Technical Service Bulletins

A/C Compressor
- Chirp Noise From FEAD Belt When A/C Compressor Is Engaging (05-17-8)
- Climate Control - A/C Service Tech Tips (02-20-8)
Accessories Control Systems
- Mil On With Pcm DTC P0463 And/Or Ic DTC B1201 - Fuel Gauge Drops To Empty Or Slow To Update After Refueling (06-2-12)
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- BACKGLASS Difficult To Close (05-13-6)
Accessory Drive Belts
- Chirp Noise From FEAD Belt When A/C Compressor Is Engaging (05-17-8)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Lock Brakes
- Abs Lamp And DTC C1235, C1236, C1237 - Vehicles With Differential-Mounted Rear Wheel Speed Sensor (03-26-3)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Inoperative Liftgate Latch Actuator With Fuse F2.16 Open (05-26-19)
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
Auxiliary Emission Control Systems
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Axle Shafts
- Unitized Seal Diagnosis - Leak / Grease Oil Separation - Axle Bearing Seal 8.8 Ifs, 8.8 IRS, And 9.75 IRS Axles (08-19-3)
- Noise From Rear Wheel Hub Bearings (05-25-8)
Body Electrical
- No Crank / Starter Terminal Fatigue (06-19-14)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- Mil On With Pcm DTC P0463 And/Or Ic DTC B1201 - Fuel Gauge Drops To Empty Or Slow To Update After Refueling (06-2-12)
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- BACKGLASS Difficult To Close (05-13-6)
Brakes Control Systems
- Abs Lamp And DTC C1235, C1236, C1237 - Vehicles With Differential-Mounted Rear Wheel Speed Sensor (03-26-3)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Collision/Avoidance
- False Parking Aid Warnings (99-4-10)
Cooling System (Mechanical)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Cooling System - MOTORCRAFT Premium Gold Engine Coolant - Service Tips (02-3-4)
Cruise Control Systems
- Speed Control Diagnostic Tips - Pcm (06-8-3)
Differentials & Drive Axles
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
- Unitized Seal Diagnosis - Leak / Grease Oil Separation - Axle Bearing Seal 8.8 Ifs, 8.8 IRS, And 9.75 IRS Axles (08-19-3)
- Noise From Rear Wheel Hub Bearings (05-25-8)
- Rear Axle Noise Repair (05-6-18)
- Driveline 1ST Order Vibration/Boom/Drone (05-3-7)
- Front Axle Tube Seal Leak (04-17-15)
Driveshaft & Universal Joints
- Driveline 1ST Order Vibration/Boom/Drone (05-3-7)
Engine Control Systems
- Engine Misfire With Diagnostic Trouble Code - DTC P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, And P0316 (06-5-13)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
Entertainment Systems
- Rattle Or Vibration From Rear Seat Entertainment System DVD Player - Dealer Installed Unit (04-24-1)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
- Rattle From Rear Seat Entertainment System (Res) DVD Player (04-17-3)
- Rattle From DVD Screen Latch Assembly (04-14-6)
- CDX6 Radio Damaged During Service Shipping - Correct Shipment Procedures (02-25-2)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Body - Liftgate Glass Applique Damaged/Cracked - Service Procedure (05-24-2)
Fuel System
- Adjustable Pedal - Adjustment Inoperative (11-10-11)
Fuses & Circuit Breakers
- No Crank / Starter Terminal Fatigue (06-19-14)
- Inoperative Liftgate Latch Actuator With Fuse F2.16 Open (05-26-19)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Gauges & Instrument Panels
- Mil On With Pcm DTC P0463 And/Or Ic DTC B1201 - Fuel Gauge Drops To Empty Or Slow To Update After Refueling (06-2-12)
- Overhead-Console Sunglass Bin Door Sticking Shut And Or Not Staying Closed (05-6-8)
Heated Glass/Defoggers
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- A/C Chemical Odor (05-9-22)
- Noise During A/C Operation From Rear Of Vehicle (04-24-6)
- Climate Control - A/C Service Tech Tips (02-20-8)
Ignition Switch/Steering Lock
- DRIVEABILITY - No-Crank - Service Tips (03-13-6)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
- Rear Window Defroster Grid/Integral Antenna Diagnosis And Repair - Terminal Tab Repair (04-24-5)
Interior/Exterior Trim
- Body - Liftgate Glass Applique Damaged/Cracked - Service Procedure (05-24-2)
- Overhead-Console Sunglass Bin Door Sticking Shut And Or Not Staying Closed (05-6-8)
Lubrication System
- Multiple Vehicle Lines - Revised Engine Oil Leak Diagnostic Procedure Using New White Fluorescent Dye (SSM 47550)
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
- Low Speed Steering Shudder (05-6-6)
Mechanical
- Multiple Vehicle Lines - Revised Engine Oil Leak Diagnostic Procedure Using New White Fluorescent Dye (SSM 47550)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
- Engine Misfire With Diagnostic Trouble Code - DTC P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, And P0316 (06-5-13)
- Chirp Noise From FEAD Belt When A/C Compressor Is Engaging (05-17-8)
- Engine Oil Level Indicator Markings - Reports Of Low Oil Level (03-8-3)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
Paint & Coatings
- Body - Paint - No CLEARCOAT Blending - Collision Manual Change (03-3-7)
- Approved Paint Materials For Warranty Repairs (02-16-7)
Passive Restraints
- Safety Belt Retraction Speed (05-16-11)
- Front Seat(S) Slight Movement When Accelerating And/Or Decelerating (05-4-16)
- Safety Belt Web Stop Button Service (05-3-10)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Safety Belt Retraction Speed (05-16-11)
- Front Seat(S) Slight Movement When Accelerating And/Or Decelerating (05-4-16)
- Safety Belt Web Stop Button Service (05-3-10)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- No Crank / Starter Terminal Fatigue (06-19-14)
- DRIVEABILITY - No-Crank - Service Tips (03-13-6)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
- Low Speed Steering Shudder (05-6-6)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
- Steering Gear Squeak When Turning The Steering Wheel During Low Speed Parking Maneuvers (06-5-16)
- Low Speed Steering Shudder (05-6-6)
Sun Roof/T-Top/Convertible Top
- Moonroof Squeak And/Or Rattle Noise - Corner Insert Repair (05-3-4)
- Rattle Or Vibration From Rear Seat Entertainment System DVD Player - Dealer Installed Unit (04-24-1)
Suspension Control Systems
- Low Tire Indicator On - TPMS System Sensor Wake Up (06-3-7)
System
- Adjustable Pedal - Adjustment Inoperative (11-10-11)
- No Crank / Starter Terminal Fatigue (06-19-14)
- Engine Misfire With Diagnostic Trouble Code - DTC P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, And P0316 (06-5-13)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
- MAF Diagnostic Service Tip - Vehicles Equipped With EGR System Module (ESM) (05-3-1)
- General Pcm Programming Procedures (04-24-14)
- Malfunction Indicator Lamp (Mil) Illuminated - System Lean Diagnostic Trouble Codes - DTC'S - Service Tips (04-17-4)
- DRIVEABILITY - No-Crank - Service Tips (03-13-6)
Towing
- Transmission - Neutral Tow Availability (02-25-8)
Transfer Case
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
Wheel Hubs
- Noise From Rear Wheel Hub Bearings (05-25-8)
Wheels & Tire System
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
- Low Tire Indicator On - TPMS System Sensor Wake Up (06-3-7)
- Noise From Rear Wheel Hub Bearings (05-25-8)
Window Motors & Regulators
- Rear Power Window Motor Inoperative/Stuck In The Up Position (07-20-5)
- Body - Liftgate Glass Applique Damaged/Cracked - Service Procedure (05-24-2)
- BACKGLASS Difficult To Close (05-13-6)
- Rear Power Window(S) Inoperative (05-1-5)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- No Crank / Starter Terminal Fatigue (06-19-14)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
- DRIVEABILITY - No-Crank - Service Tips (03-13-6)