Technical Service Bulletins

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Correct FREON Charge Warning Specs (CAT. 16, NO. 034/88)
- A/C Caution Label Location (CAT. 16, NO. 017/87)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Anti-Theft Systems
- Wind Noise Around Doors (S018/98)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Key Replacement (CALIFORNIA Dealers Only) (CAT. AD, NO. 005/94)
- Door Interior Trim Odor: New Base Plate Resin (CAT. 14, NO. 042/87)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Automatic Trans
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- Automatic Transmission Repair Policy (CAT. K, NO. 002/95)
- Automatic Transmission Diagnostic Procedures (CAT. K, NO. 002/94)
- Auto Transaxle Oil Leak - Change Rod Boot Breather (CAT. 7, NO. 056/89)
- Improved Speedo Gear Sleeve To Eliminate Leaks (CAT. 7, NO. 027/87)
- ATX/MTX/Power Steering - Revised Lubricants (CAT. 7, NO. 023/86)
- Speedometer INOP - MISROUTED/Broken Speedo Cable (CAT. 14, NO. 027/86)
Auxiliary Emission Control Systems
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Emission Inspection & Maintenance Test Preparations (CAT. F, NO. 005/93)
- Remanufactured EGI Control Unit Program (CAT. F, NO. 010/91)
- 1.6L Eng No Start/Rough Idle - New Solenoid Resistor (CAT. 4, NO. 044/88)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- Fuel Injector Color Code Table (CAT. 4, NO. 033/87)
- 1.6/2.0L Eng Hard Start When Very Cold - REPL Relays (CAT. 15, NO. 038/87)
- 1.6L Eng Intermittent Misfire - Bad Ground (CAT. 1, NO. 006/86)
- Modified Main Relay & Engine Harness (CAT. 15, NO. 034/86)
Blowers, Superchargers & Turbochargers
- 1.6L Eng Low/DISHARGED Battery - Adjust/Replace Belt (CAT. 5, NO. 007/86)
Body Interior
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- A/C System Operation/Troubleshooting Procedures (CAT. 16, NO. 038/89)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Charging Systems
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- 1.6L Eng Low/DISHARGED Battery - Adjust/Replace Belt (CAT. 5, NO. 007/86)
Clutch
- 1.6L Eng Clutch Chatter - Revised Clutch Material (CAT. H, NO. 001/90)
- 1.6L Eng Revised Clutch Release Collar Parts (CAT. 6, NO. 004/86)
Communication Devices
- Installation Of Tire Chains (CAT. Q, NO. 005/93)
Cooling System (Mechanical)
- Propylene Glycol Based Coolant: Recommendations (CAT. E, NO. 001/94)
- Reconditioned Antifreeze Warnings (CAT. E, NO. 001/90)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- Filling Cooling System (CAT. 3, NO. 008/87)
- 1.6L Eng Exhaust Noise - Revised Muffler/Bracket (CAT. 1, NO. 024/87)
- 1.6L Eng REUCED Heater Performance - New Thermostat (CAT. 3, NO. 006/87)
- 1.6L Eng Runs Cold - Check Thermostat Installation (CAT. 3, NO. 004/86)
Electronic Steering
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Electronic Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Engine Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Remanufactured EGI Control Unit Program (CAT. F, NO. 010/91)
- 1.6L Eng No Start/Rough Idle - New Solenoid Resistor (CAT. 4, NO. 044/88)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- Fuel Injector Color Code Table (CAT. 4, NO. 033/87)
- 1.6/2.0L Eng Hard Start When Very Cold - REPL Relays (CAT. 15, NO. 038/87)
- 1.6L Eng Intermittent Misfire - Bad Ground (CAT. 1, NO. 006/86)
- Modified Main Relay & Engine Harness (CAT. 15, NO. 034/86)
Entertainment Systems
- Audio System Troubleshooting Procedures (CAT. 15, NO. 078/89)
Exhaust
- 1.6L Eng Exhaust Noise - New Muffler/Bracket (CAT. 1, NO. 046/89)
- Rattle From Floor When ACCEL - Broken Muffler Hanger (CAT. 4, NO. 055/89)
Exterior Body Panels
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Painting Rustproof Steel Panels (CAT. 14, NO. 070/89)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
Frames, Subframes & Crossmembers
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Painting Rustproof Steel Panels (CAT. 14, NO. 070/89)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
Front Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Rear Coil Spring Noise - New Spring Rubber Sheet (CAT. 13, NO. 014/88)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Fuel System
- Fuel Injector Cleaner (CAT. F, NO. 001/93)
- Recommended Fuel (CAT. 4, NO. 054/89)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- 1.6L Eng Poor Idle Stability Cold - REPL Air Valve (CAT. 4, NO. 021/86)
- 1.6L Eng Mislabeled Idle Adjusting Screw (CAT. 4, NO. 016/86)
Fuses & Circuit Breakers
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Front Wiper Motor Inoperative (MT 0394-15)
- Fusible Link Reference Chart (NO. T-2-3)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Gauges & Instrument Panels
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- 1.6/2.2L Eng. Oil Leak - New Pressure Switch (CAT. 2, NO. 004/88)
- Speedometer INOP - MISROUTED/Broken Speedo Cable (CAT. 14, NO. 027/86)
Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
HVAC Control Systems
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Receiver Drier Replacement Criteria (CANADIAN) (CAT. U, NO. 95-02)
- Receiver Drier Replacement Criteria - Information (CAT. U, NO. 001/95)
- Heating System Troubleshooting (CAT. U, NO. 93-04)
- A/C System Operation/Troubleshooting Procedures (CAT. 16, NO. 038/89)
- Correct FREON Charge Warning Specs (CAT. 16, NO. 034/88)
- Poor Cooling - Diagnosing/Repair A/C Leaks (CAT. 16, NO. 033/88)
- A/C Caution Label Location (CAT. 16, NO. 017/87)
- Over Torquing A/C Compressor Block Fittings Cautions (CAT. 16, NO. 013/86)
Identification
- A/C Caution Label Location (CAT. 16, NO. 017/87)
Ignition Switch/Steering Lock
- Key Replacement (CALIFORNIA Dealers Only) (CAT. AD, NO. 005/94)
Ignition System
- Spark Plug Cross-Reference Chart (NO. T-1-3)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
Interior/Exterior Trim
- Noise From Trunk Board (CANADIAN) - New Cushion (CAT S, NO. 95-19)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Damaged Full Wheel Covers - Improper Installation (CAT. Q, NO. 003/93)
- Torn Rear Door Weatherstrip: Weatherstrip Modified (CAT. 14, NO. 080/89)
- New Door Switch Protector (CAT. 14, NO. 028/86)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- High Mount Stop Light Modification: Protector Gasket (CAT. 14, NO. 034/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- High Mount Stop Light Modification: Protector Gasket (CAT. 14, NO. 034/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
Lubrication System
- Oil Filter Application Chart (NO. T-1-7)
- Installing MAZDA Brand Oil Filter (CAT. 2, NO. 005/89)
- 1.6L Eng Exhaust Noise - Revised Muffler/Bracket (CAT. 1, NO. 024/87)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Manual Trans
- Remanufactured Trans (CANADIAN) - Diagnosis Sheet (CAT. J, NO. 95-02)
- G-Type Trans Revised Shim Selector Tool (CAT. 40, NO. 024/87)
- Improved Speedo Gear Sleeve To Eliminate Leaks (CAT. 7, NO. 027/87)
- ATX/MTX/Power Steering - Revised Lubricants (CAT. 7, NO. 023/86)
- Speedometer INOP - MISROUTED/Broken Speedo Cable (CAT. 14, NO. 027/86)
- Manual Transaxle Revised Synchronizer Keys (CAT. 7, NO. 014/85)
Mechanical
- Partial Engine (Long Block) Availability (CAT. B, NO. 004/94)
- Engine Squeak At Idle - New Timing Belt Guide Plate (CAT. B, NO. 003/90)
- Engine Stand ADAPTOR Modifications (CAT. 40, NO. 025/88)
- 1.6L Eng Crankshaft Front End Damaged - New Bolt (CAT. 1, NO. 036/88)
- 1.6L Eng Seized Camshaft/Oil Failure - New PCV Valve (CAT. 1, NO. 035/88)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- 1.6L Eng Exhaust Noise - Revised Muffler/Bracket (CAT. 1, NO. 024/87)
- 1.6L Eng Timing Belt Squeak - Modified Timing Belt (CAT. 1, NO. 023/86)
- 1.6L Eng Modified Main Bearings (CAT. 1, NO. 022/86)
- Revised Timing Belt To Improve Reliability (CAT. 1, NO. 020/86)
- 2.0L Eng Revised Head Torque Information (CAT. 1, NO. 016/85)
Mechanical - Hydraulic
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Brake Judder Repair (CANADIAN) (CAT. P, NO. 95-02)
- Vibration/Pulsation While Braking - Procedure (CAT. P, NO. 006/94)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Memory Modules
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Mirrors
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Improper Operation Of Power Window Regulator (CAT. 15, NO. 071/88)
Paint & Coatings
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Water Soluble Transit Coating Removal Procedures (CAT. S, NO. 017/95)
- Painting Rustproof Steel Panels (CAT. 14, NO. 070/89)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Rear Coil Spring Noise - New Spring Rubber Sheet (CAT. 13, NO. 014/88)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Restraints Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Seats
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Availability Of Rear 3-Point Seat Belts (CAT. S, NO. 058/92)
- Installation Of Rear 3-Point Seat Belt (CAT. 14, NO. 073/89)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
- Improper Operation Of Power Window Regulator (CAT. 15, NO. 071/88)
- Aux. Shoulder Belt Anchor Point: Parts Availability (CAT. 14, NO. 044/87)
- Head Restraint Operation - Catch Release (CAT. 14, NO. 031/86)
Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Battery Tester Recommendation - New National Account (CAT. ST, NO. 003/95)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Warranty Bulletin - MAZDA Battery Warranty (CAT. G, NO. 1)
- Battery Recharging Procedure (MT 0994-10)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- 1.6L Eng Timing Belt Squeak - Modified Timing Belt (CAT. 1, NO. 023/86)
Steering Column
- Steering Wheel Slightly Off Center - Procedure (CAT. N, NO. 005/95)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Steering Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
Steering Linkage
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Suspension Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
System
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Emission Inspection & Maintenance Test Preparations (CAT. F, NO. 005/93)
- Spark Plug Cross-Reference Chart (NO. T-1-3)
- Remanufactured EGI Control Unit Program (CAT. F, NO. 010/91)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- Recommended Fuel (CAT. 4, NO. 054/89)
- 1.6L Eng No Start/Rough Idle - New Solenoid Resistor (CAT. 4, NO. 044/88)
- 2.0 L Eng No Start/Rough - Solenoid Resistor Open (CAT. 4, NO. 044/88)
- Fuel Injector Color Code Table (CAT. 4, NO. 033/87)
- 1.6/2.0L Eng Hard Start When Very Cold - REPL Relays (CAT. 15, NO. 038/87)
- 1.6L Eng Intermittent Misfire - Bad Ground (CAT. 1, NO. 006/86)
- 1.6L Eng Poor Idle Stability Cold - REPL Air Valve (CAT. 4, NO. 021/86)
- Modified Main Relay & Engine Harness (CAT. 15, NO. 034/86)
- 1.6L Eng Mislabeled Idle Adjusting Screw (CAT. 4, NO. 016/86)
Towing
- Vehicle Towing Precautions (CAT. AD, NO. 003/96)
Transmission Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Vacuum Pumps/Lines/Tanks/Water Trap
- 1.6L Eng Exhaust Noise - Revised Muffler/Bracket (CAT. 1, NO. 024/87)
- 1.6L Eng Timing Belt Squeak - Modified Timing Belt (CAT. 1, NO. 023/86)
Wheel Alignment
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Installation Of Tire Chains (CAT. Q, NO. 005/93)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Wind Noise Around Doors (S018/98)
- Windshield Stone Chipping Inspection (S037/96)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Torn Rear Door Weatherstrip: Weatherstrip Modified (CAT. 14, NO. 080/89)
- Improper Operation Of Power Window Regulator (CAT. 15, NO. 071/88)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Front Wiper Motor Inoperative (MT 0394-15)
- Poor Wiper Blade Performance (CAT. A, NO. 93-07)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)