Technical Service Bulletins

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Special Service Tool Shipment - A/C Flushing Tool (CAT. ST, NO. 001/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Correct FREON Charge Warning Specs (CAT. 16, NO. 034/88)
- A/C Caution Label Location (CAT. 16, NO. 017/87)
- Compressor Clutch Inoperative Diagnostic Process (CAT. 16, NO. 004/85)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Anti-Theft Systems
- Wind Noise Around Doors (S018/98)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Key Replacement (CALIFORNIA Dealers Only) (CAT. AD, NO. 005/94)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Automatic Trans
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- Automatic Transmission Repair Policy (CAT. K, NO. 002/95)
- Automatic Transmission Diagnostic Procedures (CAT. K, NO. 002/94)
- Auto Transaxle Oil Leak - Change Rod Boot Breather (CAT. 7, NO. 056/89)
- Improved Speedo Gear Sleeve To Eliminate Leaks (CAT. 7, NO. 027/87)
Auxiliary Emission Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Emission Inspection & Maintenance Test Preparations (CAT. F, NO. 005/93)
- 2.0L Eng Poor DRIVEABILTY - New Emission Control Kit (CAT. 4, NO. 017/86)
- EGR Service Light Maintenance/Resetting Information (CAT. 15, NO. 023/86)
- 2.0L Eng Servo Diaphragm Modifications (CAT. 4, NO. 013/85)
- EGR Service Light Maintenance/Resetting Information (CAT. 50, NO. 001/85)
Axle Shafts
- Redesigned Propeller Shaft Center Bearing (CAT. 8, NO. 001/86)
- Revised Front Wheel Hub/Bolt/Mounting Torque Info (CAT. 9, NO. 003/86)
- Rear Axle Bearing Retainer - Conversion To Nut Info (CAT. 40, NO. 008/85)
- Rear Axle Bearing Puller Tool Modification (CAT. 40, NO. 006/85)
Body Interior
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Charging Systems
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
Communication Devices
- Installation Of Tire Chains (CAT. Q, NO. 005/93)
Cooling System (Mechanical)
- Propylene Glycol Based Coolant: Recommendations (CAT. E, NO. 001/94)
- Reconditioned Antifreeze Warnings (CAT. E, NO. 001/90)
- Filling Cooling System (CAT. 3, NO. 008/87)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- 2.0L Eng Discontinued Oil Filter Mounted Oil Cooler (CAT. 2, NO. 002/86)
- 1.5/2.0L Eng Overheats - Revised Thermostat (CAT. 3, NO. 003/85)
- 2.0L Eng Modified Head Gasket Information (CAT. 1, NO. 012/85)
- 2.0L Eng Modified Valve Cover Gasket Information (CAT. 1, NO. 013/85)
Differentials & Drive Axles
- Workshop Manual Correction - Differential (CAT. W, NO. 011/91)
- Redesigned Propeller Shaft Center Bearing (CAT. 8, NO. 001/86)
- New Service Differential ASEMBLY Replacement Info (CAT. 9, NO. 007/86)
- Rear Axle Bearing Retainer - Conversion To Nut Info (CAT. 40, NO. 008/85)
- Rear Axle Bearing Puller Tool Modification (CAT. 40, NO. 006/85)
Driveshaft & Universal Joints
- Redesigned Propeller Shaft Center Bearing (CAT. 8, NO. 001/86)
- Rear Axle Bearing Retainer - Conversion To Nut Info (CAT. 40, NO. 008/85)
Electronic Steering
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Electronic Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Engine Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- 2.0L Eng Poor DRIVEABILTY - New Emission Control Kit (CAT. 4, NO. 017/86)
- 2.0L Eng Servo Diaphragm Modifications (CAT. 4, NO. 013/85)
- EGR Service Light Maintenance/Resetting Information (CAT. 50, NO. 001/85)
Entertainment Systems
- Audio System Troubleshooting Procedures (CAT. 15, NO. 078/89)
Exhaust
- Rattle From Floor When ACCEL - Broken Muffler Hanger (CAT. 4, NO. 055/89)
Exterior Body Panels
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Painting Rustproof Steel Panels (CAT. 14, NO. 070/89)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Parking Light Stays On - Combo Switch Replacement (CAT. 15, NO. 011/85)
Frames, Subframes & Crossmembers
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Painting Rustproof Steel Panels (CAT. 14, NO. 070/89)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
- Lifting Locations (WORKSHOP MAN.,G-7,1986)
Front Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Fuel System
- Recommended Fuel (CAT. 4, NO. 054/89)
- A/C Throttle Opener Kit (CAT. 16, NO. 007/85)
Fuses & Circuit Breakers
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Front Wiper Motor Inoperative (MT 0394-15)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- No Crank No Dash Lights - Poor Contact At Main Fuse (CAT. 5, NO. 001/85)
Gauges & Instrument Panels
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- 1.6/2.2L Eng. Oil Leak - New Pressure Switch (CAT. 2, NO. 004/88)
- EGR Service Light Maintenance/Resetting Information (CAT. 15, NO. 023/86)
Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Parking Light Stays On - Combo Switch Replacement (CAT. 15, NO. 011/85)
Hoist/Jack
- Lifting Locations (WORKSHOP MAN.,G-7,1986)
HVAC Control Systems
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Special Service Tool Shipment - A/C Flushing Tool (CAT. ST, NO. 001/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- Receiver Drier Replacement Criteria (CANADIAN) (CAT. U, NO. 95-02)
- Receiver Drier Replacement Criteria - Information (CAT. U, NO. 001/95)
- Heating System Troubleshooting (CAT. U, NO. 93-04)
- A/C Odor - Replace Evaporator Core (CAT. U, NO. 015/92)
- A/C Pressure Relief Valve Information (CAT. U, NO. 007/90)
- Correct FREON Charge Warning Specs (CAT. 16, NO. 034/88)
- Poor Cooling - Diagnosing/Repair A/C Leaks (CAT. 16, NO. 033/88)
- Heater Control Lever INOP - New Control Install Info (CAT. 15, NO. 060/88)
- A/C Caution Label Location (CAT. 16, NO. 017/87)
- Over Torquing A/C Compressor Block Fittings Cautions (CAT. 16, NO. 013/86)
- Compressor Clutch Inoperative Diagnostic Process (CAT. 16, NO. 004/85)
Identification
- A/C Caution Label Location (CAT. 16, NO. 017/87)
Ignition Switch/Steering Lock
- Key Replacement (CALIFORNIA Dealers Only) (CAT. AD, NO. 005/94)
Ignition System
- Spark Plug Cross-Reference Chart (NO. T-1-3)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng Poor DRIVEABILTY - New Emission Control Kit (CAT. 4, NO. 017/86)
- 2.0L Eng Distributor Noise - Replace Dist Housing (CAT. 5, NO. 003/85)
- 2.0L Eng Ignition Coil Cover Information (CAT. 6, NO. 005/85)
Interior/Exterior Trim
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- New Door Switch Protector (CAT. 14, NO. 028/86)
- Door Wind Noise Highway Speeds - Modify Weatherstrip (CAT. 14, NO. 017/85)
Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
- Parking Light Stays On - Combo Switch Replacement (CAT. 15, NO. 011/85)
Lubrication System
- Oil Filter Application Chart (NO. T-1-7)
- Installing MAZDA Brand Oil Filter (CAT. 2, NO. 005/89)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- 2.0L Eng New Service Oil Filter Cartridge (CAT. 2, NO. 001/85)
- 2.0L Eng Modified Head Gasket Information (CAT. 1, NO. 012/85)
- 2.0L Eng Modified Valve Cover Gasket Information (CAT. 1, NO. 013/85)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Manual Trans
- Remanufactured Trans (CANADIAN) - Diagnosis Sheet (CAT. J, NO. 95-02)
- Manual Transmission Shim Adjustments (CAT. J, NO. 001/90)
- M & R Type Trans Hard Shift Cold - New Gear Oil (CAT. 7, NO. 062/89)
- 1.3/2.0/2.2L Eng Manual Trans - New Bearing/Seal (CAT. 7, NO. 042/88)
- Improved Speedo Gear Sleeve To Eliminate Leaks (CAT. 7, NO. 027/87)
- Revised Transmission Countershaft Bearing (CAT. 7, NO. 021/86)
- Manual Trans Modified Bearings (CAT. 7, NO. 011/85)
Mechanical
- Partial Engine (Long Block) Availability (CAT. B, NO. 004/94)
- Idle Vibration In Cab - New Eng Mount/Dynamic Damper (CAT. 1, NO. 048/89)
- Engine Stand ADAPTOR Modifications (CAT. 40, NO. 025/88)
- 2.0L Eng Oil Leak - New Head Seal Cap And Eng Hanger (CAT. 1, NO. 033/88)
- 2.0/2.2L Eng Idle Rattle - Revised Main Bearing (CAT. 1, NO. 027/87)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Modified Rounded Tooth Timing Belt Info (CAT. 1, NO. 018/86)
- 2.0L Eng Revised Timing Belt & Relating Parts Info (CAT. 1, NO. 017/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- 2.0L Eng Modified Head Gasket Information (CAT. 1, NO. 012/85)
- 2.0L Eng Modified Valve Cover Gasket Information (CAT. 1, NO. 013/85)
Mechanical - Hydraulic
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Brake Judder Repair (CANADIAN) (CAT. P, NO. 95-02)
- Vibration/Pulsation While Braking - Procedure (CAT. P, NO. 006/94)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
- Revised Front Wheel Hub/Bolt/Mounting Torque Info (CAT. 9, NO. 003/86)
Memory Modules
- Acceptable Battery Drain (CAT. 5, NO. 017/88)
Mirrors
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
Paint & Coatings
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Water Soluble Transit Coating Removal Procedures (CAT. S, NO. 017/95)
- Painting Rustproof Steel Panels (CAT. 14, NO. 070/89)
Parking Brake System
- Parking Brake Worn Cable Insulator Fix (MT 0595-02)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Restraints Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Seats
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Extra-Length Front Seat Belts Availability (CAT. 14, NO. 039/86)
- Static Electricity Shock When Exiting Vehicle (CAT. 14, NO. 067/89)
Starter
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Battery Tester Recommendation - New National Account (CAT. ST, NO. 003/95)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Warranty Bulletin - MAZDA Battery Warranty (CAT. G, NO. 1)
- Battery Recharging Procedure (MT 0994-10)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
Steering Column
- Steering Wheel Slightly Off Center - Procedure (CAT. N, NO. 005/95)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Steering Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
Steering Linkage
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Revised Front Wheel Hub/Bolt/Mounting Torque Info (CAT. 9, NO. 003/86)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Suspension Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
System
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Emission Inspection & Maintenance Test Preparations (CAT. F, NO. 005/93)
- Spark Plug Cross-Reference Chart (NO. T-1-3)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
- Recommended Fuel (CAT. 4, NO. 054/89)
- 2.0L Eng Revised Choke DIAPHRAM Installation Info (CAT. 4, NO. 019/86)
- 2.0L Eng New Timing Cover/Seals/Water Pump (CAT. 1, NO. 021/86)
- 2.0L Eng Coolant Leak - Revised Head Gasket Material (CAT. 1, NO. 019/86)
- 2.0L Eng Poor DRIVEABILTY - New Emission Control Kit (CAT. 4, NO. 017/86)
- EGR Service Light Maintenance/Resetting Information (CAT. 15, NO. 023/86)
- 2.0L Eng Distributor Noise - Replace Dist Housing (CAT. 5, NO. 003/85)
- 2.0L Eng Servo Diaphragm Modifications (CAT. 4, NO. 013/85)
- EGR Service Light Maintenance/Resetting Information (CAT. 50, NO. 001/85)
- A/C Throttle Opener Kit (CAT. 16, NO. 007/85)
- 2.0L Eng Modified Head Gasket Information (CAT. 1, NO. 012/85)
- 2.0L Eng Ignition Coil Cover Information (CAT. 6, NO. 005/85)
Towing
- Vehicle Towing Precautions (CAT. AD, NO. 003/96)
Transmission Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
Vacuum Pumps/Lines/Tanks/Water Trap
- 2.0L Eng Modified Valve Cover Gasket Information (CAT. 1, NO. 013/85)
Wheel Alignment
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
- Decimal Degree & Degree Minutes Alignment Spec Info (CAT. 30, NO. 001/86)
Wheel Hubs
- Revised Front Wheel Hub/Bolt/Mounting Torque Info (CAT. 9, NO. 003/86)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Installation Of Tire Chains (CAT. Q, NO. 005/93)
- Revised Front Wheel Hub/Bolt/Mounting Torque Info (CAT. 9, NO. 003/86)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Wind Noise Around Doors (S018/98)
- Windshield Stone Chipping Inspection (S037/96)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Door Wind Noise Highway Speeds - Modify Weatherstrip (CAT. 14, NO. 017/85)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Front Wiper Motor Inoperative (MT 0394-15)
- Poor Wiper Blade Performance (CAT. A, NO. 93-07)
- Improved Windshield Wiper Arm And Blade Design (CAT. 14, NO. 032/86)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Acceptable Battery Drain (CAT. 5, NO. 017/88)