Technical Service Bulletins

Accessories Control Systems
- Various Vehicles - Module Reprogramming (G0000150)
- 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
- Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
- Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
- Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
- Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
- Speedometer Indicator Needle Sticking Or Inaccurate - Built On Or Before 3/25/2010 (10-18-7)
- Adaptive Cruise Control (Acc) - Turns Off (10-8-1)
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
Air Bag, SRS
- Intermittent Air Bag Warning Indicator - DTCS B0028, B1213 When Passenger Climate Control Seat Commanded On (11-10-7)
Anti-Theft Systems
- Passive Anti Theft System(Pats) Key Programming (G0000156)
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
Automatic Trans
- 6F50/6F55 Transmission - Slip/Neutral Out - 5TH Gear Start From Stop - Backup Camera On In Drive - Built 3/13/2009-6/30/2010 (13-5-27)
- 6F50/6F55 Transmission - Sluggish Acceleration From 0-8 Km\H (0-5 Mph) Followed By A Harsh Bump Or A Slip On Take-Off Followed By A Bump - Built On Or Before 4/15/2011 (11-9-11)
- Tip-In Delayed Shift At Speeds Between 15-20 Mph (24-32 Km/H) (10-20-8)
- 6F50/6F55 Transmission - DTC P0751 - Harsh Or No Forward Engagements - Perceived Slip On Acceleration - Slip/Delayed And/Or Harsh Downshifts (10-9-9)
- 6F55 Transmission With ECO Boost (GTDI)- Bump 3-1 Coasting Downshift Below 10 Mph (16 Km/H) Built On Or Before 3/1/2010 (10-6-4)
- 6F50/6F55 Transmission - Shift Flare Initial 2-3 Shift / Slight Delay/Bump 3-1 Coasting Downshift Below 10 Mph (16 Km/H) Built On Or Before 11/17/2009 (10-4-3)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
Auxiliary Emission Control Systems
- 3.5L GTDI - Excessive Oil Consumption And/Or Smoke From The Exhaust At Idle During Normal Engine Operating Temperature - Aluminum Valve Cover (15-0086)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
- DTC P0096-Intake Air Temperature: IAT Sensor 2 Circuit/Range Performance - Bank 1 - Built On Or Before 10/14/2009 (09-23-8)
Blowers, Superchargers & Turbochargers
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
Body Interior
- Various Vehicles - Module Reprogramming (G0000150)
- 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
- Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
- Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
- Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
- Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
- Speedometer Indicator Needle Sticking Or Inaccurate - Built On Or Before 3/25/2010 (10-18-7)
- Adaptive Cruise Control (Acc) - Turns Off (10-8-1)
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Collision/Avoidance
- Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
- 6F50/6F55 Transmission - Slip/Neutral Out - 5TH Gear Start From Stop - Backup Camera On In Drive - Built 3/13/2009-6/30/2010 (13-5-27)
- Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False Blockage And/Or Diagnostic Trouble Code (DTC) - U3000 - Built On Or Before 3/29/2011 (11-8-3)
- Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
- Adaptive Cruise Control (Acc) - Turns Off (10-8-1)
Communication Devices
- Sync Programming Gen 1, Gen 2, Sync 3 (24-7088)
- Sync - Phone/USB Connectivity - Voice Recognition And Traffic - Directions And Information Messaging (12-9-6)
- SIRIUS Radio With Navigation - Various Functionality Concerns - Built On Or Before 3/8/2010 (11-11-16)
- Sync - Call Sound Quality/Background Noise Issues And/Or Voice Recognition Difficulties While Driving (10-8-3)
- Sync System Defaults To Or Stays In Privacy Mode, Multiple Vehicle Lines (10-2-8)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
Cruise Control Systems
- Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
- 6F50/6F55 Transmission - Slip/Neutral Out - 5TH Gear Start From Stop - Backup Camera On In Drive - Built 3/13/2009-6/30/2010 (13-5-27)
- Adaptive Cruise Control (Acc) - Turns Off (10-8-1)
Engine Control Systems
- Sync Programming Gen 1, Gen 2, Sync 3 (24-7088)
- Various Vehicles - Module Reprogramming (G0000150)
- 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
- Diagnostic Trouble Code (DTC) P1635 (19-7008)
- Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
- 3.5L GTDI Engine Runs Rough, Hesitates, Shuddering With Misfire DTCS P0300, P0301, P0302, P0303, P0304, P0305, P0306 Or P0316 (11-8-19)
- DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
- DTC P0096-Intake Air Temperature: IAT Sensor 2 Circuit/Range Performance - Bank 1 - Built On Or Before 10/14/2009 (09-23-8)
- Radio - High Pitch Whistle Or Whine Noise Built On Or Before 9/24/2009 (09-23-2)
Entertainment Systems
- Fm Radio Reception/Sound Quality Changes While Driving Or Satellite Radio Signal Bleed Through When Using Audio System In Aux Mode (10-13-3)
- Rear Package Tray/Speaker Rattle/Buzz With The Radio On - Built On Or Before 12/9/2009 (10-6-2)
- Radio - High Pitch Whistle Or Whine Noise Built On Or Before 9/24/2009 (09-23-2)
- Poor Am / Fm Radio Reception With Rear Defrost On (09-19-2)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
- Dirt Accumulation On Rear Door Scuff Plates (13-12-2)
- Luggage Compartment Lid Solenoid Stuck Open (10-5-9)
Exterior Lights
- Regional Program 14R01 - License Plate Lamp Assembly Replacement (14R01)
- Center High Mount STOPLAMP Repair/Replacement Procedure (10-15-2)
Front Suspension
- Intermittent Steering Drift/Pull - Built On Or Before 6/11/2010 (12-2-8)
Fuel System
- Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
- DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
- Radio - High Pitch Whistle Or Whine Noise Built On Or Before 9/24/2009 (09-23-2)
Gauges & Instrument Panels
- Speedometer Indicator Needle Sticking Or Inaccurate - Built On Or Before 3/25/2010 (10-18-7)
HVAC Control Systems
- 2008-2019 Various Ford/LINCOLN/Mercury Vehicles - Inoperative Heating, Ventilation, And Air Conditioning (HVAC) Blower Motor (SSM 47797)
Ignition Switch/Steering Lock
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
Ignition System
- 3.5L GTDI Engine Runs Rough, Hesitates, Shuddering With Misfire DTCS P0300, P0301, P0302, P0303, P0304, P0305, P0306 Or P0316 (11-8-19)
Infotainment
- Global Position Satellite Module - Traffic Directions And Information/Navigation - Unable To Locate Vehicle - Built On Or Before 5/14/2012 (12-11-2)
- SIRIUS Radio With Navigation - Various Functionality Concerns - Built On Or Before 3/8/2010 (11-11-16)
- Poor Am / Fm Radio Reception With Rear Defrost On (09-19-2)
Interior/Exterior Trim
- Various Vehicles - Running Board Concern Analysis (G0000073)
- Dirt Accumulation On Rear Door Scuff Plates (13-12-2)
- Rear Package Tray/Speaker Rattle/Buzz With The Radio On - Built On Or Before 12/9/2009 (10-6-2)
Lubrication System
- 3.5L GTDI - Excessive Oil Consumption And/Or Smoke From The Exhaust At Idle During Normal Engine Operating Temperature - Aluminum Valve Cover (15-0086)
Manual Steering
- Intermittent Steering Drift/Pull - Built On Or Before 6/11/2010 (12-2-8)
- Power Steering Fluid Leak At The Reservoir Fill Cap (10-6-1)
Mechanical
- 3.5L GTDI - Excessive Oil Consumption And/Or Smoke From The Exhaust At Idle During Normal Engine Operating Temperature - Aluminum Valve Cover (15-0086)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
Mechanical - Hydraulic
- Front Brakes - Intermittent Grunt Or Grinding Noise (11-5-15)
- Rear Brake Drag Or Rear Brake Noise - Built On Or Before 12/14/2009 (10-7-2)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
- Blind Spot Information System (BLIS) And Cross Traffic Alert (CTA) - False DTC B11D6:15 With Intermittent Faults - Built On Or Before 5/21/2010 (10-20-6)
Restraints Control Systems
- Intermittent Air Bag Warning Indicator - DTCS B0028, B1213 When Passenger Climate Control Seat Commanded On (11-10-7)
Starter
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
Steering Control Systems
- Adaptive Cruise Control & Collision Warning Radar Alignment Process (G0000136)
- Intermittent Steering Drift/Pull - Built On Or Before 6/11/2010 (12-2-8)
- Power Steering Fluid Leak At The Reservoir Fill Cap (10-6-1)
Steering Gear
- Power Steering Fluid Leak At The Reservoir Fill Cap (10-6-1)
Steering Linkage
- Intermittent Steering Drift/Pull - Built On Or Before 6/11/2010 (12-2-8)
System
- 3.5L GTDI - Excessive Oil Consumption And/Or Smoke From The Exhaust At Idle During Normal Engine Operating Temperature - Aluminum Valve Cover (15-0086)
- Easy Fuel CAPLESS - Concerns With Fuel Nozzle Insertion Or Removal (14-0132)
- 3.5L GTDI Engine Runs Rough, Hesitates, Shuddering With Misfire DTCS P0300, P0301, P0302, P0303, P0304, P0305, P0306 Or P0316 (11-8-19)
- DTC P2111 Or P2112, Or Lower Than Desired Engine Idle Speed, Engine Idle Speed Fluctuates With Or Without DTCS (10-21-6)
- Intelligent Access Key With No Key Detected Or No Fob Detected - Built On Or Before 3/11/2010 (10-5-12)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
- DTC P0096-Intake Air Temperature: IAT Sensor 2 Circuit/Range Performance - Bank 1 - Built On Or Before 10/14/2009 (09-23-8)
- Radio - High Pitch Whistle Or Whine Noise Built On Or Before 9/24/2009 (09-23-2)
Transfer Case
- 6F50/6F55 Transmission AWD - Fluid Leak - Between PTU Assembly And Transmission Case (11-4-20)
- AWD Vehicles Shudder/Chatter/Vibration On Turns Or Thump/Clunk Noise On Light Acceleration - Built 10/1/2009 To 12/31/2009 (10-22-4)
- PTU Fluid Leak - Vent Area (10-14-2)
- Service Tip - Power Transfer Unit (PTU) - Right Hand Intermediate Shaft Seal Leaks (09-8-10)
Transmission Control Systems
- 2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCS) U2100 And/Or U2101- Programmable Module Installation (PMI) Procedure (SSM 47843)
- 6F50/6F55 Transmission - Slip/Neutral Out - 5TH Gear Start From Stop - Backup Camera On In Drive - Built 3/13/2009-6/30/2010 (13-5-27)
- 6F50/6F55 Transmission - Sluggish Acceleration From 0-8 Km\H (0-5 Mph) Followed By A Harsh Bump Or A Slip On Take-Off Followed By A Bump - Built On Or Before 4/15/2011 (11-9-11)
- Tip-In Delayed Shift At Speeds Between 15-20 Mph (24-32 Km/H) (10-20-8)
- 6F50/6F55 Transmission - DTC P0751 - Harsh Or No Forward Engagements - Perceived Slip On Acceleration - Slip/Delayed And/Or Harsh Downshifts (10-9-9)
- 6F55 Transmission With ECO Boost (GTDI)- Bump 3-1 Coasting Downshift Below 10 Mph (16 Km/H) Built On Or Before 3/1/2010 (10-6-4)
- 6F50/6F55 Transmission - Shift Flare Initial 2-3 Shift / Slight Delay/Bump 3-1 Coasting Downshift Below 10 Mph (16 Km/H) Built On Or Before 11/17/2009 (10-4-3)
- Aftermarket Powertrain Control Module Calibration, Non-Factory Modification Or Aftermarket Components (10-2-6)
Wheel Alignment
- Intermittent Steering Drift/Pull - Built On Or Before 6/11/2010 (12-2-8)
Window Motors & Regulators
- Various Vehicles - Glass Concern Analysis (G0000179)
Wiper/Washer Systems
- Rain Sensor Mounting Ring Detached From Windshield (09-24-13)