Technical Service Bulletins
- A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- 2.0L Eng Poor A/C Performance - Evaporator Freeze-Up (CAT. 16, NO. 045/89)
- Correct FREON Charge Warning Specs (CAT. 16, NO. 034/88)
- A/C Caution Label Location (CAT. 16, NO. 017/87)
- Accessories & Equipment
- Accessories Control Systems
- Air Bag, SRS
- Anti-Theft Systems
- Wind Noise Around Doors (S018/98)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Key Replacement (CALIFORNIA Dealers Only) (CAT. AD, NO. 005/94)
- Hood Latch Recall Campaign (CAT. RC, NO. 93-09)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Automatic Trans
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- Automatic Transmission Repair Policy (CAT. K, NO. 002/95)
- Automatic Transmission Diagnostic Procedures (CAT. K, NO. 002/94)
- Workshop Manual Correction - Shocks, A/T, Air Bag (CAT. W, NO. 008/91)
- G4/FU06 Trans Manual Shaft Lock Nut Tightening TORQE (CAT. K, NO. 004/90)
- Auto Transaxle Oil Leak - Change Rod Boot Breather (CAT. 7, NO. 056/89)
- Improved Speedo Gear Sleeve To Eliminate Leaks (CAT. 7, NO. 027/87)
- Inaccurate Speedometer/Odometer - Replace Drive Gear (CAT. 7, NO. 019/86)
- F3A Trans Control Valve Body - Improved Shift (CAT. 7, NO. 018/86)
- Correct ATF Information (CAT. 7, NO. 013/85)
- Auxiliary Emission Control Systems
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Throttle Sensor Recall Campaign (CAT. RC, NO. 93-12)
- Emission Inspection & Maintenance Test Preparations (CAT. F, NO. 005/93)
- Remanufactured EGI Control Unit Program (CAT. F, NO. 010/91)
- 2.0L Eng Rough Idle After Cold Start - Cold Idle Kit (CAT. F, NO. 004/90)
- 2.0L Eng No Start - High Resistance No. 19 Connector (CAT. 5, NO. 014/88)
- 2.2L Eng Cold Start Rough Idle - Control Valve Kit (CAT. 4, NO. 043/88)
- Fuel Injector Color Code Table (CAT. 4, NO. 033/87)
- 2.0L Non Turbo Eng Rough Idle After Warm Restart (CAT. 4, NO. 023/87)
- 1.6/2.0L Eng Hard Start When Very Cold - REPL Relays (CAT. 15, NO. 038/87)
- 2.0L Eng Rough Idle After Warm Restart - New Ecu (CAT. 4, NO. 022/86)
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Propylene Glycol Based Coolant: Recommendations (CAT. E, NO. 001/94)
- Reconditioned Antifreeze Warnings (CAT. E, NO. 001/90)
- Filling Cooling System (CAT. 3, NO. 008/87)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- Electronic Steering
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Noise From Front Strut - Modified Spacer Bearing (CAT. R, NO. 006/91)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
- Steering Drift After Sharp Turn - New Thrust Bearing (CAT. 13, NO. 009/86)
- Electronic Suspension
- Engine Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Throttle Sensor Recall Campaign (CAT. RC, NO. 93-12)
- Remanufactured EGI Control Unit Program (CAT. F, NO. 010/91)
- 2.0L Eng Rough Idle After Cold Start - Cold Idle Kit (CAT. F, NO. 004/90)
- 2.0L Eng No Start - High Resistance No. 19 Connector (CAT. 5, NO. 014/88)
- 2.2L Eng Cold Start Rough Idle - Control Valve Kit (CAT. 4, NO. 043/88)
- Fuel Injector Color Code Table (CAT. 4, NO. 033/87)
- 2.0L Non Turbo Eng Rough Idle After Warm Restart (CAT. 4, NO. 023/87)
- 1.6/2.0L Eng Hard Start When Very Cold - REPL Relays (CAT. 15, NO. 038/87)
- 2.0L Eng Rough Idle After Warm Restart - New Ecu (CAT. 4, NO. 022/86)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Dome Light Flickers - Loose Bulb Holder Contacts (MT 0394-14)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Shift Indicator Light (SIL): Operation/Troubleshoot (CAT. 15, NO. 040/87)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- Modified Check Valve For Headlight Cleaner System (CAT. 14, NO. 037/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
- Frames, Subframes & Crossmembers
- Front Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Noise From Front Strut - Modified Spacer Bearing (CAT. R, NO. 006/91)
- Front Strut Noise - New Plastic Spacer Bearing (CAT. 13, NO. 012/87)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
- Steering Drift After Sharp Turn - New Thrust Bearing (CAT. 13, NO. 009/86)
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Dome Light Flickers - Loose Bulb Holder Contacts (MT 0394-14)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Shift Indicator Light (SIL): Operation/Troubleshoot (CAT. 15, NO. 040/87)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- Modified Check Valve For Headlight Cleaner System (CAT. 14, NO. 037/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
- HVAC Control Systems
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Receiver Drier Replacement Criteria (CANADIAN) (CAT. U, NO. 95-02)
- Receiver Drier Replacement Criteria - Information (CAT. U, NO. 001/95)
- Heating System Troubleshooting (CAT. U, NO. 93-04)
- Ignition Switch Recall Campaign (CAT. RC, NO. 93-18)
- A/C Pressure Relief Valve Information (CAT. U, NO. 007/90)
- 2.0L Eng Poor A/C Performance - Evaporator Freeze-Up (CAT. 16, NO. 045/89)
- Evaporator Freeze-Up: New Thermistor (CAT. 16, NO. 043/89)
- Correct FREON Charge Warning Specs (CAT. 16, NO. 034/88)
- Poor Cooling - Diagnosing/Repair A/C Leaks (CAT. 16, NO. 033/88)
- Inoperative Electrical Accessories - Ignition Switch (CAT. 15, NO. 055/87)
- 2.0L Eng INSUFFECIENT A/C Cooling - Control Cable (CAT. 16, NO. 022/87)
- A/C Caution Label Location (CAT. 16, NO. 017/87)
- A/C Discharge Hose Routing Precautions (CAT. 16, NO. 012/86)
- Over Torquing A/C Compressor Block Fittings Cautions (CAT. 16, NO. 013/86)
- Poor Heater Controller Operation - Revised Cable (CAT. 15, NO. 024/86)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Spark Plug Cross-Reference Chart (NO. T-1-3)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- Cold Idle Problems/Stall - New Air Valve (CAT. 4, NO. 067/89)
- 2.0L Eng Poor Idle,Stall After Start - New Air Valve (CAT. 4, NO. 020/86)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng Ignition Coil Cover Information (CAT. 6, NO. 005/85)
- Interior/Exterior Trim
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- High Mount Stop Light Modification: Protector Gasket (CAT. 14, NO. 034/86)
- Modified End Plate On Drip Moulding: Added Stopper (CAT. 14, NO. 026/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
- Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Dome Light Flickers - Loose Bulb Holder Contacts (MT 0394-14)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Shift Indicator Light (SIL): Operation/Troubleshoot (CAT. 15, NO. 040/87)
- High Mount Stop Light Protector Gasket Availability (CAT. 14, NO. 038/86)
- Modified Check Valve For Headlight Cleaner System (CAT. 14, NO. 037/86)
- High Mount Stop Light Modification: Protector Gasket (CAT. 14, NO. 034/86)
- Discolored High Mount Stop Light Gasket: New MAT'L (CAT. 15, NO. 020/86)
- Locking Hubs
- Lubrication System
- Oil Filter Application Chart (NO. T-1-7)
- Installing MAZDA Brand Oil Filter (CAT. 2, NO. 005/89)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- 2.0L Eng New Service Oil Filter Cartridge (CAT. 2, NO. 001/85)
- Manual Steering
- Manual Trans
- Remanufactured Trans (CANADIAN) - Diagnosis Sheet (CAT. J, NO. 95-02)
- G-Type Trans Revised Shim Selector Tool (CAT. 40, NO. 024/87)
- Improved Speedo Gear Sleeve To Eliminate Leaks (CAT. 7, NO. 027/87)
- Manual Trans Revised 5TH Gear Width (CAT. 7, NO. 025/86)
- Inaccurate Speedometer/Odometer - Replace Drive Gear (CAT. 7, NO. 019/86)
- Mechanical
- Partial Engine (Long Block) Availability (CAT. B, NO. 004/94)
- Cold Idle Problems/Stall - New Air Valve (CAT. 4, NO. 067/89)
- Engine Stand ADAPTOR Modifications (CAT. 40, NO. 025/88)
- 2.0/2.2L Eng Idle Rattle - Revised Main Bearing (CAT. 1, NO. 027/87)
- 2.0L Eng Poor Idle,Stall After Start - New Air Valve (CAT. 4, NO. 020/86)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Modified Rounded Tooth Timing Belt Info (CAT. 1, NO. 018/86)
- 2.0L Eng Revised Timing Belt & Relating Parts Info (CAT. 1, NO. 017/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- Mechanical - Hydraulic
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Brake Judder Repair (CANADIAN) (CAT. P, NO. 95-02)
- Vibration/Pulsation While Braking - Procedure (CAT. P, NO. 006/94)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
- Brake Noise In Reverse - Revised Brake Pads (CAT. 11, NO. 006/86)
- Rear Brake Rotors Rust Prevention Treatment (CAT. 11, NO. 005/86)
- Memory Modules
- Mirrors
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Power Window Motor Repair Kit Availability/Procedure (CAT. 15, NO. 067/88)
- Inoperative Electrical Accessories - Ignition Switch (CAT. 15, NO. 055/87)
- Paint & Coatings
- Passive Restraints
- Procedures
- Rear Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Noise From Front Strut - Modified Spacer Bearing (CAT. R, NO. 006/91)
- Front Strut Noise - New Plastic Spacer Bearing (CAT. 13, NO. 012/87)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
- Steering Drift After Sharp Turn - New Thrust Bearing (CAT. 13, NO. 009/86)
- Restraints Control Systems
- Seats
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Availability Of Rear 3-Point Seat Belts (CAT. S, NO. 058/92)
- Installation Of Rear 3-Point Seat Belt (CAT. 14, NO. 073/89)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
- Power Window Motor Repair Kit Availability/Procedure (CAT. 15, NO. 067/88)
- Inoperative Electrical Accessories - Ignition Switch (CAT. 15, NO. 055/87)
- Head Restraint Operation - Catch Release (CAT. 14, NO. 031/86)
- Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Battery Tester Recommendation - New National Account (CAT. ST, NO. 003/95)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Warranty Bulletin - MAZDA Battery Warranty (CAT. G, NO. 1)
- Battery Recharging Procedure (MT 0994-10)
- Cold Idle Problems/Stall - New Air Valve (CAT. 4, NO. 067/89)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- Steering Column
- Steering Wheel Slightly Off Center - Procedure (CAT. N, NO. 005/95)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Noise From Front Strut - Modified Spacer Bearing (CAT. R, NO. 006/91)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
- Steering Drift After Sharp Turn - New Thrust Bearing (CAT. 13, NO. 009/86)
- Steering Control Systems
- Steering Gear
- Steering Linkage
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Noise From Front Strut - Modified Spacer Bearing (CAT. R, NO. 006/91)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
- Steering Drift After Sharp Turn - New Thrust Bearing (CAT. 13, NO. 009/86)
- Suspension Control Systems
- System
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Throttle Sensor Recall Campaign (CAT. RC, NO. 93-12)
- Emission Inspection & Maintenance Test Preparations (CAT. F, NO. 005/93)
- Spark Plug Cross-Reference Chart (NO. T-1-3)
- Remanufactured EGI Control Unit Program (CAT. F, NO. 010/91)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- 2.0L Eng Rough Idle After Cold Start - Cold Idle Kit (CAT. F, NO. 004/90)
- Cold Idle Problems/Stall - New Air Valve (CAT. 4, NO. 067/89)
- Recommended Fuel (CAT. 4, NO. 054/89)
- 2.0L Eng No Start - High Resistance No. 19 Connector (CAT. 5, NO. 014/88)
- 2.2L Eng Cold Start Rough Idle - Control Valve Kit (CAT. 4, NO. 043/88)
- Fuel Injector Color Code Table (CAT. 4, NO. 033/87)
- 2.0L Non Turbo Eng Rough Idle After Warm Restart (CAT. 4, NO. 023/87)
- 1.6/2.0L Eng Hard Start When Very Cold - REPL Relays (CAT. 15, NO. 038/87)
- 2.0L Eng Rough Idle After Warm Restart - New Ecu (CAT. 4, NO. 022/86)
- 2.0L Eng Poor Idle,Stall After Start - New Air Valve (CAT. 4, NO. 020/86)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- 1.6L Eng Mislabeled Idle Adjusting Screw (CAT. 4, NO. 016/86)
- 2.0L Eng Ignition Coil Cover Information (CAT. 6, NO. 005/85)
- Towing
- Transmission Control Systems
- Wheel Alignment
- Wheels & Tire System
- Window Motors & Regulators
- Wind Noise Around Doors (S018/98)
- Windshield Stone Chipping Inspection (S037/96)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Power Window Motor Repair Kit Availability/Procedure (CAT. 15, NO. 067/88)
- Inoperative Electrical Accessories - Ignition Switch (CAT. 15, NO. 055/87)
- Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Front Wiper Motor Inoperative (MT 0394-15)
- Ignition Switch Recall Campaign (CAT. RC, NO. 93-18)
- Poor Wiper Blade Performance (CAT. A, NO. 93-07)
- Inoperative Electrical Accessories - Ignition Switch (CAT. 15, NO. 055/87)
- Modified Check Valve For Headlight Cleaner System (CAT. 14, NO. 037/86)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)