Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cruise Control
- Defoggers
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Immobilizer System
- Service Precaution
- General Description
- Circuit Diagram
- Parts Location
- Immobilizer Control Unit (ICU)
- Immobilizer Coil (Antenna)
- Transponder (Key)
- Immobilizer Warning Lamp
- Engine Control Module (ECM)
- Car Pass Card
- Important information on Programming
- Tech 2 Scan Tool
- Notes
- Tech-2 Features
- Getting Started
- Operating Procedure
- Menu
- DTC
- Clear DTC Information
- Tech-2 Data Display
- Check Vehicle Identification Number (VIN)
- Reset Immobilizer (Reset Immobilizer Control Unit)
- Reset Engine Control Module (Reset ECM)
- Erase Transponder Key
- Transponder Program
- Programming ICU and ECM
- Programming ICU
- Programming ECM
- Data List
- Diagnostic Procedure
- Clearing Diagnostic Trouble Codes
- Verifying Vehicle Repair
- Diagnostic Aids
- Immobilizer System Check
- NO Immobilizer Warning Lamp
- Immobilizer Warning Lamp ON Steady
- B8001: Replace Electronic Control Unit (ECU) (Immobilizer Fault)
- B8002: Immobilizer Not Programmed
- B8003: Transponder Key Problem
- B8004: Immobilizer Coil Circuit (Antenna Coil Fault)
- B8005: Communication Line W Voltage Low
- B8006: Communication Line W Voltage High
- B8007: NO Engine Request Received
- B8008: Wrong Transponder Key
- B8009: NO Transponder Key Programmed
- B8010: Unknown Transponder Key
- Security & Locks
- Service Precaution
- Front Door Lock Assembly
- Front Outside Handle
- Rear Door Lock Assembly
- Rear Outside Handle
- Tailgate Lock and Hatchgate Lock (LWB)
- Tailgate Lock (SWB)
- Key
- Power Door Lock System
- Anti-Theft System
- Keyless Entry System
- Main Data and Specifications
- Immobilizer System
- Cruise Control Systems
- Entertainment Systems
- Gauges & Instrument Panels
- Infotainment
- Interior/Exterior Trim
- Body Structure
- Service Precaution
- Frame
- General Description (Bumper)
- Front Bumper
- Front Bumper Slider Bracket
- Rear Bumper
- Rear Bumper Slider
- General Description (Sheet Metal)
- Engine Hood
- Engine Hood Lock
- Radiator Grille
- Front Fender Panel
- Body Mounting
- Body Dimension
- General Description (Body)
- Instrument Panel Assembly
- Front Door Assembly
- Rear Door Assembly
- Front Window Regulator, Glass and Glass Run
- Rear Window Regulator, Glass and Glass Run
- Tailgate (LWB)
- Tailgate (SWB)
- Rear Hatchgate (LWB)
- Tailgate Glass (Resin Top)
- Spare Tire Carrier
- Spare Tire Hanger
- Windshield
- Rear Quarter Glass (LWB)
- Rear Quarter Glass (Resin Top)
- Side Window Glass (SWB)
- Main Data and Specifications
- Special Tools
- Exterior/Interior Trim
- Service Precaution
- Consoles
- Front Door Trim Panel
- Rear Door Trim Panel
- Door Mirror Assembly
- Interior Trim Panels (LWB)
- Interior Trim Panels (SWB)
- Headlining (LWB)
- Headlining (SWB)
- Canopy Trim (Resin Top Model)
- Wheel Arch Protector (LWB)
- Wheel Arch Protector (SWB)
- Wheel Arch Molding (SWB)
- Wheel Arch Molding (LWB)
- Fuel Filler Door
- Roof Rail
- License Plate Garnish
- Power Door Mirror System
- Power Window System
- Body Structure
- Interior/Illumination Lights
- Lighting System
- Service Precaution
- Headlight Bulb
- Headlight Assembly
- Fog Light Bulb
- Fog Light Assembly
- Side Marker Light Bulb
- Taillight Bulb
- License Plate Light Bulb (Bumper Type)
- License Plate Light Bulb (Tailgate Type)
- Stoplight Bulb
- High Mounted Stoplight Assembly
- High Mounted Stoplight Bulb
- High Mounted Stoplight Assembly (Soft Top Model)
- High Mounted Stoplight Bulb (Soft Top Model)
- High Mounted Stoplight Assembly (Resin Top Model)
- High Mounted Stoplight Bulb (Resin Top Model)
- Backup Light Bulb
- Front Turn Signal Light Bulb
- Rear Turn Signal Light Bulb
- Dome Light Bulb (LWB)
- Dome Light Bulb (SWB)
- Glove Box Light Bulb
- Spotlight Bulb
- Luggage Room Light Bulb (LWB)
- Luggage Room Light Bulb (Resin Top Model)
- HVAC Bezel Illumination Light Bulb
- Shift Lever Illumination Light Bulb (A/T)
- Vanity Mirror Illumination Light Bulb
- Starter Switch
- Lighting Switch (Combination Switch)
- Dimmer-Passing Switch (Combination Switch)
- Door Switch
- Rear Defogger Switch
- Key Remind Switch (Starter Switch)
- Hazard Warning Light Switch
- Foglight Switch
- Stoplight Switch
- Backup Light Switch (M/T)
- Turn Signal Light Switch (Combination Switch)
- Illumination Controller
- Light and Bulb Specifications (LWB)
- Light and Bulb Specifications (SWB)
- Lighting System
- Wiper/Washer Systems
- Service Precaution
- Windshield Wiper/Washer System
- Windshield Wiper and Washer Switch
- Windshield Wiper Motor
- Windshield Washer Motor
- Windshield Washer Spray Pattern
- Windshield Wiper Linkage
- Windshield Wiper Arm/Blade
- Windshield Wiper Blade Rubber
- Rear Wiper/Washer System
- Rear Wiper and Washer Switch
- Rear Wiper Motor (LWB)
- Rear Wiper Motor (Resin Top Model)
- Rear Washer Motor
- Alarm and Relay Control Unit
- Rear Wiper Arm/Blade (LWB)
- Rear Wiper Arm/Blade (Resin Top Model)
- Rear Washer Nozzle
- Rear Washer Nozzle (Resin Top Model)
- Rear Wiper Blade Rubber (LWB Spare Tire Storage - Tailgate Mounted)
- Rear Wiper Blade Rubber (Spare Tire Storage - LWB Under Floor and SWB Tailgate Mounted)
- Main Data and Specifications
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Immobilizer System
- Service Precaution
- General Description
- Circuit Diagram
- Parts Location
- Immobilizer Control Unit (ICU)
- Immobilizer Coil (Antenna)
- Transponder (Key)
- Immobilizer Warning Lamp
- Engine Control Module (ECM)
- Car Pass Card
- Important information on Programming
- Tech 2 Scan Tool
- Notes
- Tech-2 Features
- Getting Started
- Operating Procedure
- Menu
- DTC
- Clear DTC Information
- Tech-2 Data Display
- Check Vehicle Identification Number (VIN)
- Reset Immobilizer (Reset Immobilizer Control Unit)
- Reset Engine Control Module (Reset ECM)
- Erase Transponder Key
- Transponder Program
- Programming ICU and ECM
- Programming ICU
- Programming ECM
- Data List
- Diagnostic Procedure
- Clearing Diagnostic Trouble Codes
- Verifying Vehicle Repair
- Diagnostic Aids
- Immobilizer System Check
- NO Immobilizer Warning Lamp
- Immobilizer Warning Lamp ON Steady
- B8001: Replace Electronic Control Unit (ECU) (Immobilizer Fault)
- B8002: Immobilizer Not Programmed
- B8003: Transponder Key Problem
- B8004: Immobilizer Coil Circuit (Antenna Coil Fault)
- B8005: Communication Line W Voltage Low
- B8006: Communication Line W Voltage High
- B8007: NO Engine Request Received
- B8008: Wrong Transponder Key
- B8009: NO Transponder Key Programmed
- B8010: Unknown Transponder Key
- Security & Locks
- Service Precaution
- Front Door Lock Assembly
- Front Outside Handle
- Rear Door Lock Assembly
- Rear Outside Handle
- Tailgate Lock and Hatchgate Lock (LWB)
- Tailgate Lock (SWB)
- Key
- Power Door Lock System
- Anti-Theft System
- Keyless Entry System
- Main Data and Specifications
- Immobilizer System
- Exterior/Interior Trim
- Body Structure
- Service Precaution
- Frame
- General Description (Bumper)
- Front Bumper
- Front Bumper Slider Bracket
- Rear Bumper
- Rear Bumper Slider
- General Description (Sheet Metal)
- Engine Hood
- Engine Hood Lock
- Radiator Grille
- Front Fender Panel
- Body Mounting
- Body Dimension
- General Description (Body)
- Instrument Panel Assembly
- Front Door Assembly
- Rear Door Assembly
- Front Window Regulator, Glass and Glass Run
- Rear Window Regulator, Glass and Glass Run
- Tailgate (LWB)
- Tailgate (SWB)
- Rear Hatchgate (LWB)
- Tailgate Glass (Resin Top)
- Spare Tire Carrier
- Spare Tire Hanger
- Windshield
- Rear Quarter Glass (LWB)
- Rear Quarter Glass (Resin Top)
- Side Window Glass (SWB)
- Main Data and Specifications
- Special Tools
- Exterior/Interior Trim
- Service Precaution
- Consoles
- Front Door Trim Panel
- Rear Door Trim Panel
- Door Mirror Assembly
- Interior Trim Panels (LWB)
- Interior Trim Panels (SWB)
- Headlining (LWB)
- Headlining (SWB)
- Canopy Trim (Resin Top Model)
- Wheel Arch Protector (LWB)
- Wheel Arch Protector (SWB)
- Wheel Arch Molding (SWB)
- Wheel Arch Molding (LWB)
- Fuel Filler Door
- Roof Rail
- License Plate Garnish
- Power Door Mirror System
- Power Window System
- Body Structure
- Sun Roof/T-Top/Convertible Top
- Sunroof/Convertible Top
- Door Locks
- Brakes
- Anti-Lock Brakes
- Brakes Control Systems
- Brake Control System
- Service Precaution
- General Description
- General Diagnosis
- General Information
- ABS Service Precautions
- Computer System Service Precautions
- General Service Precautions
- Note on Intermittents
- Test Driving ABS Complaint Vehicles
- "ABS" Warning Light
- Normal Operation
- Tech 2 Scan Tool
- Data List
- Actuator Test
- Tech 2 Service Bleed
- Basic Diagnostic Flow Chart
- Basic Inspection Procedure
- EHCU Connector Pin-out Checks
- Symptom Diagnosis
- Notes
- Chart A-1 ABS Works Frequently But Vehicle Does Not Decelerate
- Chart TA-1 ABS Works Frequently But Vehicle Does Not Decelerate (Use TECH 2)
- Chart A-2 Uneven Braking Occurs While ABS Works
- Chart TA-2 Uneven Braking Occurs While ABS Works (Use TECH 2)
- Chart A-3, TA-3 The Wheels Are Locked
- Chart A-4 Brake Pedal Feed Is Abnormal
- Chart A-5, TA-5 Braking Sound (From EHCU) Is Heard While Not Braking
- Diagnostic Trouble Codes
- Diagnosis By "ABS" Warning Light Illumination Pattern
- Notes
- Diagnostic Trouble Codes (DTCs)
- Diagnostic Trouble Codes (DTC) List
- Notes
- Chart B-1 With Key In On Position (Before Starting Engine). Warning Light (W/L) Is Not Activated.
- Chart B-2 CPU Error (DTC 14 (Flash Out) / C0271, C0272, C0273, C0284 (Serial Communications))
- Chart B-3 Low Or High Ignition Voltage (DTC 15 (Flash Out) / C0277, 0278 (Serial Communications))
- Chart B-4 Excessive Dump Time (DTC 17 (Flash Out) / C0269 (Serial Communications))
- Chart B-5 Excessive Isolation Time (DTC 18 (Flash Out) / C0274 (Serial Communications))
- Chart B-6 G-Sensor Output Failure (DTC 21 (Flash Out) / C0276 (Serial Communications))
- Chart B-7 Brake Switch Failure (DTC 22 (Flash Out) / C0281 (Serial Communications))
- Chart B-8 2WD Controller In 4WD Vehicle Controller (DTC 13 (Flash Out) / C0285 (Serial Communications)), 4Wd State Input Signal Failure (DTC 24 (Flash Out) / C0282 (Serial Communications))
- Chart B-9 Pump Motor Failure (DTC 32 (Flash Out) / C0267, C0268 (Serial Communications))
- Chart B-10 EHCU Valve Relay Failure (DTC 35 (Flash Out) / C0265, C0266 (Serial Communications))
- Chart B-11 FL Isolation Solenoid Coil Failure (DTC 41 (Flash Out) / C0245, C0247 (Serial Communications))
- Chart B-12 FL Dump Solenoid Coil Failure (DTC 42 (Flash Out) / C0246, C0248 (Serial Communications))
- Chart B-13 FR Isolation Solenoid Coil Failure (DTC 43 (Flash Out) / C0241, C0243 (Serial Communications))
- Chart B-14 FR Dump Solenoid Coil Failure (DTC 44 (Flash Out) / C0242, C0244 (Serial Communications))
- Chart B-15 Rear Isolation Solenoid Coil Failure (DTC 45 (Flash Out) / C0251, C0253 (Serial Communications))
- Chart B-16 Rear Dump Solenoid Coil Failure (DTC 46 (Flash Out) / C0252, C0254 (Serial Communications))
- Chart B-17 FL Speed Sensor Open Or Shorted (DTC 51 (Flash Out) / C0225 (Serial Communications))
- Chart B-18 FR Speed Sensor Open Or Shorted (DTC 52 (Flash Out) / C0221 (Serial Communications))
- Chart B-19 Rear Speed Sensor Open Or Shorted (DTC 53 (Flash Out) / C0235 (Serial Communications))
- Chart B-20 FL Speed Sensor Missing Signal (DTC 61 (Flash Out) / C0226, C0227 (Serial Communications))
- Chart B-21 FR Speed Sensor Missing (DTC 62 (Flash Out) / C0222, C0223 (Serial Communications))
- Chart B-22 Rear Speed Sensor Missing (DTC 63 (Flash Out) / C0236, C0237 (Serial Communications))
- Chart B-23 Simultaneous Drop-Out Of Front Speed Sensor Signal (DTC 64 (Flash Out) / C0229 (Serial Communications))
- Chart B-24 Wheel Speed Input Abnormality (DTC 65 (Flash Out) / C0238 (Serial Communications))
- Chart B-25 Abnormal TOD Signal Input (DTC 71 (Flash Out)/C0287 (Serial Communications))
- Sensor Signal Abnormality Criteria using TECH 2
- Unit Inspection Procedure
- Special Tools
- Brake Control System
- Mechanical - Hydraulic
- Disc & Drum
- Description & Operation
- Bleeding Brake System
- Adjustments
- Trouble Shooting
- Component Testing
- Removal & Installation
- Notes
- Brake Pedal & Associated Parts
- Brake Pipe
- Center Console
- Front Brake Hose
- Front Disc Brake Caliper
- Front Disc Brake Pads
- Front Disc Brake Rotor (RWD)
- Front Hub Assembly (4WD)
- Master Cylinder
- Parking Brake Drum Shoes (4WD)
- Parking Brake Lever
- Parking Brake Rear Cable (4WD)
- Parking Brake Rear Cable (RWD)
- Power Brake Booster Unit
- Proportioning & Bypass (P & B) Valve
- Rear Brake Hose
- Rear Disc Brake Caliper (4WD)
- Rear Disc Brake Pads (4WD)
- Rear Disc Brake Rotor (4WD)
- Rear Drum Brake Shoes (RWD)
- Stoplight Switch
- Wheel Cylinder Assembly (RWD)
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Drum Brake Specifications
- Disc & Drum
- Traction Control
- Drivelines & Axles
- Driveshaft & Universal Joints
- Drive Shaft System
- Service Precaution
- General Description
- Diagnosis
- Front Hub and Disc (2WD Model)
- Front Hub and Disc (4WD Model)
- Front Drive Shaft Joint
- Front Axle Drive Shaft
- Shift On The Fly System
- Propeller Shaft
- Front Propeller Shaft
- Rear Propeller Shaft
- Drive Shaft System
- Driveshaft & Universal Joints
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Starters
- Wiring Diagrams
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cruise Control
- Defoggers
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Engine Mechanical
- Accessory Drive Belts
- Cooling System (Mechanical)
- Engine Exhaust (Y22SE 2.2L)
- Fuel System
- Lubrication System
- Mechanical
- Engine Mechanical (Y22SE 2.2L)
- Service Precaution
- General Description
- Engine Diagnosis
- Cylinder Head Cover
- Exhaust Manifold
- Crankshaft Pulley
- Intake Manifold
- Cylinder Head Assembly
- Timing Belt
- Camshaft
- Engine Assembly
- Cylinder Head
- Valve Spring, Valve, Valve Guide
- Crankshaft
- Piston and Connecting Rod
- Cylinder Block
- Balance Unit Assembly
- Main Data and Specifications
- Special Tools
- Induction (Y22SE 2.2L)
- Engine Mechanical (Y22SE 2.2L)
- Starters
- Timing Belt Replacement - 2.2L - DOHC
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- EGR Function Testing - ISUZU
- Emission Applications - Gas
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Fuel Delivery
- Mode 6 - 1996-2007 ISUZU
- Engine Controls - Pin Voltage Charts
- Remove, Overhaul & Install
- Engine Controls - Component Removal & Installation
- Introduction
- Computerized Engine Control
- Programming
- Air Induction Systems
- Sensors & Switches
- Accelerator Position Sensor
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Level Sensor
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Ion Sensing Module (Axiom, Rodeo & Rodeo Sport 3.2L)
- Knock Sensor
- Manifold Absolute Pressure Sensor
- Mass Air Flow Sensor/Intake Air Temperature Sensor (Ascender 5.3L)
- Throttle Position Sensor
- Vehicle Speed Sensor
- Motors, Relays & Solenoids
- Emissions Systems
- Fuel System
- Torque Specifications
- Engine Controls - Component Removal & Installation
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- No Start Diagnosis
- Fuel System
- Notes
- Fuel System Pressure Release (Axiom, Rodeo & Rodeo Sport)
- Fuel System Pressure Release (Ascender 4.2L)
- Fuel System Pressure Release (Ascender 5.3L)
- Fuel System Diagnosis (Axiom, Rodeo & Rodeo Sport)
- Fuel System Diagnosis (Ascender 4.2L)
- Fuel System Diagnosis (Ascender 5.3L)
- Fuel Pressure Gauge Installation & Removal (Ascender)
- Fuel System Electrical Test
- Fuel Pump Electrical Circuit Diagnosis (Ascender 4.2L)
- Fuel Pump Pressure Test
- Fuel Pump Flow Test
- Fuel Injector Resistance
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 2.2L
- Introduction
- Self-Diagnostic System
- Notes
- On-Board Diagnostics
- On-Board Diagnostic II System Check
- Retrieving Diagnostic Trouble Codes
- Clearing Diagnostic Trouble Codes
- Comprehensive Component Monitor Diagnostic Operation
- System Status And Drive Cycle For Satisfying Federal Inspection/Maintenance (I/M 240) Regulations
- Common OBD-II Terms
- Diagnostic Executive
- Data Link Connector Location
- Malfunction Indicator Lights
- Malfunction Indicator Light On Steady
- Miscellaneous Tests
- Multiple Powertrain Control Module Information Sensor Diagnostic Trouble Codes Set
- No Malfunction Indicator Light (Check Engine Light)
- Preliminary Check
- Powertrain Control Module Location
- Powertrain Control Module Replacement
- Serial Data Communications
- Verifying Vehicle Repair
- Programming
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0106: Manifold Absolute Pressure Sensor - Circuit/Range Performance Fault
- DTC P0107: Manifold Absolute Pressure Sensor - Low Input
- DTC P0108: Manifold Absolute Pressure Sensor - High Input
- DTC P0112: Intake Air Temperature Sensor - Low Input Voltage
- DTC P0113: Intake Air Temperature Circuit - High Input Voltage
- DTC P0116: Engine Coolant Temperature Sensor - Stuck
- DTC P0117: Engine Coolant Temperature Sensor - Low Voltage
- DTC P0118: Engine Coolant Temperature Sensor - High Input Voltage
- DTC P0121: Throttle Position Sensor - Circuit Range/Performance
- DTC P0122: Throttle Position Sensor - Circuit Low Input
- DTC P0123: Throttle Position Sensor - Circuit High Input
- DTC P0125: Insufficient Temperature For Closed Loop Fuel Control
- DTC P0128: Thermostat Insufficient Temperature For Stable Operation
- DTC P0131: Bank 1 Heated Oxygen Sensor-1 Circuit - Low Voltage
- DTC P0132: Bank 1 Heated Oxygen Sensor-1 Circuit - High Voltage
- DTC P0133: Bank 1 Heated Oxygen Sensor-1 - Slow Response
- DTC P0134: Bank 1 Heated Oxygen Sensor-1 - No Activity Detected
- DTC P0135: Bank 1 Heated Oxygen Sensor-1 - Heater Circuit Malfunction
- DTC P0137: Bank 1 Heated Oxygen Sensor-2 Circuit - Low Voltage
- DTC P0138: Bank 1 Heated Oxygen Sensor-2 Circuit - High Voltage
- DTC P0140: Bank 1 Heated Oxygen Sensor-2 - No Activity Detected
- DTC P0141: Bank 1 Heated Oxygen Sensor-2 - Heater Circuit Malfunction
- DTC P0171: Fuel Trim System Lean
- DTC P0172: Fuel Trim System Rich
- DTC P0201: Cylinder No. 1 Injector Circuit Malfunction, DTC P0202: Cylinder No. 2 Injector Circuit Malfunction, DTC P0203: Cylinder No. 3 Injector Circuit Malfunction Or DTC P0204: Cylinder No. 4 Injector Circuit Malfunction
- DTC P0300: Random/Multiple Cylinder Misfire Detected
- DTC P0301: Random/Multiple Cylinder No. 1 Misfire Detected, DTC P0302: Random/Multiple Cylinder No. 2 Misfire Detected, DTC P0303: Random/Multiple Cylinder No. 3 Misfire Detected Or DTC P0304: Random/Multiple Cylinder No. 4 Misfire Detected
- DTC P0325: Knock Sensor - Circuit Malfunction
- DTC P0327: Knock Sensor Circuit - Low Input
- DTC P0336: Crankshaft Position Sensor Circuit - Range/Performance
- DTC P0337: Crankshaft Position Sensor Circuit - Low Input
- DTC P0341: Camshaft Position Sensor Circuit - Range/Performance Malfunction
- DTC P0342: Camshaft Position Sensor Circuit - Low Input
- DTC P0351: Ignition Coil "A" Primary/Secondary Circuit Malfunction, Or DTC P0352: Ignition Coil "B" Primary/Secondary Circuit Malfunction
- DTC P0401: Exhaust Gas RECIRCULATION System - Insufficient Flow
- DTC P0402: Exhaust Gas RECIRCULATION System - Excessive Flow Detected
- DTC P0404: Exhaust Gas RECIRCULATION System - Range/Performance Malfunction
- DTC P0405: Exhaust Gas RECIRCULATION System - Circuit Low Input
- DTC P0406: Exhaust Gas RECIRCULATION System - Circuit High Input
- DTC P0420: Catalytic CONVERTOR System Efficiency Below Threshold
- DTC P0440: Evaporative Emission Control System Malfunction
- DTC P0442: Evaporative Emission Control System - Small Leak Detected
- DTC P0443: Evaporative Emission Control System - Purge Control Valve Circuit Malfunction
- DTC P0446: Evaporative Emission Control System - Vent Control Circuit Malfunction
- DTC P0449: Evaporative Emission Control System - Vent Valve/Solenoid Circuit Malfunction
- DTC P0452: Fuel Tank Pressure Sensor Low Voltage
- DTC P0453: Fuel Tank Pressure Sensor (Vapor Pressure Sensor) - High Voltage
- DTC P0456: Evaporative Emission Control System - Very Small Leak Detected
- DTC P0461: Fuel Level Sensor Circuit - Range Performance Malfunction
- DTC P0462: Fuel Level Sensor Circuit - Low Input
- DTC P0463: Fuel Level Sensor Circuit - High Input
- DTC P0464: Fuel Level Sensor Circuit - Noisy Signal
- DTC P0480: Cooling Fan 1 Control Circuit Malfunction
- DTC P0481: Cooling Fan 2 Control Malfunction
- DTC P0502: Vehicle Speed Sensor Circuit - Low Input
- DTC P0506: Idle Control System - Rpm Lower Than Expected
- DTC P0507: Idle Control System - Rpm Higher Than Expected
- DTC P0532: A/C Refrigerant Pressure Sensor Circuit - Low Input
- DTC P0533: A/C Refrigerant Pressure Sensor Circuit High
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0601: Powertrain Control Module Memory Check Sum Error
- DTC P1106: Map Sensor Circuit - Intermittent High Voltage
- DTC P1107: Map Sensor Circuit - Intermittent Low Voltage
- DTC P1111: Intake Air Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1112: Intake Air Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1121: Throttle Position Sensor Circuit - Intermittent High Voltage
- DTC P1122: Throttle Position Sensor Circuit - Intermittent Low Voltage
- DTC P1133: Bank 1 Heated Oxygen Sensor-1 - Insufficient Switching
- DTC P1134: Bank 1 Heated Oxygen Sensor-1 - Transition Time Ratio
- DTC P1171: Fuel System Lean During Acceleration
- DTC P1336: Crankshaft Position Sensor System - Variation Not Learned
- DTC P1380: Anti-Lock Brake System - Rough Road System Fault
- DTC P1381: Anti-Lock Brake System - Rough Road Class 2 Serial Data Fault
- DTC P1404: Exhaust Gas RECIRCULATION Closed Valve
- DTC P1441: Evaporative Emissions System - Flow During Non-Purge
- DTC P1546: A/C Compressor Clutch Output Circuit Malfunction
- DTC P1625: Powertrain Control Module Unexpected Result
- DTC P1627: Powertrain Control Module A/D Conversion Malfunction
- DTC P1635: 5-Volt Reference Voltage Circuit Malfunction
- Wiring Diagrams
- Engine Controls - System & Component Testing
- Introduction
- Component Locations
- Computerized Engine Controls
- Sensors & Switches
- Modules & Relays
- Fuel Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous
- A/C Clutch Control (Axiom, Rodeo, & Rodeo Sport 3.2L)
- A/C Clutch Control (Rodeo, & Rodeo Sport 2.2L)
- A/C Clutch Relay
- A/C Clutch Circuit Diagnosis
- Brake Light Switch (Axiom & Rodeo Sport 3.2L)
- Brake Light Switch (Rodeo & Rodeo Sport 2.2L)
- Brake Light Switch With Cruise Control
- Malfunction Indicator Light Does Not Illuminate Or Remains Illuminated
- Misfire Monitor Diagnosis
- Wiring Diagrams
- Engine Controls - Trouble Shooting - No Codes
- Introduction
- Symptoms
- Notes
- Symptom Diagnosis
- Difficult To Start
- Surges Or CHUGGLES
- Lack Of Power, Sluggish Or Spongy
- Abnormal Combustion
- Spark Knock/Detonation
- Hesitation, Sag Or Stumble
- Cuts Out Or Misses
- Poor Fuel Mileage
- Poor Fuel Fill Quality
- Stalling, Rough, Unstable Or Incorrect Idle
- Engine Noisy
- Dieseling (Run-On)
- Backfire
- Engine Oil Consumption Excessive
- Lubrication Problems
- INTERMITTENTS
- Engine Controls - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- No Start Diagnosis
- Fuel System
- Notes
- Fuel System Pressure Release (Axiom, Rodeo & Rodeo Sport)
- Fuel System Pressure Release (Ascender 4.2L)
- Fuel System Pressure Release (Ascender 5.3L)
- Fuel System Diagnosis (Axiom, Rodeo & Rodeo Sport)
- Fuel System Diagnosis (Ascender 4.2L)
- Fuel System Diagnosis (Ascender 5.3L)
- Fuel Pressure Gauge Installation & Removal (Ascender)
- Fuel System Electrical Test
- Fuel Pump Electrical Circuit Diagnosis (Ascender 4.2L)
- Fuel Pump Pressure Test
- Fuel Pump Flow Test
- Fuel Injector Resistance
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 2.2L
- Introduction
- Self-Diagnostic System
- Notes
- On-Board Diagnostics
- On-Board Diagnostic II System Check
- Retrieving Diagnostic Trouble Codes
- Clearing Diagnostic Trouble Codes
- Comprehensive Component Monitor Diagnostic Operation
- System Status And Drive Cycle For Satisfying Federal Inspection/Maintenance (I/M 240) Regulations
- Common OBD-II Terms
- Diagnostic Executive
- Data Link Connector Location
- Malfunction Indicator Lights
- Malfunction Indicator Light On Steady
- Miscellaneous Tests
- Multiple Powertrain Control Module Information Sensor Diagnostic Trouble Codes Set
- No Malfunction Indicator Light (Check Engine Light)
- Preliminary Check
- Powertrain Control Module Location
- Powertrain Control Module Replacement
- Serial Data Communications
- Verifying Vehicle Repair
- Programming
- Summary
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0106: Manifold Absolute Pressure Sensor - Circuit/Range Performance Fault
- DTC P0107: Manifold Absolute Pressure Sensor - Low Input
- DTC P0108: Manifold Absolute Pressure Sensor - High Input
- DTC P0112: Intake Air Temperature Sensor - Low Input Voltage
- DTC P0113: Intake Air Temperature Circuit - High Input Voltage
- DTC P0116: Engine Coolant Temperature Sensor - Stuck
- DTC P0117: Engine Coolant Temperature Sensor - Low Voltage
- DTC P0118: Engine Coolant Temperature Sensor - High Input Voltage
- DTC P0121: Throttle Position Sensor - Circuit Range/Performance
- DTC P0122: Throttle Position Sensor - Circuit Low Input
- DTC P0123: Throttle Position Sensor - Circuit High Input
- DTC P0125: Insufficient Temperature For Closed Loop Fuel Control
- DTC P0128: Thermostat Insufficient Temperature For Stable Operation
- DTC P0131: Bank 1 Heated Oxygen Sensor-1 Circuit - Low Voltage
- DTC P0132: Bank 1 Heated Oxygen Sensor-1 Circuit - High Voltage
- DTC P0133: Bank 1 Heated Oxygen Sensor-1 - Slow Response
- DTC P0134: Bank 1 Heated Oxygen Sensor-1 - No Activity Detected
- DTC P0135: Bank 1 Heated Oxygen Sensor-1 - Heater Circuit Malfunction
- DTC P0137: Bank 1 Heated Oxygen Sensor-2 Circuit - Low Voltage
- DTC P0138: Bank 1 Heated Oxygen Sensor-2 Circuit - High Voltage
- DTC P0140: Bank 1 Heated Oxygen Sensor-2 - No Activity Detected
- DTC P0141: Bank 1 Heated Oxygen Sensor-2 - Heater Circuit Malfunction
- DTC P0171: Fuel Trim System Lean
- DTC P0172: Fuel Trim System Rich
- DTC P0201: Cylinder No. 1 Injector Circuit Malfunction, DTC P0202: Cylinder No. 2 Injector Circuit Malfunction, DTC P0203: Cylinder No. 3 Injector Circuit Malfunction Or DTC P0204: Cylinder No. 4 Injector Circuit Malfunction
- DTC P0300: Random/Multiple Cylinder Misfire Detected
- DTC P0301: Random/Multiple Cylinder No. 1 Misfire Detected, DTC P0302: Random/Multiple Cylinder No. 2 Misfire Detected, DTC P0303: Random/Multiple Cylinder No. 3 Misfire Detected Or DTC P0304: Random/Multiple Cylinder No. 4 Misfire Detected
- DTC P0325: Knock Sensor - Circuit Malfunction
- DTC P0327: Knock Sensor Circuit - Low Input
- DTC P0336: Crankshaft Position Sensor Circuit - Range/Performance
- DTC P0337: Crankshaft Position Sensor Circuit - Low Input
- DTC P0341: Camshaft Position Sensor Circuit - Range/Performance Malfunction
- DTC P0342: Camshaft Position Sensor Circuit - Low Input
- DTC P0351: Ignition Coil "A" Primary/Secondary Circuit Malfunction, Or DTC P0352: Ignition Coil "B" Primary/Secondary Circuit Malfunction
- DTC P0401: Exhaust Gas RECIRCULATION System - Insufficient Flow
- DTC P0402: Exhaust Gas RECIRCULATION System - Excessive Flow Detected
- DTC P0404: Exhaust Gas RECIRCULATION System - Range/Performance Malfunction
- DTC P0405: Exhaust Gas RECIRCULATION System - Circuit Low Input
- DTC P0406: Exhaust Gas RECIRCULATION System - Circuit High Input
- DTC P0420: Catalytic CONVERTOR System Efficiency Below Threshold
- DTC P0440: Evaporative Emission Control System Malfunction
- DTC P0442: Evaporative Emission Control System - Small Leak Detected
- DTC P0443: Evaporative Emission Control System - Purge Control Valve Circuit Malfunction
- DTC P0446: Evaporative Emission Control System - Vent Control Circuit Malfunction
- DTC P0449: Evaporative Emission Control System - Vent Valve/Solenoid Circuit Malfunction
- DTC P0452: Fuel Tank Pressure Sensor Low Voltage
- DTC P0453: Fuel Tank Pressure Sensor (Vapor Pressure Sensor) - High Voltage
- DTC P0456: Evaporative Emission Control System - Very Small Leak Detected
- DTC P0461: Fuel Level Sensor Circuit - Range Performance Malfunction
- DTC P0462: Fuel Level Sensor Circuit - Low Input
- DTC P0463: Fuel Level Sensor Circuit - High Input
- DTC P0464: Fuel Level Sensor Circuit - Noisy Signal
- DTC P0480: Cooling Fan 1 Control Circuit Malfunction
- DTC P0481: Cooling Fan 2 Control Malfunction
- DTC P0502: Vehicle Speed Sensor Circuit - Low Input
- DTC P0506: Idle Control System - Rpm Lower Than Expected
- DTC P0507: Idle Control System - Rpm Higher Than Expected
- DTC P0532: A/C Refrigerant Pressure Sensor Circuit - Low Input
- DTC P0533: A/C Refrigerant Pressure Sensor Circuit High
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0601: Powertrain Control Module Memory Check Sum Error
- DTC P1106: Map Sensor Circuit - Intermittent High Voltage
- DTC P1107: Map Sensor Circuit - Intermittent Low Voltage
- DTC P1111: Intake Air Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1112: Intake Air Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature Sensor Circuit - Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature Sensor Circuit - Intermittent High Voltage
- DTC P1121: Throttle Position Sensor Circuit - Intermittent High Voltage
- DTC P1122: Throttle Position Sensor Circuit - Intermittent Low Voltage
- DTC P1133: Bank 1 Heated Oxygen Sensor-1 - Insufficient Switching
- DTC P1134: Bank 1 Heated Oxygen Sensor-1 - Transition Time Ratio
- DTC P1171: Fuel System Lean During Acceleration
- DTC P1336: Crankshaft Position Sensor System - Variation Not Learned
- DTC P1380: Anti-Lock Brake System - Rough Road System Fault
- DTC P1381: Anti-Lock Brake System - Rough Road Class 2 Serial Data Fault
- DTC P1404: Exhaust Gas RECIRCULATION Closed Valve
- DTC P1441: Evaporative Emissions System - Flow During Non-Purge
- DTC P1546: A/C Compressor Clutch Output Circuit Malfunction
- DTC P1625: Powertrain Control Module Unexpected Result
- DTC P1627: Powertrain Control Module A/D Conversion Malfunction
- DTC P1635: 5-Volt Reference Voltage Circuit Malfunction
- Wiring Diagrams
- Engine Controls - System & Component Testing
- Introduction
- Component Locations
- Computerized Engine Controls
- Sensors & Switches
- Modules & Relays
- Fuel Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous
- A/C Clutch Control (Axiom, Rodeo, & Rodeo Sport 3.2L)
- A/C Clutch Control (Rodeo, & Rodeo Sport 2.2L)
- A/C Clutch Relay
- A/C Clutch Circuit Diagnosis
- Brake Light Switch (Axiom & Rodeo Sport 3.2L)
- Brake Light Switch (Rodeo & Rodeo Sport 2.2L)
- Brake Light Switch With Cruise Control
- Malfunction Indicator Light Does Not Illuminate Or Remains Illuminated
- Misfire Monitor Diagnosis
- Wiring Diagrams
- Engine Controls - Trouble Shooting - No Codes
- Introduction
- Symptoms
- Notes
- Symptom Diagnosis
- Difficult To Start
- Surges Or CHUGGLES
- Lack Of Power, Sluggish Or Spongy
- Abnormal Combustion
- Spark Knock/Detonation
- Hesitation, Sag Or Stumble
- Cuts Out Or Misses
- Poor Fuel Mileage
- Poor Fuel Fill Quality
- Stalling, Rough, Unstable Or Incorrect Idle
- Engine Noisy
- Dieseling (Run-On)
- Backfire
- Engine Oil Consumption Excessive
- Lubrication Problems
- INTERMITTENTS
- Engine Controls - Basic Diagnostic Procedures
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Computerized Engine Controls
- Notes
- Powertrain Control Module
- Pcm Components
- Pcm Voltage (Rodeo Sport 2.2L)
- Electronic Throttle Controls
- Input Devices
- Notes
- 58X Reference PCM Input (Axiom & Rodeo 3.2L)
- 58X Reference PCM Input (Rodeo 2.2L & Rodeo Sport 2.2L)
- A/C Request - A/C On
- Battery Voltage
- Camshaft Position Sensor
- Catalyst Monitor Heated Oxygen Sensors (Axiom & Rodeo 3.2L)
- Catalyst Monitor Heated Oxygen Sensor - Post Catalyst (Rodeo 2.2L & Rodeo Sport 2.2L)
- Crankshaft Position Sensor (Ascender)
- Crankshaft Position Sensor (Axiom)
- EGR Pintle Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Control Heated Oxygen Sensors (Axiom & Rodeo 3.2L)
- Fuel Control Heated Oxygen Sensor - Pre Catalyst (Rodeo 2.2L & Rodeo Sport 2.2L)
- Fuel Cutoff Mode
- Fuel Level Sensor
- Fuel Vapor Pressure Sensor
- Intake Air Temperature Sensor (Axiom & Rodeo 3.2L)
- Intake Air Temperature Sensor (Rodeo 2.2L & Rodeo Sport 2.2L)
- Knock Sensor
- Manifold Absolute Pressure Sensor (Axiom & Rodeo 3.2L)
- Manifold Absolute Pressure Sensor (Rodeo 2.2L & Rodeo Sport 2.2L)
- Mass Airflow Sensor
- Park/Neutral Switch - A/T (Mode Switch) & Inhibitor Switch - M/T
- Power Steering Pressure Switch
- Throttle Position Sensor
- Transmission Fluid Temperature Sensor
- Transmission Range Switch (Mode Switch)
- Vehicle Speed Sensor
- Output Signals
- Notes
- Battery Saver Mode
- CHECK ENGINE Light or Malfunction Indicator Light
- Cooling Fan Relays
- Distributorless Ignition System
- Evaporative Canister Purge Control
- Exhaust Gas Recirculation Valve
- Electronic Spark Advance
- Electronic Spark Timing
- Fuel Disable Mode - Engine Speed
- Deceleration Mode
- Clear Flood Mode
- Acceleration Mode
- Fuel Injectors
- Fuel Pressure Regulator
- Fuel Pump
- Fuel Pump Relay
- Idle Air Control Valve
- Reduced Engine Power Mode
- Fuel System
- Ignition System
- DISTRIBUTORLESS Ignition System
- Notes
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Ignition Timing Control Systems
- Ignition Coils (Ascender)
- Ignition Coils (Axiom & Rodeo 3.2L)
- Ignition Coils (Rodeo 2.2L & Rodeo Sport 2.2L)
- Ignition Control
- Ignition Control (Rodeo 2.2L & Rodeo Sport 2.2L)
- Ignition Control PCM Output
- Ignition Control Module (Rodeo 2.2L & Rodeo Sport 2.2L)
- Pcm
- Spark Plug
- DISTRIBUTORLESS Ignition System
- Emission Systems & Sub-Systems
- Notes
- Evaporative Emission System
- Notes
- Canister Vent Restriction Test
- Check Gas Cap Message
- Enhanced Evaporation Emission Control System
- Electrical Components
- EVAP Canister
- EVAP Purge Solenoid
- EVAP Service Port (Ascender)
- EVAP Vent Solenoid
- Fuel Evaporation Emission Control System
- Fuel Tank Pressure Sensor
- Large Leak Test
- Non-Electrical Components
- Purge Solenoid Leak Test
- Small Leak Test
- System Fault Detection
- On Board Vapor Recovery (ORVR) System
- Exhaust Gas RECIRCULATION System
- Positive Crankcase Ventilation System
- Self-Diagnostic System
- Miscellaneous
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Restraints
- Air Bag And Supplemental Restraint System (SRS) Component Inspection & Replacement Tables
- Air Bag Deactivation Procedures
- Special Care During Mechanical Repairs
- ACURA
- AUDI
- BMW
- HONDA
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling Air Bag System (Accord)
- Activating Air Bag System (Accord)
- Disabling Air Bag System (Civic)
- Activating Air Bag System (Civic)
- Disabling Air Bag System (CR-V, Insight, Odyssey & S2000)
- Activating Air Bag System (CR-V, Insight, Odyssey & S2000)
- Disabling Air Bag System (Element)
- Activating Air Bag System (Element)
- Disabling Air Bag System (Pilot)
- Activating Air Bag System (Pilot)
- HYUNDAI
- INFINITI
- ISUZU
- Jaguar
- KIA
- Land Rover
- LEXUS
- MAZDA
- MERCEDES-BENZ
- MITSUBISHI
- NISSAN
- PORSCHE
- SAAB
- SUBARU
- SUZUKI
- TOYOTA
- VOLKSWAGEN
- VOLVO
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- HVAC Systems
- Service Precaution
- Heating and Ventilation System
- General Description
- Wiring Diagram
- Diagnosis
- Heating Cycle Diagnosis
- Fan Control Lever (Fan Switch) Diagnosis
- Chart "A" Blower Motor Does Not Run
- Chart "B" Blower Motor Does Not Run At Low Position
- Chart "C" Blower Motor Does Not Run At Medium Low Position
- Chart "D" Blower Motor Does Not Run At Medium High Position
- Chart "E" Blower Motor Does Not Run At High Position
- Chart "F" Blower Motor Does Not Stop In The "OFF" Position
- Individual Inspection
- Heater Unit
- Heater Core and / or Mode Door
- Heater Mode Control Link Unit
- Heater Temperature Control Link Unit
- Blower Assembly
- Blower Link Unit and/or Mode Door
- Blower Motor
- Rear Heater Duct, Defroster Nozzle and Ventilation Duct
- Control Lever Assembly and / or Control Cable
- Control Panel Illumination Bulb
- Resistor
- Air Conditioning System
- General Description
- Air Conditioning Refrigerant Cycle Construction
- Evaporation
- Compression
- Condensation
- Expansion
- Compressor
- Magnetic Clutch
- Condenser
- Receiver / Drier
- Dual Pressure Switch (V6, M/T)
- Triple Pressure Switch (V6, A/T)
- Pressure Sensor (L4, X22SE)
- Expansion Valve
- Evaporator
- Electronic Thermostat
- Refrigerant Line
- Air Conditioning Parts
- Wiring Diagram
- General Description
- Diagnosis
- Individual Inspection
- General Repair Procedure
- Leak Check
- Inspection of refrigerant leak
- Inspection flow of refrigerant leak
- Inspection Steps
- Major Checking Points of Refrigerant Leak
- Leak at Refrigerant Line Connections
- Leaks In The Hose
- Compressor Leaks
- Recovery, Recycling, Evacuation and Charging of HFC-134a
- Refrigerant Recovery
- Refrigerant Recycling
- Evacuation of The Refrigerant System
- Charging The Refrigerant System
- Checking The A/C System
- Compressor Assembly
- Condenser Assembly
- Condenser Fan Motor
- Receiver / Drier
- Pressure Switch
- Evaporator Assembly
- Electronic Thermostat, Evaporator Core and/or Expansion Valve
- Refrigerant Line
- Main Data and Specifications
- Compressor
- General Description
- Magnetic Clutch Assembly (DKV-14G Type)
- Compressor Oil
- Special Tools
- HVAC Systems
- Maintenance
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- SRS Diagnostic System Check
- SDM Integrity Check
- Air Bag Warning Light Comes On Steady
- Air Bag Warning Light Does Not Come On Steady
- DTC 15: Passenger Deployment Loop Resistance High
- DTC 16: Passenger Deployment Loop Resistance Low
- DTC 17: Passenger Deployment Loop Open
- DTC 18: Passenger Deployment Loop Short To Ground
- DTC 19: Passenger Deployment Loop Short To Voltage
- DTC 21: Driver Deployment Loop Resistance High
- DTC 22: Driver Deployment Loop Resistance Low
- DTC 24: Driver Deployment Loop Short To Ground
- DTC 25: Driver Deployment Loop Short To Voltage
- DTC 26: Driver Deployment Loop Open
- DTC 51: Deployment Event Commanded
- DTC 53: Deployment Event Commanded With Deployment Loop Fault Or Energy Reserves Out Of Range
- DTC 61: Warning Light Circuit Failure
- DTC 71: Internal SDM Fault
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Manual Steering
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Maintenance
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Power Steering
- Power-Assisted Steering System
- Service Precaution
- Diagnosis
- General Description
- Power Steering System Test
- Maintenance
- Fluid Level
- Bleeding The Power Steering System
- Bleeding Procedure
- Flushing The Power Steering System
- Steering Wheel Free Play Inspection
- Front End Alignment Inspection and Adjustment
- Main Data and Specifications
- Special Tools
- Power Steering Unit
- Power Steering Pump
- Transfer Gear Assembly
- Supplemental Restraint System Steering Wheel & Column
- Inflator Module
- Steering Wheel
- Combination Switch
- Lock Cylinder
- Steering Column
- Supplemental Restraint System Steering Wheel & Column and Associated Parts
- Power-Assisted Steering System
- Manual Steering
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Wheels & Tire System
- Intelligent Suspension System
- Service Precaution
- General Description
- General Diagnosis
- DTC 2: Actuator Coil Over Current
- DTC 3: Actuator Coil/Position Sensor Open Circuit or Short
- DTC 4: G-Sensor Open Circuit or Short
- DTC 5: Vehicle Speed Sensor Open Circuit or Short
- DTC 6: Stop Lamp Switch Open Circuit or Short
- DTC 7: Engine Speed Signal Open Circuit or Short
- DTC 9: Control Unit Abnormality
- Control Unit
- Front Actuator
- Rear Shock Absorber
- Wheel & Tire System
- Intelligent Suspension System
- Transmission
- Automatic Trans
- Automatic Trans (4L30-E)
- Service Precaution
- Construction
- Range Reference Chart
- Normal Operation of 2001 4L30-E Transmission
- Diagnosis
- Driver Information
- General Diagnosis Procedure
- Preliminary Inspection Chart
- Checking Transmission Fluid Level and Condition
- Test Driving
- Mechanical / Hydraulic Diagnosis Check Trans Indicator Chart
- Mechanical / Hydraulic Diagnosis Symptoms Index
- Stall Test
- Line Pressure Test
- Shift Speed Chart (V6)
- Lockup Speed Chart
- Shift Speed Chart (HEC)
- Changing Transmission Fluid
- Selector Lever
- Select Cable
- Shift Lock Cable
- Mode Switch
- Transmission Assembly
- Solenoid (Main Case Valve Body)
- Solenoid (Adapter Case Valve Body)
- Valve Body Assembly (Main Case)
- Valve Body Assembly (Adapter Case)
- Powertrain Control Module (PCM) (V6)
- Powertrain Control Module (PCM) (HEC)
- Speed Sensor (Extension Assembly)
- Transmission Oil Temperature Sensor (Main Case) (V6)
- Transmission Oil Temperature Sensor (Adapter Case) (HEC)
- Front Oil Seal (Converter Housing)
- Rear Oil Seal (Extension Assembly)
- Transmission (4L30-E)
- Converter Housing and Oil Pump Assembly
- Oil Pump
- Main Case Valve Body
- Adapter Case Valve Body
- Third Clutch and Sprag Unit
- Third Clutch
- Sprag Unit
- Second Clutch
- 3-4 Accumulator Piston
- Reverse Clutch Piston and Center Support
- Overrun Clutch and Turbine Shaft
- Main Data and Specifications
- Special Tools
- 4L30-E Parts List
- Transmission Control System (4L30-E) (HEC2.2L)
- Service Precaution
- General Description
- Notes
- Electronic Control Diagram
- Powertrain Control Module (PCM)
- Control System Diagram
- Shift Control
- Band Apply Control
- Torque Converter Clutch Control
- Line Pressure Control
- On-Board Diagnostic System
- Fail-Safe Mechanism
- Torque Management Control
- ATF Warning Control
- Reverse Lock Out Control
- Downhill Control
- Uphill Control
- Shift Mode Control
- Gear Shift Control
- Winter Drive Mode
- Backup Mode
- Transmission Range Switch
- Functions of Input / Output Components
- Diagnosis
- Electronic Diagnosis
- Check Trans Indicator
- Diagnostic Check
- "Check Trans" Check
- Tech 2 OBD II Connection
- OBD II Diagnostic Management System
- 16 - Terminal Data Link Connector (DLC)
- Malfunction Indicator Lamp (MIL)
- DTC Types
- Clear DTC
- DTC Check
- PCM Precaution
- Information On PCM
- Intermittent Conditions
- Transmission and PCM Identification
- Isuzu Rodeo
- Diagnostic Trouble Code (DTC) Identification
- DTC P0218: Transmission Fluid Over Temperature
- DTC P0560: System Voltage Malfunction
- DTC P0705: Transmission Range Switch (Mode Switch) Illegal Position
- DTC P0706: Transmission Range Switch (Mode Switch) Performance
- DTC P0711: Transmission Fluid Temperature (TFT) Sensor Performance
- DTC P0712: Transmission Fluid Temperature (TFT) Sensor Circuit Low Input
- DTC P0713: Transmission Fluid Temperature (TFT) Sensor Circuit High Input
- DTC P0719: Brake Switch Circuit Low (Stuck On)
- DTC P0722: Automatic Transmission Output Shaft Speed Sensor (OSS) Low Input
- DTC P0723: Automatic Transmission Output Shaft Speed Sensor (OSS) Intermittent
- DTC P0724: Brake Switch Circuit High (Stuck Off)
- DTC P0730: Gear Error Without Input Speed
- DTC P0742: Torque Converter Clutch (TCC) System Stuck On
- DTC P0748: Pressure Control Solenoid (PCS) (Force Motor) Circuit Electrical
- DTC P0751: Shift Solenoid A Performance Without Input Speed Or Stuck Off
- DTC P0753: Shift Solenoid A Electrical
- DTC P0756: Shift Solenoid B Performance Without Input Speed Or Stuck Off
- DTC P0758 Shift Solenoid B Electrical
- DTC P1790: ROM Transmission Side Bad Check Sum
- DTC P1792: EEPROM Transmission Side Bad Check Sum
- DTC P1835: Kickdown Switch Always On
- DTC P1850: Brake Band Apply Solenoid Malfunction
- DTC P1860: TCC Solenoid Electrical
- DTC P1870: Transmission Component Slipping (TCC Stuck Off)
- Circuit Diagram
- Parts Location
- Harness Connector Faces
- Automatic Trans (4L30-E)
- Transfer Case
- Driveline Control System
- Transfer Case
- Service Precaution
- General Description
- Transfer Rear Oil Seal
- Transfer Case Assembly
- Transfer Control Unit
- Transfer Disassembly
- Main Data and Specifications
- Transfer Case Control System
- Transfer Controller
- Notes
- Removal
- Installation
- Function of Switch and Indicator Lamp
- 2H to 4H Retrial
- Parts Location
- Circuit Diagram
- Connector List
- Diagnosis
- Diagnosis From Symptom
- Check 4WD Lighting Up
- Cannot shift from 2WD to 4H or 4L. When shifting from 2H to other position, the indicator (4WD, 4Lo, Check 4WD) does not respond.
- Even after correction step 1-1(Before determining a trouble (Non-trouble mode)), the 4WD indicator still blinks at 2Hz and clicking sound of relay continues.
- Even after the correction step 1-2(Before determining a trouble (Non-trouble mode)), the 4WD indicator still blinks at 2Hz when shifting with clicking sound of relay from 2H to 4H.
- After operation, indicator of target position blinks for 1.5 sec. at 2Hz, return to 2H condition (4WD indicator going out)
- Transfer cannot shift to a position other than 4H. When shifting from 4H to other position, indicator (4WD, 4Lo, Check 4WD) does not respond (Only 4WD keeps lighting).
- Even after the correction step 2-1(Before determining a trouble (Non-trouble mode)), the 4WD indicator still blinks at 2Hz when shifting from 4H to 2H.
- Though the indicator responds when shifting from 4H to 2H (or other position), it returns to 4H.
- From 4H to 4L; Even after the correction step 3-3(Before determining a trouble (Non-trouble mode)), 4Lo indicator blinks at 4Hz
- From 4L to 4H: After the correction step 4-3(Before determining a trouble (Non-trouble mode)), 4Lo indicator blinks at 4H.
- Transmission Control Systems
- Automatic Trans
- External Pages