Technical Service Bulletins

A/C Compressor
- Servicing R1234YF A/C Systems Using The MAHLE ACX1299 (SST054 REV3)
- A/C Lubricant Guidelines (CLI007)
Accessories & Equipment
- Introduction To Pin Tension Gauge (SST062)
Accessories Control Systems
- SIMPLIFIED UVO eSERVICES ACTIVATION PROCEDURE (ELEPS428)
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- DTC Scanning Techniques And Best Practices (GEN064)
- Fuse For Power Accessory Socket And Cigar Lighter Blown Due To The Use Of Aftermarket Cellular Chargers Or Similar Plug In Devices (KT2009112001)
- New SST Release And Return Of The Black Break Out Box Main Cable (GEN025)
- Audio Interference When Using Cellular Phone (ACC004)
Air Bag, SRS
- Aftermarket Modification Warnings, (Seat, Seat Cover, Seat Belts, Etc.) (GEN050)
- UNDEPLOYED Airbag/Pre-TENSIONER Demonstration (General - 016) (KT2007051501)
- UNDEPLOYED Airbag/Pre-TENSIONER Demonstration (GEN016)
Anti-Lock Brakes
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- KIA Diagnostic System (KDS) Requirements (SST-035)
- DTC Scanning Techniques And Best Practices (GEN064)
- PITSTOP: MDPS Steering Wheel Centering Adjustment Procedure During Alignment (PS192)
Anti-Theft Systems
- Smart Key Access INOP Due To Radio Frequency (RF) Interference (ELEPS426)
- DTC Scanning Techniques And Best Practices (GEN064)
- PITSTOP: Key Tags, Key Code Number And Cutting Keys (PS191)
- Remote Keyless Entry (RKE) Tester (SST004)
- Key Duplication Information (GEN002R4)
- Key Duplication Information (General Information - 002, Revision 4) (GENERAL INFO. 002 R)
- SEPHIA/Spectra Front Door Latch (BOD020)
Automatic Trans
- KDS VCI-II Screws And/Or Case Replacement (SST056)
- Mandatory Replacement Of Locking/Security Hardware (GEN085)
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- KIA Diagnostic System (KDS) Requirements (SST-035)
- DTC Scanning Techniques And Best Practices (GEN064)
- Automatic Transmission Fluid Application Guide (TRA 046)
- Proper Checking Of The Automatic Transmission Fluid Level (KT2009043001)
- New SST Release And Return Of The Black Break Out Box Main Cable (GEN025)
- KIA Remanufactured Automatic Transmission Program (Trans/Driveline - 003, Revision 4) (TRA003 R4)
- Automatic Transaxle Diagnosis For SEPHIA/Spectra/RIO (TRA008)
- Remanufactured Automatic Transmission Cooler Pipe Deletion (TRA006)
Auxiliary Emission Control Systems
- Tech Tip: DTC P0449 After Purge Control Valve Replacement (TT043)
Axle Shafts
- Driveshaft Serviceability (TRA047 REV 2)
Body Electrical
- New KIA Wire Harness Repair Kit IV (GEN083)
- Replacement Wire Repair Connectors (GEN082)
- Introduction To "T" Connectors (ELE064)
- Fuse For Power Accessory Socket And Cigar Lighter Blown Due To The Use Of Aftermarket Cellular Chargers Or Similar Plug In Devices (KT2009112001)
- Powertrain Grounds (KT2009083101)
- STABILANT 22A® - Application Update (KT2009032702)
Body Interior
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- Global Diagnostic System (GDS) Unit Requirement (SST026 REV1)
- DTC Scanning Techniques And Best Practices (GEN064)
Brakes Control Systems
- New SST Release And Return Of The Black Break Out Box Main Cable (GEN025)
Charging Systems
- Replacement Wire Repair Connectors (GEN082)
- Tech Tip: Entering Correct Battery Data Into Gr8-1299 Charger (TT056)
- 1.8 Liter SEPHIA/Spectra Charging System (ENG017)
Communication Devices
- KVID App Installation On Existing KDS Tablets (SST058)
- SIMPLIFIED UVO eSERVICES ACTIVATION PROCEDURE (ELEPS428)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- Driveshaft Serviceability (TRA047 REV 2)
Engine Control Systems
- KDS VCI-II Screws And/Or Case Replacement (SST056)
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- External Device On DLC Port Causing Concerns (PS420)
- KIA Diagnostic System (KDS) Requirements (SST-035)
- Tech Tip: DTC P0449 After Purge Control Valve Replacement (TT043)
- Global Diagnostic System (GDS) Unit Requirement (SST026 REV1)
- DTC Scanning Techniques And Best Practices (GEN064)
- Everything You Ever Wanted To Know About Variant Coding But Were Afraid To Ask (KT2010031901-2)
- Powertrain Grounds (KT2009083101)
- DELPHI Electronic Throttle Control - TP Sensor Screw Availability (KT2009032703)
- New SST Release And Return Of The Black Break Out Box Main Cable (SST025)
- New SST Release And Return Of The Black Break Out Box Main Cable (GEN025)
- 1.8 Liter SEPHIA/Spectra Charging System (ENG017)
- Quick Connect Fuel Line Tool (FUE005)
- Automatic Transaxle Diagnosis For SEPHIA/Spectra/RIO (TRA008)
Entertainment Systems
- KVID App Installation On Existing KDS Tablets (SST058)
- SIMPLIFIED UVO eSERVICES ACTIVATION PROCEDURE (ELEPS428)
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- SIRIUS Satellite Radio (General Information - 023) (KT2008071101)
- Audio Unit Reset Procedures (Accessories - 005) (ACC005)
- Audio Interference When Using Cellular Phone (ACC004)
Exterior Body Panels
- SEPHIA/Spectra Front Door Latch (BOD020)
Exterior Lights
- Information For Headlamp Condensation And Moisture (BOD055 REV 1)
Frames, Subframes & Crossmembers
- Lock Nut Reuse Prohibited (CHA013)
Front Suspension
- Lock Nut Reuse Prohibited (CHA013)
Fuel System
- Tech Tip: DTC P0449 After Purge Control Valve Replacement (TT043)
- Fuel Economy Information - Al Models (GEN017REV2)
- Fuel System Cleaner Recommendation And Fuel Quality Information (FUEL022)
- Fuel Mileage Information And Economy (General Information - 012) (GEN012)
- Fuel Cap Tester (SST008)
- Throttle Body Cleaning (FUE010)
- Quick Connect Fuel Line Tool (FUE005)
Fuses & Circuit Breakers
- Fuse For Power Accessory Socket And Cigar Lighter Blown Due To The Use Of Aftermarket Cellular Chargers Or Similar Plug In Devices (KT2009112001)
Hazardous Waste Material
- Hazardous Materials (Hazmat) Information (GEN 063B)
- Disposal/Handling Of PERCHLORATE Containing Materials Under CALIFORNIA Law (General Information - 015) (GEN015)
Headlights
- Information For Headlamp Condensation And Moisture (BOD055 REV 1)
HVAC Control Systems
- Servicing R1234YF A/C Systems Using The MAHLE ACX1299 (SST054 REV3)
- A/C Lubricant Guidelines (CLI007)
Identification
- Load Carrying Capacity Label Requirements And Instruction To Comply With FMVSS110 (KT2008053001)
Ignition Switch/Steering Lock
- DTC Scanning Techniques And Best Practices (GEN064)
- PITSTOP: Key Tags, Key Code Number And Cutting Keys (PS191)
- Key Duplication Information (General Information - 002, Revision 4) (GENERAL INFO. 002 R)
Infotainment
- SIMPLIFIED UVO eSERVICES ACTIVATION PROCEDURE (ELEPS428)
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
Interior/Exterior Trim
- Mandatory Replacement Of Locking/Security Hardware (GEN085)
- Audio Interference When Using Cellular Phone (ACC004)
Lubrication System
- Aftermarket Oil Filters And Oil Viscosity (ENG 114 REV 1)
- Aftermarket Oil Filters (114)
Manual Steering
- Lock Nut Reuse Prohibited (CHA013)
Manual Trans
- Mandatory Replacement Of Locking/Security Hardware (GEN085)
- Automatic Transmission Fluid Application Guide (TRA 046)
Mechanical
- Engine Component Re-Use Guidelines (PS539 REV 1)
- Engine Replacement Practices Reminder (ENG190 REV 1)
- Mandatory Replacement Of Locking/Security Hardware (GEN085)
- Aftermarket Oil Filters And Oil Viscosity (ENG 114 REV 1)
- Tech Tip: Valve Clearance Specs Not Listed In Shop Manual (TT048)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Internal Engine Component Awareness During Catastrophic Failure (PS213)
- Aftermarket Oil Filters (114)
- Engine Remanufacturing Return Concerns (KT2009051201)
- KIA Remanufactured Engine Program (ENG042)
- Lock Nut Reuse Prohibited (CHA013)
Mechanical - Hydraulic
- Mandatory Replacement Of Locking/Security Hardware (GEN085)
- Precaution Before Adding Or Changing Brake Fluid (GEN039)
- Front Brake Rotor And Pad Change (CHA008)
Paint & Coatings
- KIA Paint Information (BOD037)
- 1993-2004 Paint Codes (PAI006R5)
- 1993-2004 Paint Codes (PAI006)
Passive Restraints
- Aftermarket Modification Warnings, (Seat, Seat Cover, Seat Belts, Etc.) (GEN050)
Procedures
- Services And Products Not Recommended By KIA (GEN 058)
Rear Suspension
- Lock Nut Reuse Prohibited (CHA013)
Restraints Control Systems
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- KIA Diagnostic System (KDS) Requirements (SST-035)
- DTC Scanning Techniques And Best Practices (GEN064)
- "Passenger Air Bag Off" Indicator Light Operation (GEN020)
- UNDEPLOYED Airbag/Pre-TENSIONER Demonstration (General - 016) (KT2007051501)
Schedule
- Services And Products Not Recommended By KIA (GEN 058)
Seats
- Aftermarket Modification Warnings, (Seat, Seat Cover, Seat Belts, Etc.) (GEN050)
Starter
- KIA Smart Battery Tester (B2Q) And Warranty Policy (SST070)
- KIA Smart Battery Tester Application Download And Initial Login (PS565 REV 4)
- AGM Battery Charging Procedure (SST066)
- KIA Smart Battery Tester V1.8 Replacement (SST061)
- KIA Smart Battery Tester User Guide (SST057)
- KIA Smart Battery Tester Introduction (SST059)
- Tech Tip: Entering Correct Battery Data Into Gr8-1299 Charger (TT056)
- Battery Tester And Diagnostic Charger (SST022)
- MIDTRONICS Battery Tester (SST002)
Steering Column
- PITSTOP: MDPS Steering Wheel Centering Adjustment Procedure During Alignment (PS192)
- Key Duplication Information (GEN002R4)
Steering Control Systems
- DTC Scanning Techniques And Best Practices (GEN064)
Steering Gear
- Lock Nut Reuse Prohibited (CHA013)
Steering Linkage
- Lock Nut Reuse Prohibited (CHA013)
Suspension Control Systems
- TPMS Equipped Tire And Rim Assembly/Disassembly (Chassis - 014) (CHA014)
System
- KDS VCI-II Screws And/Or Case Replacement (SST056)
- External Device On DLC Port Causing Concerns (PS420)
- KIA Diagnostic System (KDS) Requirements (SST-035)
- Tech Tip: DTC P0449 After Purge Control Valve Replacement (TT043)
- Global Diagnostic System (GDS) Unit Requirement (SST026 REV1)
- DTC Scanning Techniques And Best Practices (GEN064)
- Everything You Ever Wanted To Know About Variant Coding But Were Afraid To Ask (KT2010031901-2)
- Powertrain Grounds (KT2009083101)
- DELPHI Electronic Throttle Control - TP Sensor Screw Availability (KT2009032703)
- New SST Release And Return Of The Black Break Out Box Main Cable (SST025)
- New SST Release And Return Of The Black Break Out Box Main Cable (GEN025)
- Hi-Scan Pro End Of Life-Cycle Support (SST - 014) (KT2007073001)
- 1.8 Liter SEPHIA/Spectra Charging System (ENG017)
- Quick Connect Fuel Line Tool (FUE005)
- Automatic Transaxle Diagnosis For SEPHIA/Spectra/RIO (TRA008)
- SEPHIA/Spectra And RIO TCM Logic Revision (TRA007)
Towing
- Recreational Towing Requirements (GEN018REV1)
- Recreational Towing Requirements (General - 018) (KT2007091901)
Towing Systems
- Recreational Towing Requirements (GEN018REV1)
Transmission Control Systems
- KDS VCI-II Screws And/Or Case Replacement (SST056)
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- KIA Diagnostic System (KDS) Requirements (SST-035)
- DTC Scanning Techniques And Best Practices (GEN064)
- Everything You Ever Wanted To Know About Variant Coding But Were Afraid To Ask (KT2010031901-2)
- New SST Release And Return Of The Black Break Out Box Main Cable (GEN025)
- KIA Remanufactured Automatic Transmission Program (Trans/Driveline - 003, Revision 4) (TRA003 R4)
- Automatic Transaxle Diagnosis For SEPHIA/Spectra/RIO (TRA008)
- SEPHIA/Spectra And RIO TCM Logic Revision (TRA007)
Wheel Alignment
- 4-Wheel Alignment Equipment Recommendation (SST 031R1)
- PITSTOP: MDPS Steering Wheel Centering Adjustment Procedure During Alignment (PS192)
Wheel Hubs
- Wheel Hub Bearing Noise Diagnosis (PS631)
Wheels & Tire System
- Aftermarket Equipment Causing Can Codes And/Or Improper Operation (ELEPS399)
- 4-Wheel Alignment Equipment Recommendation (SST 031R1)
- Road Force Balancer With STRAIGHTTRAK Requirement (SST 030)
- TPMS Equipped Tire And Rim Assembly/Disassembly (Chassis - 014) (CHA014)
Window Motors & Regulators
- Proper Windshield Washer Concentrate Mixing (PS350)
Wiper/Washer Systems
- Windshield Washer Nozzle Cleaning And Adjustment (PS521)
- Windshield Wiper Blade / Element Maintenance (PS260)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- New KIA Wire Harness Repair Kit IV (GEN083)
- Replacement Wire Repair Connectors (GEN082)
- Introduction To "T" Connectors (ELE064)