Engine Controls - Basic Testing

• Introduction
• Preliminary Inspection & Adjustments
  • Visual Inspection
  • Mechanical Inspection
    • Compression
    • Exhaust System Backpressure
• Fuel System (CARBURETED)
  • Fuel Pressure
  • Fuel Pump (Electrical)
  • Fuel Pump (Mechanical)
• Fuel System (Fuel Injection)
  • Fuel Pressure
  • Fuel Pump Circuit (Except NAVAJO)
  • Fuel Pump Relay (NAVAJO)
  • Inertia Switch (NAVAJO)
  • Circuit Opening Relay (Except NAVAJO)
  • Resistor Relay (RX7)
  • Transfer Pump (Protege 4WD)
  • Transfer Pump Control Unit (Protege 4WD)
• Ignition Checks
  • Spark (Except NAVAJO & RX7)
  • Ignition Coil Power Source (Except NAVAJO & RX7)
  • Ignition Coil Resistance (Except NAVAJO & RX7)
  • Optical Distributor Voltage (MIATA, Protege & 323)
  • Distributor Pick-Up Coil Resistance (B2200, B2600I, MPV, MX-6 Non-Turbo & 626 Non-Turbo)
  • Crank Angle Sensor Resistance (MX-6 Turbo, 626 Turbo & 929)
  • IGNITOR (MIATA, Protege & 323)
  • IGNITOR (MX-6 Turbo, 626 Turbo & 929)
  • Initial Test (NAVAJO)
  • Check Profile Ignition Pickup (Pip) At EDIS Module (NAVAJO)
  • Isolate EDIS Module/Pip Fault (NAVAJO)
  • Check For VBAT To EDIS Module (NAVAJO)
  • Check For Ground Open To EDIS Module (NAVAJO)
  • Check VRS Resistance (NAVAJO)
  • VRS Sensor (NAVAJO)
  • Check VBAT Open To Coil (NAVAJO)
  • Verify Coil Operation (NAVAJO)
  • NAVAJO Check C1, C2 & C3 At Coil Pack (Cranking)
  • NAVAJO Check C1, C2 & C3 At Coil Pack (Running)
  • Checking Coil Pack (NAVAJO)
  • Checking EDIS Control NAVAJO
  • Spark (RX7)
  • Leading Side IGNITOR (RX7)
  • Leading Side Coil (RX7)
  • Trailing Side IGNITOR (RX7)
  • Trailing Side Coil (RX7)
  • Crank Angle Sensor (RX7)
• Idle Speed & Ignition Timing
• Throttle Position Sensor (TPS)
• Summary