Automatic Transmission
- Component Location
- Specifications
- General Specifications
- End Play Specifications
- Torque Converter End Play
- Band Adjustment And Torque Chart
- Selective Snap Rings
- Service Identification Model Chart
- Solenoid Operation Chart
- Band And Clutch Application Chart A
- Band And Clutch Application Chart B
- Line Pressure Chart
- Stall Speed Chart
- Shift Speeds
- Torque Specifications
- Description And Operation
- Transmission Description
- Identification Tags
- Range Selection
- Shift Patterns
- Disassembled Views
- Torque Converter
- GEARTRAIN
- Apply Components
- Hydraulic System
- Transmission Electronic Control System
- Electronic System Description
- Powertrain Control Module (PCM)
- Air Conditioning (A/C) Clutch
- Brake Pedal Position (BPP) Switch
- Engine Coolant Temperature (ECT) Sensor
- Electronic Ignition (El) System
- Intake Air Temperature (IAT) Sensor
- Mass Air Flow (MAF) Sensor
- Transmission Control Switch (TCS)
- Transmission Control Indicator Lamp (TCIL)
- Throttle Position (TP) Sensor
- Digital Transmission Range (TR) Sensor
- Turbine Shaft Speed (TSS) Sensor
- Output Shaft Speed (OSS) Sensor
- Intermediate Shaft Speed Sensor
- Pressure Control Solenoids (PCA, PCB, PCC)
- Torque Converter Clutch (TCC) Solenoid
- Shift Solenoids - (SSA, SSB, SSC, SSD)
- Transmission Fluid Temperature (TFT) Sensor
- Transmission Cooling
- External Controls
- Diagnosis And Testing
- Preliminary Inspection
- Road Testing Vehicle
- Shift Point Road Test
- Torque Converter Diagnosis
- Visual Inspection
- Diagnostics
- Output State Control (OSC) Mode
- Notes
- Output State Control (OSC) Procedures
- OSC - Transmission Bench Modes
- SSA, SSB, SSC, SSD and TCC in BENCH MODE
- PCA, PCB, PCC in BENCH MODE
- BENCH MODE Procedure for PCx
- OSC - Transmission DRIVE MODES
- GEAR in DRIVE MODE
- DRIVE MODE Procedure for GEAR
- TCC in DRIVE MODE
- Drive Mode Procedures for TCC
- FIRM_SFT in DRIVE MODE
- Using Output State Control (OSC) and Accessing PIDs
- Transmission Drive Cycle Test
- Diagnostic Trouble Code Charts
- Rotunda Transmission Tester
- Transmission Connector Layouts
- Pinpoint Tests - OSC Equipped Vehicles
- Special Tool(s)
- Shift Solenoid Pre-Diagnosis
- Shift Solenoid Failure Mode Chart
- Pinpoint Tests
- Pinpoint Test A: Shift and Torque Converter Clutch Solenoids
- Pinpoint Test B: Transmission Fluid Temperature (TFT) Sensor
- Pinpoint Test C: Digital Transmission Range (TR) Sensor
- Pinpoint Test D: Pressure Control (PC) Solenoids (PCA, PCB, PCC)
- Pinpoint Test E: Turbine Shaft Speed (TSS), Intermediate Shaft and Output Shaft Speed (OSS) Sensors
- Pinpoint Test F: Solenoid Mechanical Failure
- Special Testing Procedures
- Leakage Inspection
- Transmission Fluid Cooler
- Diagnosis By Symptom
- Special Tool(s)
- Diagnosis by Symptom Index
- Diagnosis by Symptom Index - Directions
- Diagnostic Routines
- Engagement Concern: No Forward in (D) Only (201A)
- Engagement Concern: No Forward (201B)
- Engagement Concern: No Reverse (202)
- Engagement Concern: Harsh Reverse ONLY (203)
- Engagement Concern: Harsh Forward ONLY (204A)
- Engagement Concern: Harsh Manual 1st Gear ONLY (204B)
- Engagement Concern: Delayed or Soft Reverse ONLY (205)
- Engagement Concern: Delayed/Soft Forward ONLY (206)
- Engagement Concern: No Forward and No Reverse (207)
- Engagement Concern: Harsh Forward and Harsh Reverse (208)
- Engagement Concern: Delayed Forward and Delayed Reverse (209)
- Shift Concern: Some/All Shifts Missing (Automatic Mode Only) - (210)
- Shift Concern: Timing Concerns - Early/Late (211)
- Shift Concern: Timing Concerns - Erratic/Hunting (Some/All) (212)
- Engagement Concern: Feel - Soft/Slipping (Some/All) (213)
- Shift Concern: Feel - Harsh (Some/All) (214)
- Shift Concern: No 1st and 2nd Gear in Drive, Engages in a Higher Gear (215)
- Engagement Concern: No 1st Gear in Manual 1 Position (216)
- Shift Concern: No 2nd Gear in Manual 2 Position (217)
- Torque Converter Operation Concerns: Does Not Apply (240)
- Torque Converter Operation Concern: Always Applied/Stalls Vehicle (241)
- Torque Converter Operation Concern: Cycling/Shudder/Chatter (242)
- Other Concerns: Shift Lever Efforts High (251)
- Other Concerns: External Leaks (252)
- Other Concern: Vehicle Driveability (253)
- Other Concern: Noise/Vibration - Forward or Reverse (254)
- Other Concern: Engine Will Not Crank (255)
- Other Concern: No Park Range (256)
- Other Concern: Transmission Overheating (257)
- Other Concern: No Engine Braking in Manual 3rd Position (280)
- Other Concern: No Engine Braking in Manual 4th (D) Position (281)
- Other Concerns: No Engine Braking in Manual 2nd Position (258)
- Other Concern: No Engine Braking in Manual 1st Position (259)
- Other Concerns: Fluid Venting/Foaming (261)
- Other Concern: Vehicle Movement With Gear Selector In N Position (262)
- Other Concern: Slips/Chatters in Manual 1st Position (263)
- Other Concern: Slips/Chatters in Manual 2nd Position (264)
- Other Concern: Slip/Chatters in Manual 3rd Position (282)
- Other Concern: Engine Braking in ALL Gears (283)
- Other Concern: No 2nd And 5th Gears (284)
- Other Concern: No 3rd, 4th and 5th Gears (285)
- Shift Concern: Harsh 1-2 Shift (232)
- Shift Concern: Harsh 2-3 Shift (233)
- Shift Concern: Harsh 3-4 Shift (234)
- Shift Concerns: Harsh 4-5 Shift (274)
- Shift Concern: Harsh 5-4 Shift (275)
- Shift Concern: Harsh 4-3 Shift (235)
- Shift Concern: Harsh 3-2 Shift (236)
- Shift Concern: Harsh 2-1 Shift (237)
- Shift Concern: No 1-2 Shift (220)
- Shift Concern: No 2-3 Shift (221)
- Shift Concern: N0 3-4 Shift (222)
- Shift Concern: No 4-5 Shift (270)
- Shift Concern: No 5-4 Shift (271)
- Shift Concern: No 4-3 Shift (223)
- Shift Concern: No 3-2 Shift (224)
- Shift Concern: No 2-1 Shift (225)
- Shift Concern: Soft/Slipping 1-2 Shift (226)
- Shift Concern: Soft/Slipping 2-3 Shift (227)
- Shift Concern: Soft/Slipping 3-4 Shift (228)
- Shift Concern: Soft/Slipping 4-5 Shift (272)
- Shift Concern: Feel - Soft/Slipping 5-4 Shift (273)
- Shift Concern: Feel - Soft/Slipping 4-3 Shift (229)
- Shift Concern: Soft/Slipping 3-2 Shift (230)
- Shift Concern: Feel - Soft/Slipping 2-1 Shift (231)
- Transmission Cooling
- External Controls
- Notes
- Shift Interlock System
- Transmission Control Switch (TCS)
- Inspection and Verification
- Symptom Chart
- Pinpoint Tests
- Pinpoint Tests G: Shift Interlock System Does Not Release/Lock Correctly
- Pinpoint Test H: Shift Control is Out of Correct Gear Relationship
- Pinpoint Test I: Transmission Control Switch (TCS) Is Not Operating Correctly
- Pinpoint Test J: Transmission Control Indicator Lamp (TCIL) Does Not Illuminate
- Pinpoint Test K: Transmission Control Indicator Lamp (TCIL) Stays Illuminated
- General Procedures
- In-Vehicle Repair
- Fluid Pan, Gasket And Filter
- Main Control Valve Body
- Special Tool
- Material
- Removal And Installation
- Notes
- Item 22: Main Control Valve Body Installation Note
- Item 19, 20 and 21: Main Control Valve Body Screws Installation Note
- Item 15: Reverse Servo Screws Installation Note
- Item 14: Solenoid Body O-rings Seals Installation Note
- Items 11, 12 and 13: Solenoid Body and Screws Installation Note
- Item 10: Transmission Fluid Pan Filter Installation Note
- Item 7: Transmission Fluid Pan Installation Note
- Item 6: Transmission Fluid Pan Screws Installation Note
- Item 5: Solenoid Body Harness Electrical Connector Installation Note
- Extension Housing Seal - 4 x 2
- Extension Housing Seal - 4X4
- Extension Housing Gasket - 4X2
- Extension Housing Gasket - 4X4
- Solenoid Body Assembly
- Digital Transmission Range (Tr) Sensor
- Reverse Servo Assembly
- Park System
- Special Tool
- Material
- Removal
- Installation
- Notes
- Item 2: Manual Control Valve Detent Inner Lever Installation Note
- Item 3: Manual Control Lever Shaft Installation Note
- Item 4: Manual Control Lever Inner Nut Installation Note
- Item 5: Manual Control Lever Shaft Retaining Pin Installation Note
- Item 6: Manual Control Lever Inner Nut Installation Note
- Item 7: Manual Valve Detent Spring Installation Note
- Item 13: Extension Housing Installation Note
- Item 15: Transmission Fluid Filter Installation Note
- Item 18: Transmission Fluid Pan Installation Note
- Item 19: Transmission Fluid Pan Screws Installation Note
- Item 21: TR Sensor Installation Note
- Item 22: TR Sensor Screws Installation Note
- Item 26: TR Sensor Electrical Connector Installation Note
- Transmission Support Insulator - 4X2
- Transmission Support Insulator - 4X4
- Turbine Shaft Speed (TSS) Sensor
- Output Shaft Speed (OSS) Sensor
- Intermediate Shaft Speed Sensor
- Transmission Fluid Cooler
- Special Tool(s)
- Removal And Installation
- Notes
- Item 1: Side Air Deflector Removal Note
- Item 2: Lower Air Deflector Removal Note
- Item 3: Transmission Fluid Cooler Hose Fittings Removal Note
- Item 11. Transmission Fluid Cooler Line bracket Installation Note
- Item 3: Transmission Fluid Cooler Hose Fittings Installation Note
- Item 1: Side Air Deflector Installation Note
- Brake Shift Interlock Actuator
- Transmission Selector Lever
- Transmission Selector Cable
- Removal
- Transmission - 4X2
- Transmission - 4X4
- Special Tool(s)
- Removal and Installation
- Notes
- Item 13: Transmission Assembly Removal Note
- Item 36: Torque Converter Nuts Removal Note
- Item 42: Solenoid Body Harness Connector Removal Note
- Item 47: Fluid Cooler Nuts Removal Note
- Item 48: Transmission Assembly Removal Note
- Item 50: Fuel Line Bracket Removal Note
- Item 52: Transmission Assembly Removal Note
- Disassembly
- Transmission
- Special Tool(s)
- Disassembly
- Notes
- Item 1: Torque Converter Disassembly Note
- Item 2: Transmission Case Disassembly Note
- Item 10: Output Shaft Seal (4x2) Disassembly Note
- Item 12: Extension Housing (4x2) Disassembly Note
- Item 13: Output Shaft Seal (4x4) Disassembly Note
- Item 15: Extension Housing (4x4) Disassembly Note
- Item 28: Reverse Servo Piston and Cover Assembly Disassembly Note
- Item 31: Solenoid Body Disassembly Note
- Item 36: Front Pump Fluid Seal Disassembly Note
- Item 37 and 38: Band Adjusting Locknut and Screw Disassembly Note
- Item: 39: Band and Anchor Strut Disassembly Note
- Item 40: Front Pump Screws Disassembly Note
- Item 41: Front Pump Disassembly Note
- Item 43: Intermediate Servo Retaining Ring Disassembly Note
- Item 47: Overdrive Servo Cover Retaining Ring Disassembly Note
- Item 52: Band Apply Strut Disassembly Note
- Item 53: Overdrive Intermediate Band Disassembly Note
- Item 55: Overdrive Planetary Gear Carrier Disassembly Note
- Item 58: Center Shaft and Forward Clutch Cylinder Bearing Assembly No. 3 Disassembly Note
- Item 59: Center Support Bolt Disassembly Note
- Item 62: Center Support Assembly Disassembly Note
- Item 62: Center support Assembly Inspection Note
- Item 63: Intermediate Clutch Drum Bearing (Select Fit) No. 4 Disassembly Note
- Item 64: Band Anchor Strut Disassembly Note
- Item 65: Overdrive Intermediate Band Disassembly Note
- Item 66: Band Apply Strut Disassembly Note
- Item 68: Intermediate Brake Drum Assembly Disassembly Note
- Item 69: Center Shaft and Forward Clutch Cylinder Bearing Assembly No. 5 Disassembly Note
- Item 70: Forward Clutch Cylinder Assembly Disassembly Note
- Item 71: Forward Ring Gear Hub Thrust Bearing No. 6A Disassembly Note
- Item 72 and 73: Forward Ring Gear and Hub Assembly and Forward Clutch Hub Thrust Washer No. 6B Disassembly Note
- Item 74: Forward Planetary Thrust Bearing Assembly No. 7 Disassembly Note
- Item 78: Center Shaft and Forward Clutch Cylinder Bearing Assembly No. 8 Disassembly Note
- Item 81: Center Shaft and Forward Clutch Cylinder Bearing Assembly No. 9 Disassembly Note
- Item 82: Output Shaft Sleeve Disassembly Note
- Item 83: Output Shaft Retaining Ring Disassembly Note
- Item 86: Reverse Band Actuating Lever Shaft Disassembly Note
- Item 88: Reverse Brake Drum and Clutch Assembly Disassembly Note
- Item 88: Reverse Brake Drum and Clutch Assembly Inspection Note
- Item 91: Output Shaft Thrust Washer Disassembly Note
- Item 92: Manual Control Lever Inner Nut Disassembly Note
- Transmission
- Disassembly And Assembly Of Subassemblies
- Main Control Valve Body
- Fluid Pump
- Special Tool(s)
- Material
- Disassembly
- Assembly
- Notes
- Item 1: Seal Ring Assembly Note
- Items 2 and 3: Front Pump Drive Gear and Driven Gear Assembly Note
- Item 5: Fluid Pump Control Valve Assembly Note
- Items 6 and 7: Fluid Pump Cover Assembly and Fluid Pump Adapter Plate Assembly Note
- Item 8: Front Pump Support Assembly Note
- Item 9: Fluid Pump Screws Assembly Note
- Item 11: Stator Support Seal Assembly Note
- Overdrive Brake And Coast Clutch Drum Assembly
- Special Tool(s)
- Material
- Disassembly
- Notes
- Item 5: Retaining Ring Disassembly Note
- Item 8: Direct and Overdrive Clutch Piston Disassembly Note
- Item 11: Overdrive Brake and Coast Clutch Drum Assembly Note
- Items 9 and 10: Direct and Overdrive Piston Inner and Outer Seal Ring Assembly Note
- Item 8: Direct and Overdrive Clutch Piston Assembly Note
- Item 5: Retaining Ring Assembly Note
- Items 3 and 4: Coast Clutch External Steel and Internal Friction Plates Assembly Note
- Item 1: Retaining Ring Assembly Note
- Direct Clutch Drum Assembly
- Special Tool(s)
- Material
- Disassembly & Assembly
- Notes
- Item 5: Retaining Ring Disassembly Note
- Item 8: Direct and Overdrive Clutch Piston Disassembly Note
- Item 11: Intermediate Brake Drum Assembly Note
- Items 9 and 10: Direct and Overdrive Piston Outer and Inner Seal Ring Inspection Note
- Items 9 and 10: Direct and Overdrive Piston Outer and Inner Seal Ring Assembly Note
- Item 5: Retaining Ring Assembly Note
- Items 4 and 3: Direct Clutch External Spline Steel and Internal Spline Friction Plates Assembly Note
- Item 1: Retaining Ring Assembly Note
- Forward Clutch
- Special Tool(s)
- Material
- Disassembly & Assembly
- Notes
- Item 5: Retaining Ring Disassembly Note
- Item 7: Forward Clutch Piston Disassembly Note
- Item 8: Forward Clutch Cylinder Assembly Note
- Item 7: Forward Clutch Piston Inspection Note
- Item 7: Forward Clutch Piston Assembly Note
- Item 5: Retaining Ring Assembly Note
- Items 4 and 3: Forward Clutch Internal Splined Steel and External Splined Friction Plates Assembly Note
- Item 1: Retaining Ring Assembly Note
- Overdrive Planetary And One-Way Clutch Assembly
- Disassembly & Assembly
- Notes
- Item 1: Retaining Ring Disassembly Note
- Items 2, 4, 5, 6 and 7 Overdrive Planetary and One-Way Clutch Assembly Inspection Note
- Item 7: Overdrive Sun Gear Assembly Note
- Item 6: Coast Clutch Adapter Assembly Note
- Item 4: No. 2 Overdrive Planetary Thrust Bearing Assembly Note
- Item 1: Retaining Ring Assembly Note
- Disassembly & Assembly
- Output Shaft Ring Gear And Hub Shaft Assembly
- Reverse Servo Assembly
- Torque Converter
- Torque Converter Cleaning And Inspection
- Torque Converter Flushing
- Torque Converter Leak Check
- Torque Converter Impeller To Pump Stator Interference Check
- Torque Converter End Play Check
- Torque Converter One-Way Clutch Check
- Torque Converter Turbine To Pump Stator Interference Check
- Assembly
- Transmission
- Special Tool(s)
- Material
- Assembly
- Notes
- Item 1: Transmission Case Assembly Note
- Item 2: Case Bearing Disassembly Note
- Item 2: Case Bearing Assembly Note
- Item 3: Manual Control Lever Seal Assembly Note
- Item 4: Park Pawl Actuating Rod Assembly Note
- Item 5: Manual Control Valve Inner Lever Assembly Note
- Item 6: Manual Control Lever Shaft Assembly Note
- Item 7: Manual Control Lever Inner Nut Assembly Note
- Item 8: Manual Control Lever Shaft Retaining Pin Assembly Note
- Item 9: Manual Control Lever Inner Nut Assembly Note
- Item 10: Output Shaft Thrust Washer No. 11 Assembly Note
- Item 13: Reverse Band Assembly Note
- Item 14: Reverse Brake Drum and Clutch Assembly Note
- Item 15: Reverse Brake Drum Lever Assembly Note
- Item 18: Output Shaft Ring Gear Assembly Note
- Item 19: Output Shaft Retaining Ring Assembly Note
- Item 20: Output Shaft Sleeve Assembly Note
- Item 23: Reverse Brake Drum Retaining Ring Assembly Note
- Item 27: Forward Planet Assembly Note
- Item 35: Intermediate Servo Retaining Ring Assembly Note
- Item 37: Intermediate Clutch Drum Bearing No. 4 Assembly Note
- Item 38: Intermediate Brake Band Assembly Note
- Item 39: Intermediate Brake Band Anchor Strut Assembly Note
- Item 40: Intermediate Brake Band Adjusting Screw Assembly Note
- Item 41: Intermediate Brake Band Apply Strut Assembly Note
- Item 42: Center Support Assembly Note
- Item 43: Nut and Cage Assembly Note
- Item 44: Center Support Screw Assembly Note
- Item 45: Retaining Ring Assembly Note
- Item 48: Overdrive Servo Retaining Ring Assembly Note
- Item 50: Overdrive Planetary Gear Carrier Assembly Note
- Item 52: Overdrive Brake Band Assembly Note
- Item 53: Overdrive Brake Band Anchor Strut Assembly Note
- Item 54: Overdrive Brake Band Adjusting Screw Assembly Note
- Item 55: Overdrive Brake Band Apply Strut Assembly Note
- Item 56: Fluid Pump Support Thrust Washer No. 1 Assembly Note
- Item 57: Fluid Pump Gasket Assembly Note
- Item 58: Fluid Pump Assembly Note
- Item 59: Fluid Pump Screw Assembly Note
- Item 60: Band Adjusting Locknut Assembly Note
- Item 61: Band Adjusting Locknut Assembly Note
- Item 62: Center Support Bolt Assembly Note
- Items 63, 64, 65 and 66: Main Control and Screws Assembly Note
- Items 67 and 68: Manual Valve Detent Spring and Screw Assembly Note
- Item 69: Solenoid Body O-Ring Seals Assembly Note
- Items 70, 71 and 72: Solenoid Body and Solenoid Body Screws Assembly Note
- Item 74: Reverse Servo Screws Assembly Note
- Items 75 and 76: Transmission Fluid Filter and Screws Assembly Note
- Item 77: Transmission Fluid Pan Gasket Assembly Note
- Item 78: Transmission Fluid Pan Assembly Note
- Item 79: Transmission Fluid Pan Screws Assembly Note
- Items 80, 81, 82, and 83: Park Pawl Assembly Note
- Item 86: Extension Housing Seal Assembly Note
- Items 87 and 88: Transmission Range (TR) Sensor and Screws Assembly Note
- Item 91: Fluid Pump Assembly Note
- Item 92: Front Fluid Pump Seal Assembly Note
- Item 93: Input Shaft Assembly Note
- Item 94: Torque Converter Assembly Note
- Items 95 and 96: Flexplate Adapter Plate and Nuts Assembly Note
- Items 97 and 98: Speed Sensor and Screws Assembly Note
- Transmission
- Installation
- Transmission - 4X2
- Special Tool(s)
- Assembly
- Notes
- Item 1: Transmission Assembly Installation Note
- Item 3: Fuel Line Bracket Installation Note
- Item 9: Fluid Cooler Nuts Installation Note
- Item 12: Solenoid Body Harness Connector Installation Note
- Item 31: Rear Transmission Support Nuts Installation Note
- Item 35: Transmission Assembly Installation Note
- Transmission - 4X4
- Special Tool(s)
- Assembly
- Notes
- Item 1: Transmission Assembly Installation Note
- Item 3: Fuel Line Bracket Installation Note
- Item 9: Fluid Cooler Nuts Installation Note
- Item 12: Solenoid Body Harness Connector Installation Note
- Item 32: Rear Transmission Support Nuts Installation Note
- Item 36: Transmission Assembly Installation Note
- Transmission - 4X2