Technical Service Bulletins

A/C Compressor
- Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
Accessories Control Systems
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- I-View Update Instructions V4 (SSM71383)
- Fuel Sender Unit Fault - Incorrect Diagnosis (SSM51357)
- TV Does Not Receive MPEG 4 Signal (SSM71928)
- Mongoose Update Instructions (SSM71399)
- Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
- Led Trailer Light Boards (SSM37157)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
- New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
Accessory Drive Belts
- Chirping Noise From Accessory Drive Belt - Misaligned Belt - Replace FEAD TENSIONER (303-59)
- Possible Alternator Mounting Bracket Contact - Replace Front Auxiliary Drive Belt - Service Action S490 (SECTION 303, NO. S490)
Air Bag, SRS
- Counterfeit Airbags - Essential Vigilance In All Jaguar Land Rover Networks (LAB 00050)
- Counterfeit Airbags - Essential Vigilance In All Jaguar Land Rover Networks (JAB00044)
Anti-Lock Brakes
- SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
Anti-Theft Systems
- Unable To Lock Vehicle With Remote Key Fob - Repair Procedure (JTB00106)
- Door Latch Issues - Door Ajar Switch Now Available Separately - Replacement Procedure (SECTION 501, NO. 54)
Automatic Trans
- Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
- Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
- I-View Update Instructions V4 (SSM71383)
- DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
- Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
- Remanufactured W5A-580 Transmission - Harsh Shifts - Install Revised Valve Body (307-22)
Auxiliary Emission Control Systems
- Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
- Part-Load Engine Breather - Partial Blockage Of RESTRICTOR - Scheduled Cleaning - Service Action S474 (600-03)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- Part-Load Engine Breather - Partial Blockage Of RESTRICTOR - Scheduled Cleaning - Service Action S474 (SECTION 600, NO. 03)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
Axle Shafts
- Front Axle Shafts - Check Retention In CV Joint - Service Action S930 (XT205-S930)
Body Electrical
- Quiescent Drain Current - Specifications - Not In Workshop Manual (414-03)
Body Interior
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
Brakes Control Systems
- Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
- I-View Update Instructions V4 (SSM71383)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
- New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
Charging Systems
- Mandatory Software Update For The JLR MIDTRONICS Exp-1080 Battery Tester (JAB00027)
- Possible Alternator Mounting Bracket Contact - Replace Front Auxiliary Drive Belt - Service Action S490 (SECTION 303, NO. S490)
Communication Devices
- Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
- Check Customers Phone Compatibility Using The Jaguar Website (SSM44191)
- Jaguar Cellular Telephone - AUDIOTRONICS Technical Hotline (SECTION 419, NO. 02)
- Telephone Interference - Install Generator Suppression Module (414-04)
Cooling System (Mechanical)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Coolant Pumps - Identifying Impeller Material - Pump Replacement Guidelines (303-60)
- Overheating - Thermostat Stuck Closed - Revised Thermostat Available (303-54)
- Thermostat Sticking Closed - Improved Thermostat Introduced (303-25)
Differentials & Drive Axles
- Shaft Protector - Tool No 205-272-01 (SECTION 1, NO. 116)
Engine Control Systems
- Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74982)
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
- Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
- I-View Update Instructions V4 (SSM71383)
- DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
- Symptom Driven Diagnostics (SDD) Getting Started Guide (SSM71898)
- Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- Vehicle Communication Device Fails To Communicate To A Vehicle After Update (SSM70058)
- SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
- Vehicle Stall Questionnaire - Gasoline Models (SSM46817)
- Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
- Legacy Jaguar Vehicles - Advice For Viewing DTC'S With SDD (SSM45956)
- Windows XP Professional-Service Pack 2 & Internet Explorer V6.0 (SSM41093)
- Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
- Check Engine Mil - DTC P0121 Flagged - Connector Material Mismatch - AJ27 Engines - Modify Harness (303-58)
- Hesitation When Cold - Supercharged AJ 27 Engines - REFLASH ECM (SECTION 303, NO. 53)
- "Restricted Performance" Displayed On Message Center - AJ27 SC Engines (SECTION 303, NO. 49)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
- A-Bank Camshaft Sensor Harness Contacting EGR Pipe - Check/Install Tie Strap - Service Action S704 (SECTION 303, NO. S704)
- New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- Difficult Cold Start - ECM Flash Reprogramming - Service Action S471 (303-33)
- Drivability Concerns After Repair - Resetting ECM Adaptation (303-01)
Entertainment Systems
- TV Does Not Receive MPEG 4 Signal (SSM71928)
- Audio System Repair - New Address Information (SECTION 3, NO. 165)
- Radio Station Cut Out - RBDS - Disable Alternative Frequency Feature (415-07)
Exhaust
- Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
Exterior Body Panels
- Service Action: Fuel Filler Cap Difficult To Install/Check Engine Mil On - Revised Fuel Filler Cap (S509)
Exterior Lights
- Led Trailer Light Boards (SSM37157)
Front Suspension
- Shock Absorbers - Revised Warranty Replacement Policy (SECTION 204, NO. 19)
- Revised Front Bushings - Revised Special Tools - Replacement Procedure (SECTION 204, NO. 11)
Fuel System
- Jaguar AJ-V8 Fuel Injector Cleaning Equipment (SSM39211)
- Vehicle Stall Questionnaire - Gasoline Models (SSM46817)
- Service Action: Fuel Filler Cap Difficult To Install/Check Engine Mil On - Revised Fuel Filler Cap (S509)
- Loss Of Engine Performance - Intake Ducts Loose - Install Revised Parts (303-57)
- Difficulty Filling Fuel Tank - Fuel Gauge Not Indicating Full - Spit Back/Premature Shut Off - Diagnosis (310-10)
Gauges & Instrument Panels
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Fuel Sender Unit Fault - Incorrect Diagnosis (SSM51357)
- Door Latch Issues - Door Ajar Switch Now Available Separately - Replacement Procedure (SECTION 501, NO. 54)
- Difficulty Filling Fuel Tank - Fuel Gauge Not Indicating Full - Spit Back/Premature Shut Off - Diagnosis (310-10)
General Servicing
- Leak Detection System - Ultraviolet Dye (412-03)
HVAC Control Systems
- Air Conditioning - Refrigerant Circuit - Leak Reporting (SECTION 3, NO. 170)
- Leak Detection System - Ultraviolet Dye (412-03)
Infotainment
- Alpine Navigation System - DVD-Driven Diagnosis - Repair (419-11)
- Navigation System Exchange Program - V8 XJ Series And XK Range (SECTION 6, NO. 97)
- Accessory Installation Of Navigation System - Clarification (SECTION 419, NO. 10)
- Alpine Navigation System - DVD-Driven Diagnosis - Repair (SECTION 419, NO. 11)
Interior/Exterior Trim
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Draft Welt Loose - Front Door Opening - Install Edge Finisher (SECTION 501, NO. 50)
- Wood Veneer Repair Program (SECTION 3, NO. 158)
Interior/Illumination Lights
- Damaged J-Gate Gasket - Available Separately - Repair Procedure (SECTION 307, NO. 07)
- Quiescent Drain Current - Specifications - Not In Workshop Manual (414-03)
Lubrication System
- Oil Leaks From Oil Filter - Filter Loosens - Revised Tightening Method (SECTION 303, NO. 51)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- AJV6 / AJV8 Engines - Aluminum Component Thread Repair (JTB00136)
- Oil Leaks From Oil Filter - Filter Loosens - Revised Tightening Method (SECTION 303, NO. 51)
- Possible Alternator Mounting Bracket Contact - Replace Front Auxiliary Drive Belt - Service Action S490 (SECTION 303, NO. S490)
Memory Modules
- Memory Systems - Driver's Seat, Steering Column, Door Mirrors - Diagnostics (501-51)
Mirrors
- Memory Systems - Driver's Seat, Steering Column, Door Mirrors - Diagnostics (501-51)
Paint & Coatings
- Exterior Paint Issues Reporting Aid (XJ501-023)
Parking Brake System
- Parking Brake Does Not Release (JTB00044)
Procedures
- Calibration And As-Built Servers Requires Maintenance Which Will Involve The Server Being Offline (SSM75440)
- Lower Than Actual Compression Figures Using The K00825-0/JLR-4425 COMPRESSIOR Tester Kit (SSM75380)
- Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74982)
- Symptom Driven Diagnostics (SDD) Displays Update Icon And Reduced Functionality If Not Updated (SSM74881)
- SDD Software Update Icon Is Displayed And When Trying To Update 'No Update AVAILABLE' Is Displayed (SSM74809)
- SDD Software Update Icon Is Displayed And When Trying To Update 'No Update AVAILABLE' Is Displayed (SSM74805)
- Required Internet Option Setting To Correct Security Update For JLR Server Access (SSM74720)
- Error Code 903 - 'Incorrect Service IDENTIFICATION' When Updating Vehicle Module Software Using SDD (SSM74542)
- Unable To Log Into SDD And Pathfinder (SSM74324)
- Unable To Install Or Update Pathfinder On Approved Diagnostic Equipment (SSM74010)
- Unable To Install Or Update Pathfinder On Devices With 256GB Solid State Drive (SSM74010)
- Installing Approved Diagnostic Software Applications (SSM74011)
- Notice - Essential Maintenance For Calibration And As-Built Servers (SSM74002)
- Unable To Login To Pathfinder (SSM73894)
- Unable To Login To Symptom Driven Diagnostics (SDD) And Pathfinder (SSM73894)
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
Rear Suspension
- Shock Absorbers - Revised Warranty Replacement Policy (SECTION 204, NO. 19)
Restraints Control Systems
- Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
- I-View Update Instructions V4 (SSM71383)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
- New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
Schedule
- Part-Load Engine Breather - Partial Blockage Of RESTRICTOR - Scheduled Cleaning - Service Action S474 (SECTION 600, NO. 03)
- Scheduled Maintenance Program - 2001 My Vehicles (SECTION 6, NO. 87)
Seats
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Memory Systems - Driver's Seat, Steering Column, Door Mirrors - Diagnostics (501-51)
- Rattle From Unoccupied Front Seat - Change PRETENSIONER Bungee Cords (SECTION 501, NO. 48)
Starter
- Mandatory Software Update For The JLR MIDTRONICS Exp-1080 Battery Tester (JAB00027)
- Batteries - Use Of Interstate Batteries (SECTION 3, NO. 174)
- Intermittently Discharged Battery - Diagnostic Procedure (SECTION 414, NO. 06)
- Low Maintenance Battery - Recommended Practices (SECTION 414, NO. 02)
- Micro 490 Battery Tester - Jaguar Recommended (SECTION 1, NO. 112)
- Quiescent Drain Current - Specifications - Not In Workshop Manual (414-03)
Steering Column
- Steering Rack Knocking Or Rattling - Revised Lower Steering Column/Rack Return Line - Repair Procedure (211-06)
- Memory Systems - Driver's Seat, Steering Column, Door Mirrors - Diagnostics (501-51)
Steering Control Systems
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
Steering Gear
- Revised Workshop Procedure - Remove/Install Steering Gear (JTB00092)
- Steering Rack Knocking Or Rattling - Revised Lower Steering Column/Rack Return Line - Repair Procedure (211-06)
Suspension Control Systems
- I-View Update Instructions V4 (SSM71383)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
System
- SDD 152.05 Diagnostic Trouble Codes (DTC) Not Shown In Some Modules (SSM73807)
- Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
- Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
- I-View Update Instructions V4 (SSM71383)
- DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
- Symptom Driven Diagnostics (SDD) Getting Started Guide (SSM71898)
- Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- Vehicle Stall Questionnaire - Gasoline Models (SSM46817)
- Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
- Legacy Jaguar Vehicles - Advice For Viewing DTC'S With SDD (SSM45956)
- Windows XP Professional-Service Pack 2 & Internet Explorer V6.0 (SSM41093)
- Service Action: Fuel Filler Cap Difficult To Install/Check Engine Mil On - Revised Fuel Filler Cap (S509)
- Check Engine Mil - DTC P0121 Flagged - Connector Material Mismatch - AJ27 Engines - Modify Harness (303-58)
- Hesitation When Cold - Supercharged AJ 27 Engines - REFLASH ECM (SECTION 303, NO. 53)
- "Restricted Performance" Displayed On Message Center - AJ27 SC Engines (SECTION 303, NO. 49)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Part-Load Engine Breather - Partial Blockage Of RESTRICTOR - Scheduled Cleaning - Service Action S474 (SECTION 600, NO. 03)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
- A-Bank Camshaft Sensor Harness Contacting EGR Pipe - Check/Install Tie Strap - Service Action S704 (SECTION 303, NO. S704)
- New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
- Micro 490 Battery Tester - Jaguar Recommended (SECTION 1, NO. 112)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
Transmission Control Systems
- Diagnostic Tool IDU2 And NVH Sensor Use (SSM72941)
- Installation Concerns Experienced With The Release Of SDD 140.01 (SSM72210)
- I-View Update Instructions V4 (SSM71383)
- DA-Dongle/DA-Vina J2534/St512 Update Instructions V5 (SSM71361)
- Unable To Communicate With Pcm On Legacy Jaguar Vehicles Using DVD133 (SSM63597)
- Important Firmware Update Required For The DA Dongle/DA-Vina (SSM65058)
- Mongoose Update Instructions (SSM71399)
- SDD Displays A 'System ERROR' When Attempting To Programme Modules (SSM66517)
- Improving Diagnostics For Warning Lamp Symptoms And Messages (SSM51117)
- Legacy Jaguar Vehicles - Advice For Viewing DTC'S With SDD (SSM45956)
- Shift Quality Issues/Harsh Engagement With Engine Cold - ZF 5HP26 - Install New Transmission Control Module (307-14)
- JTP 759/13 WDS Software (SECTION 1, NO. 130)
- JTP 759/10 WDS Software (SECTION 1, NO. 126)
- Damaged J-Gate Gasket - Available Separately - Repair Procedure (SECTION 307, NO. 07)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 627/10 Replaces JTP 627/9 & JTP 627/9A (SECTION 1, NO. 119)
- New PDU Software - JTP 627/9A Replaces JTP 627/9 (SECTION 1, NO. 115)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
Warning Systems
- Door Latch Issues - Door Ajar Switch Now Available Separately - Replacement Procedure (SECTION 501, NO. 54)
Wheels & Tire System
- Vibration/Shimmy - Tire Radial Force Variation - Optimizing Wheel And Tires (SECTION 204, NO. 17)
- Use Of Aftermarket Wheels & Tires - No Recommended - Effect On Warranty (SECTION 6, NO. 88)
Window Motors & Regulators
- Windshield Damage Diagnostic Aid (JAGA501-001)
Wiper/Washer Systems
- Removing Transit Wiper Protection At PDI (XJ501-024)
- Windshield Wiper - Streaking Or Juddering - Repair Policy (SECTION 501, NO. 27)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Check Engine Mil - DTC P0121 Flagged - Connector Material Mismatch - AJ27 Engines - Modify Harness (303-58)
- A-Bank Camshaft Sensor Harness Contacting EGR Pipe - Check/Install Tie Strap - Service Action S704 (SECTION 303, NO. S704)