Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Intermittent A/C Compressor Or Blower Operation (94-16-7)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- No Start - Repair Shorted/Corroded Engine Wiring (91-16-6)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Accessories Control Systems
- Anti-Lock Brakes
- Anti-Theft Systems
- Cargo Area/Liftgate Hinge Pop/Snap - Modify Hinge (91-18-2)
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- White Appearance On Sun Roof W/Strip: New W/Strip (90-5-3)
- Key Stuck In Liftgate Lock - New Lock Cylinder Lever (90-25-6)
- No Start/Battery Drained - Key/Doors/Hood/Liftgate (90-22-8)
- Key Stuck In Liftgate Lock - Replace Rear Latch ASSY (90-8-6)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- Transmission Fluid Usage Chart (98-8-8)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Fluid Leakage From Outer CV Joint Boot (96-25-16)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Electronic Transmission Repair Process Chart (91-6-4)
- 4EAT Transaxle : Parts List Update (90-26-10)
- 4EAT Shift Display Intermittent/No 3-4 Or 2-1 Shift (90-4-8)
- 4EAT Trans Delayed 2-3 Shift - Oil Pump Spool Valve (90-16-6)
- 4EAT Trans Delayed 2-3 Shift - Oil Pump Spool Valve (90-10-10)
- Auxiliary Emission Control Systems
- 2.2L Turbo Intermittent Malfunction Indicator Light (95-3-5)
- High Cold Idle Rpm (3.0L,4EAT): New Pcm (93-3-6)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- 3.0L Eng False Code 41/173 Stored - Disconnect Batt (91-8-11)
- 3.0L Eng Vibration/Boom At Idle - RDDIATOR Mount (90-22-14)
- 3.0L Eng 3-Digit Trouble Codes - Use 1991 Diag Info (90-18-5)
- 2.2L Eng Intermittent CKECK Engine Light (90-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Intermittent A/C Compressor Or Blower Operation (94-16-7)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- 3.0L "Lx" Engine Trip Computer Inaccurate: Resistor (90-5-5)
- Interior Windows Fogging & Moisture Condensation:Adj (90-5-2)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- High Cold Idle Rpm (3.0L,4EAT): New Pcm (93-3-6)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Rough Idle - Check Fuel/Ignition System (91-22-4)
- 3.0L Eng Vibration/Boom At Idle - RDDIATOR Mount (90-22-14)
- 3.0L Eng Oil Leak - New Oil Filter Mounting Insert (90-16-4)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 2.2L Turbo Intermittent Malfunction Indicator Light (95-3-5)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- High Cold Idle Rpm (3.0L,4EAT): New Pcm (93-3-6)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- 3.0L Eng False Code 41/173 Stored - Disconnect Batt (91-8-11)
- 3.0L Eng 3-Digit Trouble Codes - Use 1991 Diag Info (90-18-5)
- 2.2L Eng Intermittent CKECK Engine Light (90-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Entertainment Systems
- Exterior Body Panels
- Modified Tail Lamp Gasket Installation (91-24-2)
- New Fuel Filler Cap Part Numbers (91-21-2)
- Water Leaks/Wind Noise - Inspection/Sealing (91-8-6)
- White Appearance On Sun Roof W/Strip: New W/Strip (90-5-3)
- Key Stuck In Liftgate Lock - New Lock Cylinder Lever (90-25-6)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 1.8/2.2L Eng Hard Start/Poor Idle/Stalls - Air Tube (94-10-6)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- High Cold Idle Rpm (3.0L,4EAT): New Pcm (93-3-6)
- Rough Idle - Check Fuel/Ignition System (91-22-4)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- SPEEDOMTR Modules/Cluster-PSOM Replacement Available (93-12-9)
- False Safety Belt Warning Light/Chime - New Sensors (91-12-7)
- New Digital Speedometer With Preset Odometer (91-8-14)
- 3.0L "Lx" Engine Trip Computer Inaccurate: Resistor (90-5-5)
- Low Coolant Message Incorrectly Displayed - Module (90-24-7)
- Analog Oil Pressure Gauge Parts (90-14-9)
- Trip Computer Inaccurate - New Display Assembly (90-10-6)
- Wrong Trip Computer Displays - Modify Circuit Board (90-3T-12)
- Analog Speedo/Odometer Replacement Revisions (90-8-13)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Intermittent A/C Compressor Or Blower Operation (94-16-7)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C Condensation Leak In Car - Drain Hose Or Baffle (92-4-5)
- A/C Leaks Water Onto Carpets - New Evaporator Seal (92-2-5)
- Window Fogging/Condensation - RECIRC/Fresh Cable Adj (91-17-3)
- No Start - Repair Shorted/Corroded Engine Wiring (91-16-6)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Interior Windows Fogging & Moisture Condensation:Adj (90-5-2)
- A/C "O" Ring Usage Table (90-14-8)
- Loss Of Temperature Control - Spring Washer Retainer (90-3-7)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Modified Tail Lamp Gasket Installation (91-24-2)
- Front Window Noise/Water Leak - Revised Repair (90-22-2)
- Cargo Area/Liftgate Hinge Pop/Snap - Modify Hinge (91-18-2)
- Water Leaks/Wind Noise - Inspection/Sealing (91-8-6)
- White Appearance On Sun Roof W/Strip: New W/Strip (90-5-3)
- Interior Water Leaks - Seal Cowl/A-Pillars (90-9-2)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 3.0L Eng Oil Leak - New Oil Filter Mounting Insert (90-16-4)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Manual Steering
- Manual Trans
- Mechanical
- 3.0L 2V (VULCAN) - Revised Oil Pan Gasket Replacement Procedure (99-18-3)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- 1.8/2.2L Eng Hard Start/Poor Idle/Stalls - Air Tube (94-10-6)
- High Cold Idle Rpm (3.0L,4EAT): New Pcm (93-3-6)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- 3.0L Eng Oil Leak - Rear Camshaft Core Plug (91-7-8)
- 2.2L Eng Tappet Noise - New Rocker Arms (90-26-8)
- 2.2L EFI Vibration/Whine - Engine/Radiator Mounts (90-23-4)
- 3.0L Eng Oil Leak - New Oil Filter Mounting Insert (90-16-4)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Mechanical - Hydraulic
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Front Brake Grinding On Moderate To Heavy Braking (93-24-7)
- Rear Disc Brake Squeal - New Rear Disc Brake Pads (91-3-4)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Modified Tail Lamp Gasket Installation (91-24-2)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Water Leaks/Wind Noise - Inspection/Sealing (91-8-6)
- White Appearance On Sun Roof W/Strip: New W/Strip (90-5-3)
- New Lower Body Stone Guard Decals (90-25-5)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Interior Water Leaks - Seal Cowl/A-Pillars (90-9-2)
- 1990 Ford Probe Exterior Color Codes: Touch-Up Paint (90-1-1)
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- Safety Belt Locks Too Easily - New Retractor ASSY. (92-11-4)
- False Safety Belt Warning Light/Chime - New Sensors (91-12-7)
- 2.2L Eng 4EAT Trans Idle Vibration/Whine (91-11-3)
- Passive Restraint Belt Stays In "B" Pillar Position (90-26-2)
- 2.2L EFI Vibration/Whine - Engine/Radiator Mounts (90-23-4)
- Door Glass Popping Noise When Lowering (90-17-3)
- Front Door Rattle With Window 1/2 Way Down (90-2-2)
- Sleeper
- Solar Ventilation
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Modified Tail Lamp Gasket Installation (91-24-2)
- Cargo Area/Liftgate Hinge Pop/Snap - Modify Hinge (91-18-2)
- White Appearance On Sun Roof W/Strip: New W/Strip (90-5-3)
- New Lower Body Stone Guard Decals (90-25-5)
- Door Glass Popping Noise When Lowering (90-17-3)
- Front Door Rattle With Window 1/2 Way Down (90-2-2)
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 2.2L Turbo Intermittent Malfunction Indicator Light (95-3-5)
- 1.8/2.2L Eng Hard Start/Poor Idle/Stalls - Air Tube (94-10-6)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- High Cold Idle Rpm (3.0L,4EAT): New Pcm (93-3-6)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Rough Idle - Check Fuel/Ignition System (91-22-4)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- 3.0L Eng False Code 41/173 Stored - Disconnect Batt (91-8-11)
- 3.0L Eng Vibration/Boom At Idle - RDDIATOR Mount (90-22-14)
- 3.0L Eng 3-Digit Trouble Codes - Use 1991 Diag Info (90-18-5)
- 2.2L Eng Intermittent CKECK Engine Light (90-14-7)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Towing
- Transfer Case
- Transmission Control Systems
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- New Generation "Star Tester": Proper Connection (93-2-4)
- Electronic A/T (E4OD,AXODE,4EAT) Diagnostic Chart (92-1A-1)
- No Crank - Low State Of Battery Charge (91-10-8)
- 4EAT Shift Display Intermittent/No 3-4 Or 2-1 Shift (90-4-8)
- 4EAT Trans Self Test Diagnosis Procedure (90-2-6)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Front Suspension Knocking Noise When Turning (94-13-4)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- New "DACROTIZED" Balanced Weights Availability (90-19-8)
- Aluminum Rims Leak Air - Inspection/Hot Melt Sealant (89-17-3)
- Alum Wheel Leaks Air - Hot Melt Wheel Repair Info (89-9T-6)
- Aluminum Wheel Air Leak - Use Hot Melt-Stick On Leak (89-9T-6)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Modified Tail Lamp Gasket Installation (91-24-2)
- Front Window Noise/Water Leak - Revised Repair (90-22-2)
- Cargo Area/Liftgate Hinge Pop/Snap - Modify Hinge (91-18-2)
- Water Leaks/Wind Noise - Inspection/Sealing (91-8-6)
- Front Window Rattle - Insulate Center Bracket (91-1-2)
- Key Stuck In Liftgate Lock - New Lock Cylinder Lever (90-25-6)
- New Lower Body Stone Guard Decals (90-25-5)
- Door Glass Popping Noise When Lowering (90-17-3)
- Interior Water Leaks - Seal Cowl/A-Pillars (90-9-2)
- Front Door Rattle With Window 1/2 Way Down (90-2-2)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- No Crank - Low State Of Battery Charge (91-10-8)
- 3.0L "Lx" Engine Trip Computer Inaccurate: Resistor (90-5-5)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring Diagram Symbols Explanation (85-11-5)