Technical Service Bulletins

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- Air Conditioner Magnetic Clutch Service Kit (U003/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- A/C O-Ring REPALCEMENT (CAT. U, NO. 95-10)
- A/C O-Ring Replacement Part Numbers (CAT. U, NO. 009/95)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Air Bag, SRS
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Anti-Lock Brakes
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Wind Noise Around Doors (S018/98)
- Outer Door Handle Rattles/Loose (S019/96)
- Rear Door Window INOP - Rear Window Cable Protector (CAT. S, NO. 95-33)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Poor A/T Performance - Check Aftermarket Alarm (MT 05-04)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- After Market Alarm - Transmission Shifting Problems (MT 0195-07)
Automatic Trans
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Torque CONVERTOR Material Flaking - Repair Procedure (K001/96)
- A/T Oil Cooler Flushing Equipment Guideline (CAT. J, NO. 96-01)
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- Automatic Transmission Repair Policy (CAT. K, NO. 002/95)
- A/T Throttle Cable Adjustment (MT 05-06)
- A/T Fluid - Check Level At Every Service (MT 0195-13)
- Automatic Transmission Throttle Cable Adjustment (MT 0195-12)
- Automatic Transmission Diagnostic Procedures (CAT. K, NO. 002/94)
Auxiliary Emission Control Systems
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Incorrect CPU Number - Information (MT 0495-11)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Axle Shafts
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Charging Systems
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
Clutch
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Cooling System (Mechanical)
- Propylene Glycol Based Coolant: Recommendations (CAT. E, NO. 001/94)
Cruise Control Systems
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Differentials & Drive Axles
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Driveshaft & Universal Joints
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Electronic Steering
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Electronic Suspension
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Engine Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Incorrect CPU Number - Information (MT 0495-11)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Entertainment Systems
- Radio Unlocking Codes (MT-002/22)
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Exchange Cd Changer - Information (MT 0495-13)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Rear Door Window INOP - Rear Window Cable Protector (CAT. S, NO. 95-33)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- License Plate Installation (MT 1094-11)
Front Suspension
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Noise From Front And Rear Stabilizer Control Links (R003/96)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Fuel System
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Fuses & Circuit Breakers
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
HVAC Control Systems
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- A/C O-Ring REPALCEMENT (CAT. U, NO. 95-10)
- A/C O-Ring Replacement Part Numbers (CAT. U, NO. 009/95)
- Receiver Drier Replacement Criteria (CANADIAN) (CAT. U, NO. 95-02)
- Receiver Drier Replacement Criteria - Information (CAT. U, NO. 001/95)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
Interior/Exterior Trim
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Scratched Or Peeling B-Pillar Trim (S046/96)
- Outer Door Handle Rattles/Loose (S019/96)
- Scratched Or Peeling B-Pillar Trim (S002/96)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- Wind Noise - Poor Sealing Of Rear Door Weatherstrip (MT 1194-09)
Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
Lubrication System
- Winter Engine Oil Viscosity Chart (MT 0195-11)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Manual Trans
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Remanufactured Trans (CANADIAN) - Diagnosis Sheet (CAT. J, NO. 95-02)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Engine Noise: Carbon Accumulation (B005/96)
- Various Cases Of Engine Noise (CAT. B, NO. 93-05)
- HLA Noise After Long Storage (CANADIAN) (CAT. B, NO. 95-04)
- Hydraulic Lash Adjuster Noise After Long Storage (CAT. B, NO. 005/95)
Mechanical - Hydraulic
- Brake Drum/Rotor Resurfacing Machinery Selection (MT 0897-06)
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Brake Judder Repair (CANADIAN) (CAT. P, NO. 95-02)
- Vibration/Pulsation While Braking - Procedure (CAT. P, NO. 006/94)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Mirrors
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Rattling Noise From Sunroof (CAT. S, NO. 035/95)
- Rear Door Window Inoperative (CAT. S, NO. 033/95)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
- Scratched Or Peeling B-Pillar Trim (S046/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Water Soluble Transit Coating Removal Procedures (CAT. S, NO. 017/95)
- Transit Coating Removal Exceeding 90 Days (CANADIAN) (CAT. S, NO. 95-17)
- Transit Coating Removal - Damage Information (MT 0295-06)
- Paint Repair - Fading & Swirl/Wheel Marks (MT 0195-09)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- Paint Damage - Iron Particles / Industrial Fallout / Acid Rain (09-025/04)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Noise From Front And Rear Stabilizer Control Links (R003/96)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
Seats
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Rattling Noise From Sunroof (CAT. S, NO. 035/95)
- Rear Door Window Inoperative (CAT. S, NO. 033/95)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Battery Tester Recommendation - New National Account (CAT. ST, NO. 003/95)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Warranty Bulletin - MAZDA Battery Warranty (CAT. G, NO. 1)
Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/96)
- Steering Wheel Slightly Off Center (CANADIAN) (CAT. N, NO. 95-04)
- Steering Wheel Slightly Off Center - Procedure (CAT. N, NO. 005/95)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- NGS System Message - Data Link Error (MT 06-02)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
Steering Linkage
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Sun Roof/T-Top/Convertible Top
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Rear Door Window INOP - Rear Window Cable Protector (CAT. S, NO. 95-33)
Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
System
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Incorrect CPU Number - Information (MT 0495-11)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
Towing
- Vehicle Towing Precautions (CAT. AD, NO. 003/96)
Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- After Market Alarm - Transmission Shifting Problems (MT 0195-07)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Wheel Alignment
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Wheel Balance Tips For Higher Precision Results (MT 0897-08)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Lug Nut Tightening - Torque Wrench Caution (MT 1094-13)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Wind Noise Around Doors (S018/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- Windshield Stone Chipping Inspection (S037/96)
- Rattling Noise From Sunroof (CAT. S, NO. 035/95)
- Rear Door Window INOP - Rear Window Cable Protector (CAT. S, NO. 95-33)
- Rear Door Window Inoperative (CAT. S, NO. 033/95)
- Film Or Residue On Glass - Removal (MT 05-05)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Film/Residue On Glass - Polish Glass With Compound (MT 0195-10)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Wind Noise - Poor Sealing Of Rear Door Weatherstrip (MT 1194-09)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Windshield Washer Level Sensor Connector Deleted (CAT. T, NO. 013/95)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)