Technical Service Bulletins

Accessories Control Systems
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
Accessory Drive Belts
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
Air Bag, SRS
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
Automatic Trans
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
- 5R55S - Transmission Fluid Leak (06-10-5)
Auxiliary Emission Control Systems
- 3.9L V8 Unusual Engine Noise - Spark Knock Ticking Noise Under Acceleration (06-23-17)
Body Electrical
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
Body Interior
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
Charging Systems
- Stuck High Voltage Charge Cord Information Sheet (G0000127)
Collision/Avoidance
- Parking Aid System Inoperative - DTC C1983 (06-25-13)
Cooling System (Mechanical)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Engine Control Systems
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L V8 Unusual Engine Noise - Spark Knock Ticking Noise Under Acceleration (06-23-17)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Entertainment Systems
- Audio / Navigation Service And Ordering Procedures (06-21-7)
Exhaust
- Various Vehicles - Catalytic Converter Concern Analysis (22-7009)
Exterior Body Panels
- Aluminum Panel Corrosion (17-0062)
Frames, Subframes & Crossmembers
- Aluminum Panel Corrosion (17-0062)
Fuel System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
Fuses & Circuit Breakers
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)
HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
Ignition System
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Infotainment
- Audio / Navigation Service And Ordering Procedures (06-21-7)
- "CANADA Only" - Map Zoom - Navigation System Will Not Zoom Closer Than A 16 Mile Scale (32 Km) (05-16-8)
Interior/Exterior Trim
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Manual Steering
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L Accessory Drive Belt Snap Noise In Freezing Temperatures (08-16-5)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Ford Interior Mirror Job Aid (G0000001)
Paint & Coatings
- Aluminum Panel Corrosion (17-0062)
- Interior Plastic Trim - Paint-To-Match And Repair - Interior Spray Paint And Adhesion Promoter Usage Instructions (05-9-3)
Passive Restraints
- Safety Belt Retraction Speed (05-16-11)
Restraints Control Systems
- RCM Fault Reporting Using DTCS And Bit-Mapped Parameter Identifiers (PIDS) - Service Tips (07-7-8)
Seats
- Safety Belt Retraction Speed (05-16-11)
Starter
- Battery Service - Operation Of Battery Eye - Charging Service Tips (07-5-8)
- Battery Drain Diagnosis - Service Tips (05-22-9)
Steering Column
- Leather-Wrapped Steering Wheel - Leather Coming Loose (07-4-3)
Steering Control Systems
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
Steering Gear
- MERCON(R) ATF Replaced By MERCON(R) V As A Service Fluid For Some Power Steering Systems (07-1-7)
System
- DTCS P0505, P0506 And/Or Engine Idle Rpm Fluctuation - Hard Start (12-8-1)
- 3.9L V8 Unusual Engine Noise - Spark Knock Ticking Noise Under Acceleration (06-23-17)
- WDS Cop Kit Diagnostic Tips - Coil On Plug (Cop) Ignition Systems - Engine Misfire Or Rough Running (05-22-8)
Transmission Control Systems
- 5R55S/5R55N/5R55W Transmissions - Shift Concerns, Loss Of 2ND, 3RD And 5TH Gear, Incorrect Ratio DTC'S - Procedure To Inspect And Repair Servo Pin Bore Wear (09-12-12)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Soldering And Crimping Repairs - Service Tips (05-18-7)