
- TEST TC-21F - INJECTOR NO. 1 CONTROL CIRCUIT (4-Cyl)
- Test TC-25A - Idle Air Control Motor Circuits
- Test TC-25B - Idle Air Control Motor Circuits
- Test TC-25C - Idle Air Control Motor Circuits
- Test TC-25D - Idle Air Control Motor Circuits
- Test TC-25E - Idle Air Control Motor Circuits
- Test TC-26A - Throttle Position Sensor Voltage Low
- Test TC-27A - Throttle Position Sensor Voltage High
- Test TC-30A - ECT Temperature Sensor Voltage Too Low
- Test TC-31A - ECT Sensor Voltage Too High
- Test TC-32A - Upstream O2 Sensor Stays At Center
- Test TC-35A - No Vehicle Speed Sensor Signal
- Test TC-35B - No Vehicle Speed Sensor Signal
- Test TC-35C - No Vehicle Speed Sensor Signal
- Test TC-36A - Map Sensor Voltage Too Low Or No 5 Volts To Map
- Test TC-37A - Map Sensor Voltage Too High
- Test TC-39A - No Change In Map Sensor From Start To Run
- Test TC-40A - No Crank Reference Signal At Pcm
- Test TC-40B - No Crank Reference Signal At Pcm
- Test TC-41A - Ignition Coil No. 3 Primary Circuit
- Test TC-42A - Ignition Coil No. 2 Primary Circuit
- Test TC-43A - Ignition Coil No. 1 Primary Circuit
- Test TC-44A - No ASD Relay Output Voltage At Pcm
- Test TC-46A - EGR System Failure
- Test TC-57A - Intake Air Temperature Sensor Voltage Low
- Test TC-58A - Intake Air Temperature Sensor Voltage High
- Test TC-59A - Knock Sensor Circuit
- Test TC-61A - Injector No. 4 Control Circuit
- Test TC-62A - Upstream O2 Sensor Shorted To Voltage
- Test TC-69A - Injector No. 5 Control Circuit
- Test TC-69B - Injector No. 5 Control Circuit
- Test TC-70A - Injector No. 6 Control Circuit
- Test TC-83A - Knock Sensor No. 2 Circuit
- Test TC-88A - Manifold Tune Valve Solenoid Circuit
- Test TC-88B - Manifold Tune Valve Solenoid Circuit
- Test TC-92A - Low Speed Fan Control Relay Circuit
- Test TC-93A - High Speed Fan Control Relay Circuit
- Test TC-96A - No CCD Messages From TCM
- Test TC-101A - Fuel Pump Relay Control Circuit
- Test TC-102A - Upstream O2 Sensor Slow Response
- Test TC-103A - Upstream O2 Sensor Heater Failure
- Test TC-105A - Downstream O2 Sensor Heater Failure
- Test TC-106A - Multiple Cylinder Misfire
- Test TC-107A - Cylinder No. 1-6 Misfire
- Test TC-112A - Catalytic Converter Efficiency Failure
- Test TC-113A - EVAP Purge Flow Monitor Failure
- Test TC-113B - EVAP Purge Flow Monitor Failure
- Test TC-114A - Park/Neutral Switch Failure
- Test TC-115A - Power Steering Switch Failure
- Test TC-115B - Power Steering Switch Failure
- Test TC-118A - Fuel System Rich
- Test TC-118B - Fuel System Rich
- Test TC-119A - Fuel System Lean
- Test TC-119B - Fuel System Lean
- Test TC-120A - Right Bank Fuel System Rich
- Test TC-120B - Right Bank Fuel System Rich
- Test TC-121A - Right Bank Fuel System Lean
- Test TC-121B - Right Bank Fuel System Lean
- Test TC-126A - Downstream O2 Sensor Shorted To Voltage
- Test TC-128A - Closed Loop Temp Not Reached
- Test TC-129A - Downstream O2 Sensor Stays At Center
- Test TC-132A - TPS Voltage Does Not Agree With Map
- Test TC-133A - Timing Belt Skipped One Tooth Or More
- Test TC-135A - No 5 Volts To Map Sensor
- Test TC-138A - Target Idle Not Reached
- Test TC-138B - Target Idle Not Reached
- Test TC-139A - High Speed Radiator Fan Control Relay
- Test TC-145A - Vacuum Leak Found (IAC Fully Seated)
- Test TC-146A - 5 Volt Supply Output Too Low
- Test TC-146B - 5-Volt Supply Output Too Low
- Test TC-148A - TORQ CONV CLU No Rpm Drop At Lockup
- Test TC-149B - Fuel Level Sending Unit Volts Too Low
- Test TC-150B - Fuel Level Sending Unit Volts Too High
- Test TC-151B - Fuel Level Unit No Change Over Miles
- Test TC-152A - Brake Switch Sense Circuit
- Test TC-153C - Battery Temp Sensor Voltage Too Low Or Battery
- Test TC-155A - Upstream O2S Voltage Shorted To Ground
- Test TC-156A - Downstream O2S Voltage Shorted To
- Test TC-157A - Intermittent Loss Of CMP Or CKP
- Test TC-157B - Intermittent Loss Of CMP Or CKP
- Test TC-157C - Intermittent Loss Of CMP Or CKP
- Test TC-180A - Right Catalytic Converter Efficiency Failure
- Test TC-183A - Leak Detection Pump Solenoid Circuit
- Test TC-184A - Leak Detection Pump SW Or Mechanical Fault
- Test TC-186A - Misfire Adaptive Numerator At Limit
- No Trouble Code Tests
- Test NTC-1A - No Trouble Codes (NTC) Tests
- Test NTC-2A - Checking Secondary Ignition & Timing
- Test NTC-3A - Checking Fuel Pressure
- Test NTC-3B - Checking Fuel Pressure
- Test NTC-3C - Checking Fuel Pressure
- Test NTC-4A - Checking Coolant Sensor Calibration
- Test NTC-5A - Checking Throttle Position Sensor
- Test NTC-6A - Checking Map Sensor
- Test NTC-7A - Checking Oxygen Sensor Switching
- Test NTC-7B - Checking Oxygen Sensor Switching
- Test NTC-8A - Checking Oxygen Sensor Heater
- Test NTC-9A - Checking Idle Air Control Motor
- Test NTC-10A - Checking Park/Neutral Position Switch
- Test NTC-11A - Checking Pcm Power & Grounds
- Test NTC-12A - Checking Evaporative Emissions Systems
- Test NTC-13A - Checking EGR System
- Test NTC-14A - Checking Engine Vacuum
- Test NTC-15A - Checking Intake Air Temperature Sensor
- Test NTC-17A - Checking Minimum Idle Airflow
- Test NTC-18A - Checking Engine Mechanical Systems
- No Start Tests
- Test NS-1A - Qualifying A No Start Condition
- Test NS-2A - Checking Fuel System
- Test NS-3A - Checking Engine Mechanical Systems
- Test NS-4B - Repairing High Fuel Pressure
- Test NS-4C - Repairing Low Fuel Pressure
- Test NS-5A - Checking Fuel Pump
- Test NS-6A - Repairing No Response Condition
- Test NS-6C - Repairing No Response Condition
- Test NS-7A - Checking Idle Air Control Motor Operation
- Test NS-8A - Repairing A Start & Stall Condition
- Test NS-9A - Repairing A No Crank Condition
- Test NS-9B - Repairing A No Crank Condition
- Verification Tests
- Engine Controls - Tests W/Codes - Turbo
- Introduction
- Self-Diagnostic System
- Diagnostic Trouble Code (DTC) Identification
- Connector Identification
- Component Location
- Self-Diagnostic Tests
- Self-Diagnostic Test Usage Procedures
- DTC Test No. 1 - Volume Airflow Sensor
- DTC Test No. 2 - Barometric Pressure Sensor
- DTC Test No. 3 - Intake Air Temperature Sensor
- DTC Test No. 4 - Engine Coolant Temperature Sensor
- DTC Test No. 5 - Throttle Position Circuit
- DTC Test No. 6 - Excessive Time To Enter Closed Loop
- DTC Test No. 7 - Front Oxygen Sensor
- DTC Test No. 8 - Front Oxygen Sensor Heater
- DTC Test No. 9 - Rear Oxygen Sensor
- DTC Test No. 10 - Rear Oxygen Sensor Heater
- DTC Test No. 11 - Fuel Trim Malfunction
- DTC Test No. 12 - Injector Circuit
- DTC Test No. 13 - Random Misfire
- DTC Test No. 14 - Cylinder Misfire
- DTC Test No. 15 - Knock Sensor
- DTC Test No. 16 - Crankshaft Position Sensor
- DTC Test No. 17 - Camshaft Position Sensor
- DTC Test No. 18 - EGR Malfunction
- DTC Test No. 19 - EGR Solenoid
- DTC Test No. 20 - Catalytic System Efficiency
- DTC Test No. 21 - EVAP Emission Control System
- DTC Test No. 22 - EVAP Purge Solenoid
- DTC Test No. 23 - Vehicle Speed Sensor
- DTC Test No. 24 - Idle Control System
- DTC Test No. 25 - Closed Throttle Position Switch
- DTC Test No. 26 - Transaxle Control System
- DTC Test No. 27 - Transaxle Range Sensor
- DTC Test No. 28 - Transaxle Fluid Temp. Sensor
- DTC Test No. 29 - Turbocharger WASTEGATE Actuator
- DTC Test No. 30 - Turbocharger WASTEGATE Solenoid
- DTC Test No. 31 - Fuel Pressure Solenoid
- DTC Test No. 32 - Ignition Timing Adjustment Circuit
- DTC Test No. 33 - Manifold Differential Pressure Sensor
- DTC Test No. 34 - Generator Fr Terminal Circuit
- DTC Test No. 35 - Transaxle Control System
- DTC Test No. 36 - Solenoid Assembly Malfunction
- Trouble Symptoms
- Trouble Symptom Usage
- Inspection Procedure 1 - No Scan Tool Communication With Any
- Inspection Procedure 2 - No Scan Tool Communication With ECM
- Inspection Procedure 3 - Mil Fails To Illuminate When
- Inspection Procedure 4 - Mil Remains Illuminated At All Times
- Inspection Procedure 5 - Engine Cranks But Will Not Start
- Inspection Procedure 6 - Engine Starts & Dies
- Inspection Procedure 7 - Engine Is Hard Starting
- Inspection Procedure 8 - Unstable Engine Idle Speed
- Inspection Procedure 9 - Engine Idle Speed Is Too High
- Inspection Procedure 10 - Engine Idle Speed Is Too Low
- Inspection Procedure 11 - Engine Stalls At Idle When Engine
- Inspection Procedure 12 - Engine Stalls At Idle When Engine
- Inspection Procedure 13 - Engine Stalls When Accelerating
- Inspection Procedure 14 - Engine Stalls When Decelerating
- Inspection Procedure 15 - Engine Hesitates Or Stumbles
- Inspection Procedure 16 - Engine Vibrates When Accelerating
- Inspection Procedure 17 - Engine Vibrates When Decelerating
- Inspection Procedure 18 - Engine Has Poor Acceleration
- Inspection Procedure 19 - Engine Surges
- Inspection Procedure 20 - Engine Knocks
- Inspection Procedure 21 - Engine Diesels
- Inspection Procedure 22 - Engine Has High Co & HC When Idling
- Inspection Procedure 23 - Power Supply & Ignition Switch
- Inspection Procedure 24 - Fuel Pump System Operation
- Inspection Procedure 25 - IGN Switch Start (St) System (M/T)
- Inspection Procedure 26 - Ignition Switch Start (St) &
- Inspection Procedure 27 - Power Steering Pressure Switch
- Inspection Procedure 28 - A/C Switch & A/C Clutch Relay
- Inspection Procedure 29 - Radiator & A/C Condenser Cooling
- Inspection Procedure 30 - Front Oxygen Sensor System
- Inspection Procedure 31 - Ignition System Circuit
- Inspection Procedure 32 - Scan Tool Inspection Procedure When
- Inspection Procedure 33 - IGN System Inspection Procedure
- Inspection Procedure 34 - Scan Tool Inspection Procedure When
- Inspection Procedure 35 - When Hunting Occurs
- Inspection Procedure 36 - When Engine Idle Speed Is Unstable
- Inspection Procedure 37 - Engine Stalls When Warm & Idling
- Inspection Procedure 38 - When Engine Hesitates, Stumbles Or
- Inspection Procedure 39 - When Surge Occurs
- Inspection Procedure 40 - ECM Power Supply & Ground Circuits
- Inspection Procedure 41 - Fuel Pump Circuit
- Inspection Procedure 42 - Fuel Pump Drive Control Circuit
- Inspection Procedure 43 - Volume Airflow Sensor Circuit
- Inspection Procedure 44 - Throttle Position Sensor Output
- Inspection Procedure 45 - Injector Control Circuit
- Inspection Procedure 46 - Ignition Signal Circuit
- Scan Tool Service Data Inspection Procedure
- Scan Tool Actuator Tests
- Engine Controls - Tests W/O Codes - Non-Turbo
- Engine Controls - Tests W/O Codes - Turbo
- Testing & Diagnosis
- Engine Controls - Basic Testing - Non-Turbo
- Engine Controls - Basic Testing - Turbo
- Engine Controls - System/Component Tests - Non-Turbo
- Engine Controls - System/Component Tests - Turbo
- Engine Controls - Tests W/Codes - Non-Turbo
- Introduction
- Self-Diagnostic System
- Inactive Trouble Code Condition
- Fuel Pressure Release
- Connector Identification
- Self-Diagnostic Tests
- Diagnostic Trouble Code (DTC) Identification
- Trouble Code Tests
- Test TC-1A - No Cam Signal At Pcm
- Test TC-5A - Charging System Voltage Too Low
- Test TC-6A - Charging System Voltage Too High
- Test TC-6B - Charging System Voltage Too High
- Test TC-10A - Auto Shutdown Relay Control Circuit
- Test TC-11A - Generator Field Not Switching Properly
- Test TC-15A - Speed Control Power Relay & Solenoid Circuits
- Test TC-15C - Speed Control Power Relay & Solenoid Circuits
- Test TC-16A - A/C Clutch Relay Circuit
- Test TC-17A - EGR Solenoid Circuit
- Test TC-18A - EVAP Purge Solenoid Circuit
- Test TC-19A - Injector No. 3 Control Circuit (V6)
- TEST TC-19B - INJECTOR NO. 3 CONTROL CIRCUIT (4-Cyl)
- Test TC-19D - Injector No. 3 Control Circuit
- Test TC-19E - Injector No. 3 Control Circuit
- Test TC-20A - Injector No. 2 Control Circuit
- Test TC-21A - Injector Control Circuit
- Test TC-21B - Injector No. 1 Control Circuit (V6)
- Test TC-21C - Injector No. 1 Control Circuit
- TEST TC-21F - INJECTOR NO. 1 CONTROL CIRCUIT (4-Cyl)
- Test TC-25A - Idle Air Control Motor Circuits
- Test TC-25B - Idle Air Control Motor Circuits
- Test TC-25C - Idle Air Control Motor Circuits
- Test TC-25D - Idle Air Control Motor Circuits
- Test TC-25E - Idle Air Control Motor Circuits
- Test TC-26A - Throttle Position Sensor Voltage Low
- Test TC-27A - Throttle Position Sensor Voltage High
- Test TC-30A - ECT Temperature Sensor Voltage Too Low
- Test TC-31A - ECT Sensor Voltage Too High
- Test TC-32A - Upstream O2 Sensor Stays At Center
- Test TC-35A - No Vehicle Speed Sensor Signal
- Test TC-35B - No Vehicle Speed Sensor Signal
- Test TC-35C - No Vehicle Speed Sensor Signal
- Test TC-36A - Map Sensor Voltage Too Low Or No 5 Volts To Map
- Test TC-37A - Map Sensor Voltage Too High
- Test TC-39A - No Change In Map Sensor From Start To Run
- Test TC-40A - No Crank Reference Signal At Pcm
- Test TC-40B - No Crank Reference Signal At Pcm
- Test TC-41A - Ignition Coil No. 3 Primary Circuit
- Test TC-42A - Ignition Coil No. 2 Primary Circuit
- Test TC-43A - Ignition Coil No. 1 Primary Circuit
- Test TC-44A - No ASD Relay Output Voltage At Pcm
- Test TC-46A - EGR System Failure
- Test TC-57A - Intake Air Temperature Sensor Voltage Low
- Test TC-58A - Intake Air Temperature Sensor Voltage High
- Test TC-59A - Knock Sensor Circuit
- Test TC-61A - Injector No. 4 Control Circuit
- Test TC-62A - Upstream O2 Sensor Shorted To Voltage
- Test TC-69A - Injector No. 5 Control Circuit
- Test TC-69B - Injector No. 5 Control Circuit
- Test TC-70A - Injector No. 6 Control Circuit
- Test TC-83A - Knock Sensor No. 2 Circuit
- Test TC-88A - Manifold Tune Valve Solenoid Circuit
- Test TC-88B - Manifold Tune Valve Solenoid Circuit
- Test TC-92A - Low Speed Fan Control Relay Circuit
- Test TC-93A - High Speed Fan Control Relay Circuit
- Test TC-96A - No CCD Messages From TCM
- Test TC-101A - Fuel Pump Relay Control Circuit
- Test TC-102A - Upstream O2 Sensor Slow Response
- Test TC-103A - Upstream O2 Sensor Heater Failure
- Test TC-105A - Downstream O2 Sensor Heater Failure
- Test TC-106A - Multiple Cylinder Misfire
- Test TC-107A - Cylinder No. 1-6 Misfire
- Test TC-112A - Catalytic Converter Efficiency Failure
- Test TC-113A - EVAP Purge Flow Monitor Failure
- Test TC-113B - EVAP Purge Flow Monitor Failure
- Test TC-114A - Park/Neutral Switch Failure
- Test TC-115A - Power Steering Switch Failure
- Test TC-115B - Power Steering Switch Failure
- Test TC-118A - Fuel System Rich
- Test TC-118B - Fuel System Rich
- Test TC-119A - Fuel System Lean
- Test TC-119B - Fuel System Lean
- Test TC-120A - Right Bank Fuel System Rich
- Test TC-120B - Right Bank Fuel System Rich
- Test TC-121A - Right Bank Fuel System Lean
- Test TC-121B - Right Bank Fuel System Lean
- Test TC-126A - Downstream O2 Sensor Shorted To Voltage
- Test TC-128A - Closed Loop Temp Not Reached
- Test TC-129A - Downstream O2 Sensor Stays At Center
- Test TC-132A - TPS Voltage Does Not Agree With Map
- Test TC-133A - Timing Belt Skipped One Tooth Or More
- Test TC-135A - No 5 Volts To Map Sensor
- Test TC-138A - Target Idle Not Reached
- Test TC-138B - Target Idle Not Reached
- Test TC-139A - High Speed Radiator Fan Control Relay
- Test TC-145A - Vacuum Leak Found (IAC Fully Seated)
- Test TC-146A - 5 Volt Supply Output Too Low
- Test TC-146B - 5-Volt Supply Output Too Low
- Test TC-148A - TORQ CONV CLU No Rpm Drop At Lockup
- Test TC-149B - Fuel Level Sending Unit Volts Too Low
- Test TC-150B - Fuel Level Sending Unit Volts Too High
- Test TC-151B - Fuel Level Unit No Change Over Miles
- Test TC-152A - Brake Switch Sense Circuit
- Test TC-153C - Battery Temp Sensor Voltage Too Low Or Battery
- Test TC-155A - Upstream O2S Voltage Shorted To Ground
- Test TC-156A - Downstream O2S Voltage Shorted To
- Test TC-157A - Intermittent Loss Of CMP Or CKP
- Test TC-157B - Intermittent Loss Of CMP Or CKP
- Test TC-157C - Intermittent Loss Of CMP Or CKP
- Test TC-180A - Right Catalytic Converter Efficiency Failure
- Test TC-183A - Leak Detection Pump Solenoid Circuit
- Test TC-184A - Leak Detection Pump SW Or Mechanical Fault
- Test TC-186A - Misfire Adaptive Numerator At Limit
- No Trouble Code Tests
- Test NTC-1A - No Trouble Codes (NTC) Tests
- Test NTC-2A - Checking Secondary Ignition & Timing
- Test NTC-3A - Checking Fuel Pressure
- Test NTC-3B - Checking Fuel Pressure
- Test NTC-3C - Checking Fuel Pressure
- Test NTC-4A - Checking Coolant Sensor Calibration
- Test NTC-5A - Checking Throttle Position Sensor
- Test NTC-6A - Checking Map Sensor
- Test NTC-7A - Checking Oxygen Sensor Switching
- Test NTC-7B - Checking Oxygen Sensor Switching
- Test NTC-8A - Checking Oxygen Sensor Heater
- Test NTC-9A - Checking Idle Air Control Motor
- Test NTC-10A - Checking Park/Neutral Position Switch
- Test NTC-11A - Checking Pcm Power & Grounds
- Test NTC-12A - Checking Evaporative Emissions Systems
- Test NTC-13A - Checking EGR System
- Test NTC-14A - Checking Engine Vacuum
- Test NTC-15A - Checking Intake Air Temperature Sensor
- Test NTC-17A - Checking Minimum Idle Airflow
- Test NTC-18A - Checking Engine Mechanical Systems
- No Start Tests
- Test NS-1A - Qualifying A No Start Condition
- Test NS-2A - Checking Fuel System
- Test NS-3A - Checking Engine Mechanical Systems
- Test NS-4B - Repairing High Fuel Pressure
- Test NS-4C - Repairing Low Fuel Pressure
- Test NS-5A - Checking Fuel Pump
- Test NS-6A - Repairing No Response Condition
- Test NS-6C - Repairing No Response Condition
- Test NS-7A - Checking Idle Air Control Motor Operation
- Test NS-8A - Repairing A Start & Stall Condition
- Test NS-9A - Repairing A No Crank Condition
- Test NS-9B - Repairing A No Crank Condition
- Verification Tests
- Engine Controls - Tests W/Codes - Turbo
- Introduction
- Self-Diagnostic System
- Diagnostic Trouble Code (DTC) Identification
- Connector Identification
- Component Location
- Self-Diagnostic Tests
- Self-Diagnostic Test Usage Procedures
- DTC Test No. 1 - Volume Airflow Sensor
- DTC Test No. 2 - Barometric Pressure Sensor
- DTC Test No. 3 - Intake Air Temperature Sensor
- DTC Test No. 4 - Engine Coolant Temperature Sensor
- DTC Test No. 5 - Throttle Position Circuit
- DTC Test No. 6 - Excessive Time To Enter Closed Loop
- DTC Test No. 7 - Front Oxygen Sensor
- DTC Test No. 8 - Front Oxygen Sensor Heater
- DTC Test No. 9 - Rear Oxygen Sensor
- DTC Test No. 10 - Rear Oxygen Sensor Heater
- DTC Test No. 11 - Fuel Trim Malfunction
- DTC Test No. 12 - Injector Circuit
- DTC Test No. 13 - Random Misfire
- DTC Test No. 14 - Cylinder Misfire
- DTC Test No. 15 - Knock Sensor
- DTC Test No. 16 - Crankshaft Position Sensor
- DTC Test No. 17 - Camshaft Position Sensor
- DTC Test No. 18 - EGR Malfunction
- DTC Test No. 19 - EGR Solenoid
- DTC Test No. 20 - Catalytic System Efficiency
- DTC Test No. 21 - EVAP Emission Control System
- DTC Test No. 22 - EVAP Purge Solenoid
- DTC Test No. 23 - Vehicle Speed Sensor
- DTC Test No. 24 - Idle Control System
- DTC Test No. 25 - Closed Throttle Position Switch
- DTC Test No. 26 - Transaxle Control System
- DTC Test No. 27 - Transaxle Range Sensor
- DTC Test No. 28 - Transaxle Fluid Temp. Sensor
- DTC Test No. 29 - Turbocharger WASTEGATE Actuator
- DTC Test No. 30 - Turbocharger WASTEGATE Solenoid
- DTC Test No. 31 - Fuel Pressure Solenoid
- DTC Test No. 32 - Ignition Timing Adjustment Circuit
- DTC Test No. 33 - Manifold Differential Pressure Sensor
- DTC Test No. 34 - Generator Fr Terminal Circuit
- DTC Test No. 35 - Transaxle Control System
- DTC Test No. 36 - Solenoid Assembly Malfunction
- Trouble Symptoms
- Trouble Symptom Usage
- Inspection Procedure 1 - No Scan Tool Communication With Any
- Inspection Procedure 2 - No Scan Tool Communication With ECM
- Inspection Procedure 3 - Mil Fails To Illuminate When
- Inspection Procedure 4 - Mil Remains Illuminated At All Times
- Inspection Procedure 5 - Engine Cranks But Will Not Start
- Inspection Procedure 6 - Engine Starts & Dies
- Inspection Procedure 7 - Engine Is Hard Starting
- Inspection Procedure 8 - Unstable Engine Idle Speed
- Inspection Procedure 9 - Engine Idle Speed Is Too High
- Inspection Procedure 10 - Engine Idle Speed Is Too Low
- Inspection Procedure 11 - Engine Stalls At Idle When Engine
- Inspection Procedure 12 - Engine Stalls At Idle When Engine
- Inspection Procedure 13 - Engine Stalls When Accelerating
- Inspection Procedure 14 - Engine Stalls When Decelerating
- Inspection Procedure 15 - Engine Hesitates Or Stumbles
- Inspection Procedure 16 - Engine Vibrates When Accelerating
- Inspection Procedure 17 - Engine Vibrates When Decelerating
- Inspection Procedure 18 - Engine Has Poor Acceleration
- Inspection Procedure 19 - Engine Surges
- Inspection Procedure 20 - Engine Knocks
- Inspection Procedure 21 - Engine Diesels
- Inspection Procedure 22 - Engine Has High Co & HC When Idling
- Inspection Procedure 23 - Power Supply & Ignition Switch
- Inspection Procedure 24 - Fuel Pump System Operation
- Inspection Procedure 25 - IGN Switch Start (St) System (M/T)
- Inspection Procedure 26 - Ignition Switch Start (St) &
- Inspection Procedure 27 - Power Steering Pressure Switch
- Inspection Procedure 28 - A/C Switch & A/C Clutch Relay
- Inspection Procedure 29 - Radiator & A/C Condenser Cooling
- Inspection Procedure 30 - Front Oxygen Sensor System
- Inspection Procedure 31 - Ignition System Circuit
- Inspection Procedure 32 - Scan Tool Inspection Procedure When
- Inspection Procedure 33 - IGN System Inspection Procedure
- Inspection Procedure 34 - Scan Tool Inspection Procedure When
- Inspection Procedure 35 - When Hunting Occurs
- Inspection Procedure 36 - When Engine Idle Speed Is Unstable
- Inspection Procedure 37 - Engine Stalls When Warm & Idling
- Inspection Procedure 38 - When Engine Hesitates, Stumbles Or
- Inspection Procedure 39 - When Surge Occurs
- Inspection Procedure 40 - ECM Power Supply & Ground Circuits
- Inspection Procedure 41 - Fuel Pump Circuit
- Inspection Procedure 42 - Fuel Pump Drive Control Circuit
- Inspection Procedure 43 - Volume Airflow Sensor Circuit
- Inspection Procedure 44 - Throttle Position Sensor Output
- Inspection Procedure 45 - Injector Control Circuit
- Inspection Procedure 46 - Ignition Signal Circuit
- Scan Tool Service Data Inspection Procedure
- Scan Tool Actuator Tests
- Engine Controls - Tests W/O Codes - Non-Turbo
- Engine Controls - Tests W/O Codes - Turbo
- Theory and Operation
- Engine Controls - Theory & Operation - Non-Turbo
- Introduction
- Computerized Engine Controls
- Powertrain Control Module (Pcm)
- Input Devices
- Notes
- A/C Switch
- Battery Temperature Sensor
- Battery Voltage
- Brake Switch
- Camshaft Position (CMP) Sensor
- Clutch Switch
- Crankshaft Position (CKP) Sensor
- Cruise Control Switch
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (HO2S)
- Ignition Switch
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Park/Neutral (P/N) Switch
- Serial Communication Interface (SCI) Receive
- Throttle Position (TP) Sensor
- Transmission Overdrive Override (OD/OR) Switch (A/T Models)
- Vehicle Speed Sensor (VSS)
- Output Signals
- Notes
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Direct Ignition System
- Electric EGR Transducer (EET)
- Evaporative Canister Purge Solenoid (EVAP-CPCS)
- Exhaust Gas Recirculation (EGR) Solenoid
- Fuel Injectors
- Fuel Pump Relay
- Generator Field
- Idle Air Control (IAC) Motor
- Ignition Coil
- In-Tank Fuel Pump
- Limp-In Mode
- Malfunction Indicator Light (MIL)
- Radiator Fan Relay
- Serial Communication Interface (SCI) Transmit
- Service Reminder Indicator (SRI) Light
- Shift Indicator Light
- Speed Control Servo
- Tachometer
- Torque Converter Clutch (TCC) Solenoid
- Light
- Transmission Overdrive (OD) Solenoid
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation - Turbo
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Control Unit
- Input Devices
- A/C Switch
- Airflow Sensor Assembly
- Atmospheric (Barometric) Pressure Sensor
- Camshaft Position (CMP) Sensor
- Closed Throttle Position Switch (CTPS)
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Speed (RPM) Signal
- Heated Oxygen Sensor (HO2S)
- Ignition Switch
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Multiport Fuel Injection (MFI) Relay
- Park/Neutral (P/N) Position Switch
- Power Steering Pressure (PSP) Switch
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Volume Airflow (VAF) Sensor
- Output Signals
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation - Non-Turbo
- Vacuum Diagrams - 2.4L 4-CYL.
- Wiring Diagrams - Non-Turbo
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- Air Compressor - Refrigerant Oil Checking
- Cabin Air Filter (Special Applications) - General Information
- HVAC Systems - Compressor Servicing
- HVAC Systems - General Servicing
- HVAC Systems - Specifications
- HVAC Control Systems
- A/C-Heater System - Manual
- Heater System
- HVAC Systems - Basic Trouble Shooting - Manual
- Vacuum Control System Diagnosis
- Actuator Calibration/Diagnostics & Cooldown Test - Fwd Vans
- Notes
- Actuator Calibration
- Diagnostics
- Cooldown Test
- Calibration/Cooldown Led Display Codes
- Calibration/Diagnostics Test Entry
- Cooldown Test Entry
- Calibration/Diagnostics And Cooldown Abort
- EEPROM Data
- Actuator Calibration & Diagnostics
- Blend/Passenger Actuator Background
- Driver Actuator Background
- Manual A/C (HVAC) - Mode Door Operation
- Mode Actuator Background
- Fail Codes/Level Display
- Temperature And Mode Potentiometer Diagnostics
- Fin Sensor Temperature Diagnostics
- Trouble Shooting
- General Servicing
- Maintenance
- Procedures
- Interference Verification Check For OHC Engine
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- Identification Label Locations
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (SRS) Air Bag System
- Anti-Lock Brake System (Abs)
- Battery Warning
- Replacing Blown Fuses
- Brake Pad Wear Indicator
- Catalytic Converter
- Coolant (Propylene-Glycol Formulations)
- Electrostatic Discharge Sensitive (ESD) Parts
- Engine Oil
- Fuel System Service
- Halogen Bulbs
- Radiator Cap
- Radiator Fan
- Turbocharged Models
- Warranty Information
- Notes
- Air Bag Warranty
- Customer One Care Warranty
- Basic New Car Limited Warranty
- Powertrain Warranty
- Corrosion Coverage
- Emission System "Defect" & "Performance" Warranties (Except CALIFORNIA)
- Federal Emissions Warranty
- Emission "Performance" Warranty (CALIFORNIA)
- Emission "Defect" Warranty (CALIFORNIA)
- Roadside Assistance
- Towing
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems - Except SEBRING CONV
- Post-Collision Air Bag Safety Inspection
- Restraints Control Systems
- Seat Belts
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering
- Steering Wheel & Steering Column
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Transmission
- Automatic Trans
- Automatic Transmission - Service Information (Cars)
- Lubrication
- Service Intervals
- Checking Fluid Level
- 41TE Transaxle (Avenger & Sebring Coupe)
- 41TE Transaxle (Breeze, Cirrus, Sebring Convertible & Stratus)
- 42LE Transaxle (Concord, Intrepid, LHS, New Yorker & Vision)
- 31TH Transaxle (Neon)
- 41TE Transaxle (Talon Non-Turbo)
- F4A33 Transaxle (Talon Turbo) & W4A33 Transaxle (Talon Turbo AWD)
- Differential (Concorde, Intrepid, LHS, New Yorker & Vision)
- Transfer Case (Talon Turbo AWD)
- Recommended Fluid
- Fluid Capacities
- Draining & Refilling
- 41TE Transaxle (Avenger, Breeze, Cirrus, Sebring Convertible, Sebring Coupe, Stratus & Talon Non-Turbo)
- 42LE Transaxle (Concord, Intrepid, LHS, New Yorker & Vision)
- 31TH Transaxle (Neon)
- F4A33 Transaxle (Talon Turbo) & W4A33 Transaxle (Talon Turbo AWD)
- Differential (Concorde, Intrepid, LHS, New Yorker & Vision)
- Transfer Case (Talon Turbo AWD)
- Adjustments
- Torque Specifications
- Lubrication
- Automatic Transmission Oil Pan Gasket Id
- Diagnosis - F4A20, F4A30 & W4A30
- Application
- Introduction
- Description
- Operation
- Adjustments
- Trouble Shooting
- Visual Inspection
- Component Trouble Shooting Using Scan Tool
- Throttle Position (TP) Sensor
- Oil Temperature Sensor
- Kickdown Servo Switch
- Ignition Pulse Signal
- Closed Throttle Position Switch
- Air Conditioning Compressor Clutch Relay Signal
- Transaxle Gear Position
- Pulse Generator "A"
- Pulse Generator "B"
- Overdrive Switch
- Power/Economy Switch
- Park/Neutral Position (PNP) Switch
- Vehicle Speed Sensor (VSS)
- PCSV Duty Solenoid
- Torque Converter Clutch Slip
- TCC Solenoid Duty
- Self-Diagnostic System
- Testing
- Notes
- DTC No. 11, 12, 13, 14 (Throttle Position (TP) Sensor)
- DTC No. 15, 16 (Oil Temperature Sensor)
- DTC No. 21, 22 (KICKDOWN Servo Switch)
- DTC No. 23 (Ignition Signal)
- DTC No. 31, 81 (Pulse Generator "A")
- DTC No. 32, 82 (Pulse Generator "B")
- DTC 36, 37 (Park/Neutral Position (PNP) Switch)
- DTC 41, 42, 83 (Shift Control Solenoid Valve "A" (SCSV-A)
- DTC 43, 44, 84 (Shift Control Solenoid Valve "B" (SCSV-B)
- DTC 45, 46, 85 (Pressure Control Solenoid Valve (PCSV)
- DTC 47, 48, 49 (Torque Converter Clutch (TCC) Solenoid)
- DTC 51, 86 (1ST Gear-Incorrect Ratio)
- DTC 52, 86 (2ND Gear-Incorrect Ratio)
- DTC 53, 86 (3RD Gear-Incorrect Ratio)
- DTC 54, 86 (4TH Gear-Incorrect Ratio)
- DTC 59 (Abnormal Vibration)
- DTC 61, 62, 63 (Torque Reduction Request & Execution Signal Lines)
- Component Testing
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Diagnosis - F4AC1 (41TE/AE)
- Application
- Introduction
- Description
- Operation
- Notes
- Transaxle Control Module (TCM)
- Limp-In Mode
- Solenoid Assembly
- Direct Input Devices
- Notes
- Battery Supply Voltage
- Cranking Signal
- Engine Speed Signal
- Ignition Signal
- Input Speed Sensor
- Low-Reverse (L-R), Overdrive (OD) & 2-4 Pressure Switches
- Overdrive Lock-Out Switch (Talon)
- Output Speed Sensor Signal
- Park/Neutral Position (PNP) Switch & Transmission Range Switch
- Throttle Position Sensor (TPS)
- Transmission Range Sensor (TRS)
- CCD Bus Inputs
- Direct Output Devices
- CCD Bus Output Signals
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- Test 1A - Entering 41TE/AE Diagnostic Test
- Test 2A - Retrieving Diagnostic Trouble Codes
- Test 3A - Conditions Needed To Set DTCS
- Test 4A - Shift Lever Status Test (DTC 28)
- Test 5A - Failed Shift Lever Test
- Test 6A - Checking Intermittent DTCS
- Test 7A - Relay Output Always On (DTC 14)
- Test 7B - Relay Always On
- Test 8A - Relay Output Always Off (DTC 15)
- Test 9A - Engine Speed Sensor Circuit (DTC 18)
- Test 10A - Transmission Control Relay Output DTC 21 - Switched Battery)
- Test 11A - Od Pressure Switch Sense Circuit (DTC 21)
- Test 11B - Od Pressure Switch Sense Circuit
- Test 11C - Od Pressure Switch Sense Circuit
- Test 12A - 2-4 Pressure Switch Sense CKT (DTC 22, 23 & 27)
- Test 12B - 2-4 Pressure Switch Sense Circuit
- Test 13A - L-R Pressure Switch Sense Circuit (DTC 24, 25 & 26)
- Test 13B - L-R Pressure Switch Sense Circuit
- Test 14A - Throttle Position (TP) Signal (DTC 29)
- Test 15A - Od Hydraulic Pressure Switch (DTC 31)
- Test 16A & 17A - Od/2-4 Hydraulic Pressure SW (DTC 32 & 33)
- Test 18A - Solenoid Switch Latched In TCC Position (DTC 37)
- Test 19A - Torque Converter Clutch (TCC) Control CKT (DTC 38)
- Test 20A - Speed Ratio Error In Reverse & 1ST (DTC 50 & 51)
- Test 20B - Slipping Clutch Assemblies (DTC 52, 53 & 54)
- Test 20C - Open/Shorted Input Speed Sensor (DTC 56)
- Test 20D - Open/Shorted Output Speed Sensor (DTC 57)
- Test 20E - Open Speed Sensor Ground (DTC 58)
- Test 21A - L-R Solenoid Circuit (DTC 41)
- Test 22A - 2-4 Solenoid Control (DTC 42)
- Test 23A - Od Solenoid Control (DTC 43)
- Test 24A - UD Solenoid Control (DTC 44)
- Test 25A - T3 Sense Circuit
- Test 26A - T1 Sense Circuit
- Test 27A - T41 Sense Circuit
- Test 28A - T42 Sense Circuit
- Test 29A - T41 Sense Circuit
- Test 30A - T42 Sense Circuit
- Test 31A - T1 Sense Circuit
- Test 32A - T1 Sense Circuit
- Test 33A - Transmission Range Sensor (TRS) T3 Sense Circuit
- Test 34A - Transmission Range Sensor (TRS) T1 Sense Circuit
- Test 35A - Transmission Range Sensor (TRS) T41 Sense Circuit
- Test 36A - Transmission Range Sensor (TRS) T42 Sense Circuit
- Test 37A - Transmission Range Sensor (TRS) T41 Sense Circuit
- Test 38A - Transmission Range Sensor (TRS) T42 Sense Circuit
- Test 39A - Transmission Range Sensor (TRS) T1 Sense Circuit
- Test 40A - Transmission Range Sensor (TRS) T3 Sense Circuit
- Test 41A - Intermittent Transmission Range Sensor (TRS) CKT
- Test 41B - Intermittent Transmission Range Sensor (TRS) Circuit
- Test 42A - 3-4 Shift Abort (DTC 46)
- Test 43A - Intermittent Shift Lever Status
- Test 43B - Intermittent Shift Lever Status
- Test 44A - No Response
- Test 45A - Bus Communication With Pcm (DTC 19)
- Test 45B - Bus Communication With Pcm
- Test 45C - Bus Communication With Pcm
- Test 46A - Symptoms & Possible Causes (DTC 60, 61 & 62)
- Test 47A - Back-Up Light Malfunction
- Test 47B - Back-Up Light Malfunction
- Test 48A - TRD Link Communication Error (DTC 48)
- Test 49A - Worn Out/Burnt Transmission Fluid (DTC 73)
- Test 50A - Loss Of Pump Prime (DTC 35)
- Test 51A - AUTOSTICK Sensor Circuit (DTC 70)
- Test 51B - AUTOSTICK Sensor Circuit
- Test 51C - AUTOSTICK Sensor Circuit
- Test 51D - AUTOSTICK Sensor Circuit
- Test 51E - AUTOSTICK Sensor Circuit
- Test 52A - Manual Shift Overheat (AUTOSTICK Vehicles Only - DTC 71)
- Test 54A - O/D Off Switch Circuit Or Loss Of 4TH Gear
- Verification Test VER-1A
- Connector Identification
- Wiring Diagrams
- Overhaul - 41TE & 41AE Automatic Transmission
- Application
- Identification
- Description
- Operation
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Overhaul - 41TE & 41AE Automatic Transmission
- Shift Schedule Operation
- Symptom Diagnosis
- Buzzing Noise
- Buzzing Noise During Transaxle Shifts
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Grating, Scraping Or Growling Noise
- Hard To Fill With Fluid Or Fluid Blows Out Filler Tube
- Harsh Downshifts
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Torque Converter Lock-Up
- Harsh Upshift
- High Shift Efforts
- No Torque Converter Lock-Up
- No Upshift Into Overdrive
- Poor Shift Quality
- Shifts Erratically
- Transaxle Overheats
- Vehicle Drags Or Locks
- Vehicle Moves In Neutral
- Testing
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Bearing Adjustments
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Overhaul - F4A33, W4A32 & W4A33
- Application
- Identification
- Description
- Lubrication
- On-Vehicle Service
- Trouble Shooting
- Symptom Diagnosis
- Notes
- Abnormal Vibration During High Load In Low Gear
- Abnormal Vibration Or Shock When Transaxle Is Shifted Into Forward Or Reverse Gears
- Clutch Slips In Drive & Torque Converter Stall Speed Is Excessive
- Clutch Slips In Reverse & Torque Converter Stall Speed Is Excessive
- Torque Converter Clutch Inoperative
- Engine Starts, Or Vehicle Moves Between Neutral & Reverse Or Neutral & Drive
- Excessive Creeping Or Idling Vibration
- Excessive Vibration During All Upshifts
- Excessive Vibration During D-2 Downshift
- Excessive Vibration During 1-2 Or 3-4 Upshift
- Excessive Vibration During 2-3 Or 4-3 Shift
- Excessive Vibration When Cold
- Overdrive Control Switch Will Not Operate
- Sudden Engine RPM Increase During Upshift
- Sudden Engine RPM Increase During 3-2 Shift With Excessive Vibration
- Torque Converter Stall Speed Is Low
- Transaxle Remains In 3rd Gear
- Transaxle Shifts But Not Within Specified Range
- Transaxle Starts Off From 2nd Gear
- Transaxle Will Not Upshift From 2nd To 3rd Gear
- Transaxle Will Not Upshift Into 4th Gear
- Vehicle Moves In Park Or Neutral
- Vehicle Will Not Hold In Park
- Vehicle Will Not Move Forward
- Vehicle Will Not Move Forward Or Backward
- Vehicle Will Not Move In Reverse
- Symptom Diagnosis
- Testing
- Adjustments
- Torque Converter
- Removal & Installation
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Oil Pump
- Transfer Shaft (F4A33)
- Front Clutch
- Front & Rear Clutch Retaining Ring Identification
- Rear Clutch
- End Clutch
- Planetary Carrier Assembly
- Output Flange & Transfer Drive Gear
- Differential Assembly
- KICKDOWN Servo
- Low-Reverse Brake
- Center Differential Assembly (W4A32 & W4A33)
- Front Output Shaft (W4A32 & W4A33)
- Valve Body Disassembly & Reassembly
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Transmission Removal & Installation - Automatic (Cars)
- Automatic Transmission - Service Information (Cars)
- Clutches
- 41TE & 41AE & F4AC1 (Early) Automatic Transmission - Hydraulic Diagrams
- Manual Trans
- Overhaul - W5M33 & W6MG1
- Application & Labor Times
- Identification
- Description
- Lubrication & Adjustments
- Trouble Shooting
- On-Vehicle Service
- Removal & Installation
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Transaxle Reassembly
- Transaxle Specifications
- Torque Specifications
- Overhaul - W5M33 & W6MG1
- Automatic Trans
- External Pages