Technical Service Bulletins

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- A/C O-Ring REPALCEMENT (CAT. U, NO. 95-10)
- A/C O-Ring Replacement Part Numbers (CAT. U, NO. 009/95)
- Expansion Valve WHISTTLING Noise - Replace Valve (CAT. U, NO. 95-08)
- Insufficient Cooling - A/C Relay Failure (CANADIAN) (CAT. U, NO. 95-07)
- INSUFFICENT Cooling - A/C Relay Failure (CAT. U, NO. 007/95)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- NGS System Message - Data Link Error (MT 06-02)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Accessory Drive Belts
- Expansion Valve WHISTTLING Noise - Replace Valve (CAT. U, NO. 95-08)
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
Air Bag, SRS
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Air Bag Warning Light Troubleshooting (T014/96)
- 1995 Air Bag Not Interchangeable W/Previous Designs (MT 1194-07)
Anti-Lock Brakes
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Keyless Entry Inoperative\Intermittent - Battery (MT 1197-11)
- Power Door Lock Knob Malfunction (T022/96)
- Outer Door Handle Rattles/Loose (S019/96)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- CPU Troubleshooting Procedures (T007/96)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Poor A/T Performance - Check Aftermarket Alarm (MT 05-04)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- After Market Alarm - Transmission Shifting Problems (MT 0195-07)
Automatic Trans
- Oil Leak From Breather - Automatic Transmission (K006/97)
- La4A El Auto Trans Leaking Fluid From Filler (MT 0697-03)
- Torque Converter Clutch System Performance - DTC 628 (K003/97)
- Turbine Speed Sensor Replacement (K007/96)
- La4A-El Transaxle Leak At Torque Converter Hub Seal (K006/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- La4A-El Transmission Whistle Noise At Idle (K003/96)
- Transmission Oil Leak From Breather (CAT. K, NO. 005/96)
- O/D "Off" Light La4A-El Transmission (MT 0596-09)
- A/T Oil Cooler Flushing Equipment Guideline (CAT. J, NO. 96-01)
- La4A-El Transaxle Fluid Leak At Converter Hub Seal (CAT. K, NO. 006/95)
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- Broken "Hold" Or "O/D" Switch Wire (CAT. K, NO. 003/95)
- La4A-El ATX Forward Clutch Circuit Filter Service (CAT. K, NO. 004/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- La4A-El ATX Forward Clutch Filter Service (CAT. K, NO. 95-04)
- Automatic Transmission Repair Policy (CAT. K, NO. 002/95)
- A/T Throttle Cable Adjustment (MT 05-06)
- Shift Lever Will Not Move From Park (CANADIAN) (CAT. J, NO. 95-03)
- A/T Fluid - Check Level At Every Service (MT 0195-13)
- Automatic Transmission Throttle Cable Adjustment (MT 0195-12)
- Automatic Transmission Diagnostic Procedures (CAT. K, NO. 002/94)
Auxiliary Emission Control Systems
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- PCV SYS. Modification At Partial Engine Replacement (CAT. B, NO. 004/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Diagnostic For Mass Air Flow Sensor - DTC P0171/181 (F002/97)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- Harsh Shifts - TCC/Transaxle Replacement (MT 1196-03)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Fuel Vapor Valve - Correct Installation (MT 0596-01)
- Rough Idle Or Miss - Idle Air Control Valve Service (F012/96)
- CPU Troubleshooting Procedures (T007/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Hard Start With Cold Engine, Mil Light On (CANADIAN) (CAT. F, NO. 95-02)
- O2 Light On & Hard Start When Cold - Timer Kit (CAT. F, NO. 003/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
Axle Shafts
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Blowers, Superchargers & Turbochargers
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
Body Electrical
- Electrical Connector And Terminal Replacement Part Availability (T004/97)
Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Changed Fuel Pump & Sender Assemblies (CAT. RF, NO. 95-27)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Erratic Climate Control Variations - LOGICON Fault (MT 0995-01)
- NGS System Message - Data Link Error (MT 06-02)
- Insufficient Cooling - A/C Relay Failure (CANADIAN) (CAT. U, NO. 95-07)
- INSUFFICENT Cooling - A/C Relay Failure (CAT. U, NO. 007/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Charging Systems
- Electrical Connector And Terminal Replacement Part Availability (T004/97)
- 2.0L Eng Revised Alternator Adjustment Bracket (MT 1197-07)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
Clutch
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Communication Devices
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
Cooling Fan
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
Cooling System (Mechanical)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 010/95)
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
- Propylene Glycol Based Coolant: Recommendations (CAT. E, NO. 001/94)
Cruise Control Systems
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Differentials & Drive Axles
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Driveshaft & Universal Joints
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Electronic Steering
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Electronic Suspension
- Rattle From Front Of Vehicle - Front Stabilizer Nuts (MT 1196-04)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Engine Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DRIVEABILITY Concern/Carbon Buildup In Throttle Body (MT 0897-11)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Diagnostic For Mass Air Flow Sensor - DTC P0171/181 (F002/97)
- Harsh Shifts - TCC/Transaxle Replacement (MT 1196-03)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Rough Idle Or Miss - Idle Air Control Valve Service (F012/96)
- CPU Troubleshooting Procedures (T007/96)
- Fuel Pump And Sender Non-Interchangeability (F004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Hard Start With Cold Engine, Mil Light On (CANADIAN) (CAT. F, NO. 95-02)
- O2 Light On & Hard Start When Cold - Timer Kit (CAT. F, NO. 003/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
Entertainment Systems
- Radio Unlocking Codes (MT-002/22)
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Cigarette Lighter Replacement (S018/97)
- Speaker Self Diagnostics Feature (MT 0697-04)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- MAZDA Cd Player Back Lighting Does Not Illuminate (T010/96)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Antenna Mast - Proper Length For Application (MT 07-03)
- Radio INOP - Power Reset Procedure (MT 06-11)
- Exchange Cd Changer - Information (MT 0495-13)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Warranty Bulletin - Audio Units (CAT. AD, NO. 11)
- Ford/MAZDA/SANYO (FMS) Radio - Reset Radio (MT 0994-08)
Exhaust
- Rattle Noise From Pre-Muffler - Modify Exhaust Mount (CAT. S, NO. 019/95)
- Rattle Noise From Pre-Muffler Bracket (CANADIAN) (CAT. S, NO. 95-21)
Exterior Body Panels
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Trunk Water Leak - Seam Sealer Inspection (MT 0397-09)
- Creak / Rattle Noise From Passenger Side Wiper (S006/96)
- Fuel Pump And Sender Non-Interchangeability (CAT.F, NO. 004/96)
- Fuel Pump And Sender Non-Interchangeability (F004/96)
- Price Reduction On MX-6 Rear Spoiler (CAT. RF, NO. 95-25)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Windshield Wiper - Rattle Or Creak Noise At Cowl (MT 07-01)
- Water Leak In The Trunk - Tighten BUNPER Bolts (MT 0195-03)
Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Headlight Switch Replacement (MT 0595-06)
- High Mount Stop Lamp Service Procedure (CANADIAN) (CAT. T, NO. 95-03)
- High Mount Stop Lamp(Rear Spoiler) Service Procedure (CAT. T, NO. 002/95)
- Dome Lamp Flickers/Inoperative - Repair Procedure (MT 1294-05)
Frames, Subframes & Crossmembers
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Creak / Rattle Noise From Passenger Side Wiper (S006/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Creak/Rattle Noise From PASSSENGER Wiper (CAT. S, NO. 95-28)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Windshield Wiper - Rattle Or Creak Noise At Cowl (MT 07-01)
- Windshield Wiper Rattle Noise - Install Bolts/Nuts (MT 0695-01)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
- Water Leak In The Trunk - Tighten BUNPER Bolts (MT 0195-03)
- License Plate Installation (MT 1094-11)
Front Suspension
- Stabilizer Bar Bushing Replacement Procedure (R001/97)
- Rattle From Front Of Vehicle - Front Stabilizer Nuts (MT 1196-04)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Rear Damper Inspection/Replacement Information (MT 1295-04)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Noise From Front And Rear Stabilizer Control Links (R003/96)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Fuel System
- DRIVEABILITY Concern/Carbon Buildup In Throttle Body (MT 0897-11)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- Diagnostic For Mass Air Flow Sensor - DTC P0171/181 (F002/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Rough Idle Or Miss - Idle Air Control Valve Service (F012/96)
- Fuel Pump And Sender Non-Interchangeability (CAT.F, NO. 004/96)
- Fuel Pump And Sender Non-Interchangeability (F004/96)
Fuses & Circuit Breakers
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Cigarette Lighter Replacement (S018/97)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement (T005/96)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Headlight Switch Replacement (MT 0595-06)
- Spark Plug Wire V-6 Applications - Correct Part No. (MT 0595-07)
- Dome Lamp Flickers/Inoperative - Repair Procedure (MT 1294-05)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Squeak/Rattle From Dash Defroster Area (MT 0597-03)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- CPU Troubleshooting Procedures (T007/96)
- Fuel Pump And Sender Non-Interchangeability (F004/96)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
- Low Washer Fluid Light - Production Change (MT 0195-02)
- Fuel Gauge Reads 3/4 With Full Tank: Adjust (CAT. T, NO. 012/95)
Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Headlight Switch Replacement (MT 0595-06)
- High Mount Stop Lamp Service Procedure (CANADIAN) (CAT. T, NO. 95-03)
- High Mount Stop Lamp(Rear Spoiler) Service Procedure (CAT. T, NO. 002/95)
- Dome Lamp Flickers/Inoperative - Repair Procedure (MT 1294-05)
HVAC Control Systems
- Noise From Blower Motor Due To Foreign Substance (U013/97)
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- Intermittent A/C Operation (U006/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
- A/C Compressor Noise Replacement Criteria (CAT. U, NO. 012/95)
- A/C O-Ring REPALCEMENT (CAT. U, NO. 95-10)
- A/C O-Ring Replacement Part Numbers (CAT. U, NO. 009/95)
- Expansion Valve WHISTTLING Noise - Replace Valve (CAT. U, NO. 95-08)
- A/C Evaporator Hose May Fall Off - Reconnect (MT 08-12)
- Manual Update - Defroster Operation (MT 05-01)
- Insufficient Cooling - A/C Relay Failure (CANADIAN) (CAT. U, NO. 95-07)
- INSUFFICENT Cooling - A/C Relay Failure (CAT. U, NO. 007/95)
- Expansion Valve Whistling Noise (CANADIAN) (CAT. U, NO. 95-06)
- Expansion Valve Whistling Noise: New Expansion Valve (CAT. U, NO. 004/95)
- Receiver Drier Replacement Criteria (CANADIAN) (CAT. U, NO. 95-02)
- Receiver Drier Replacement Criteria - Information (CAT. U, NO. 001/95)
- Owners Manual Correction - Defroster Operation (MT 0195-01)
- A/C Evaporator Drain Hose - Leaks (MT 1094-06)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Throttle Body Service Procedure For Carbon Removal (F022/96)
- Spark Plug Wire V-6 Applications - Correct Part No. (MT 0595-07)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
Infotainment
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
Interior/Exterior Trim
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Squeak/Rattle From Dash Defroster Area (MT 0597-03)
- Front Console Service Parts (S054/96)
- Outer Door Handle Rattles/Loose (S019/96)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
- Water Leak In Trunk - Tighten Bumper Screws (MT 05-02)
- Door Trim Recess Broken -Recess Available Separately (MT 0395-03)
- High Mount Stop Lamp(Rear Spoiler) Service Procedure (CAT. T, NO. 002/95)
Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Modified Interior Dome Light Bulb Application (MT 0897-05)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Headlight Switch Replacement (MT 0595-06)
- High Mount Stop Lamp Service Procedure (CANADIAN) (CAT. T, NO. 95-03)
- High Mount Stop Lamp(Rear Spoiler) Service Procedure (CAT. T, NO. 002/95)
- Dome Lamp Flickers/Inoperative - Repair Procedure (MT 1294-05)
Locking Hubs
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
Lubrication System
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Winter Engine Oil Viscosity Chart (MT 0195-11)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Rear Damper Inspection/Replacement Information (MT 1295-04)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Manual Trans
- MTX Overhaul Information - Reverse Gate Spring Care (J003/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Remanufactured Trans (CANADIAN) - Diagnosis Sheet (CAT. J, NO. 95-02)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Piston Standardization Left & Right Bank REPLACEMANT (CAT. 01, NO. 015/99)
- Camshaft Friction Gear Noise - Modified REPL Process (B005/98)
- 2.0L Eng Revised Alternator Adjustment Bracket (MT 1197-07)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Tapping Noise When Engine Is Cold (B001/97)
- Rough Idle And/Or Engine Stall After Cold Start (D002/96)
- Throttle Body Service Procedure For Carbon Removal (F022/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Vibration Noise While Turning Right And Accelerating (M003/96)
- Cylinder Head Bolt Change V-6 Engine Only (B002/96)
- Intake Manifold Assembly Modification To OBDII Specs (F011/96)
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 010/95)
- Rattle Noise From Pre-Muffler - Modify Exhaust Mount (CAT. S, NO. 019/95)
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
- Camshaft Friction Gear Noise (CANADIAN) (CAT. B, NO. 95-05)
- Clicking Noise From Camshaft Friction Gear - Repair (MT 0495-10)
- HLA Noise After Long Storage (CANADIAN) (CAT. B, NO. 95-04)
- Hydraulic Lash Adjuster Noise After Long Storage (CAT. B, NO. 005/95)
- Knock Sensor Cover Eliminated (MT 06-05)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
Mechanical - Hydraulic
- Brake Drum/Rotor Resurfacing Machinery Selection (MT 0897-06)
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Brake Judder Repair (CANADIAN) (CAT. P, NO. 95-02)
- Vibration/Pulsation While Braking - Procedure (CAT. P, NO. 006/94)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Memory Modules
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
Mirrors
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Power Door Lock Knob Malfunction (T022/96)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
Overdrive Unit
- Turbine Speed Sensor Replacement (K007/96)
- O/D "Off" Light La4A-El Transmission (MT 0596-09)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Paint Cracking On Horizontal Surfaces (S023/97)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
- Trunk Water Leak - Seam Sealer Inspection (MT 0397-09)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Water Soluble Transit Coating Removal Procedures (CAT. S, NO. 017/95)
- Transit Coating Removal Exceeding 90 Days (CANADIAN) (CAT. S, NO. 95-17)
- Transit Coating Removal - Damage Information (MT 0295-06)
- Paint Repair - Fading & Swirl/Wheel Marks (MT 0195-09)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
Passive Restraints
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- Stabilizer Bar Bushing Replacement Procedure (R001/97)
- Rattle From Front Of Vehicle - Front Stabilizer Nuts (MT 1196-04)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Rear Damper Inspection/Replacement Information (MT 1295-04)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Noise From Front And Rear Stabilizer Control Links (R003/96)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- NGS System Message - Data Link Error (MT 06-02)
Seats
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Seat Belt Extender Description/Ordering Info (CAT. S, NO. 032/96)
- Power Door Lock Knob Malfunction (T022/96)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Clicking Or Popping Noise From Front Seat (S024/96)
- Glove Box Lid Squeak During Operation - Cold Weather (CAT. S, NO. 032/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Battery Tester Recommendation - New National Account (CAT. ST, NO. 003/95)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
- Warranty Bulletin - MAZDA Battery Warranty (CAT. G, NO. 1)
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
- Camshaft Friction Gear Noise (CANADIAN) (CAT. B, NO. 95-05)
- Clicking Noise From Camshaft Friction Gear - Repair (MT 0495-10)
Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/96)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
- Steering Wheel Slightly Off Center (CANADIAN) (CAT. N, NO. 95-04)
- Steering Wheel Slightly Off Center - Procedure (CAT. N, NO. 005/95)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- NGS System Message - Data Link Error (MT 06-02)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- Rear Damper Inspection/Replacement Information (MT 1295-04)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
Steering Linkage
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Front Strut Squeaks On Turns - Strut Interference (R001/96)
- Front Struts - Squeak Or Squeal (MT 08-06)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Sun Roof/T-Top/Convertible Top
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Rattle Noise From Sunroof (MT 0697-02)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Sunroof Rattle When Closed (S010/96)
- Glove Box Lid Squeak During Operation - Cold Weather (CAT. S, NO. 032/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Rattle From Front Of Vehicle - Front Stabilizer Nuts (MT 1196-04)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
System
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DRIVEABILITY Concern/Carbon Buildup In Throttle Body (MT 0897-11)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- PCV SYS. Modification At Partial Engine Replacement (CAT. B, NO. 004/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Diagnostic For Mass Air Flow Sensor - DTC P0171/181 (F002/97)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- Harsh Shifts - TCC/Transaxle Replacement (MT 1196-03)
- Rough Idle And/Or Engine Stall After Cold Start (D002/96)
- Throttle Body Service Procedure For Carbon Removal (F022/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Fuel Vapor Valve - Correct Installation (MT 0596-01)
- Rough Idle Or Miss - Idle Air Control Valve Service (F012/96)
- CPU Troubleshooting Procedures (T007/96)
- Fuel Pump And Sender Non-Interchangeability (F004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- Spark Plug Wire V-6 Applications - Correct Part No. (MT 0595-07)
- Hard Start With Cold Engine, Mil Light On (CANADIAN) (CAT. F, NO. 95-02)
- O2 Light On & Hard Start When Cold - Timer Kit (CAT. F, NO. 003/95)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
- Knock Sensor Cover - Eliminated In Production (MT 0794-04)
- Parts Bulletin - Spark Plug Coil/Wire Set (NO. T-1-6)
Towing
- Vehicle Towing Precautions (CAT. AD, NO. 003/96)
Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Torque Converter Clutch System Performance - DTC 628 (K003/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- Broken "Hold" Or "O/D" Switch Wire (CAT. K, NO. 003/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- NGS System Message - Data Link Error (MT 06-02)
- Shift Lever Will Not Move From Park-Faulty Actuator (CAT. K, NO. 001/95)
- After Market Alarm - Transmission Shifting Problems (MT 0195-07)
- Shipment Of NGS Program Card Version 2.0:Information (CAT. ST, NO. 002/94)
Vacuum Pumps/Lines/Tanks/Water Trap
- Idle Vibration Due To Mis-Positioned Dampers (CAT. B, NO. 95-08)
- Camshaft Friction Gear Noise (CANADIAN) (CAT. B, NO. 95-05)
- Clicking Noise From Camshaft Friction Gear - Repair (MT 0495-10)
Warning Systems
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
Wheel Alignment
- Alignment Specifications And Tolerances -Information (CAT. N, NO. 004/94)
- Alignment Specifications (CANADIAN) (CAT. N, NO. 95-02)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Wheel Balance Tips For Higher Precision Results (MT 0897-08)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Upper Spring Seat/Dust Cover & Rubber Stop Lubricant (MT 1295-05)
- Lug Nut Tightening - Torque Wrench Caution (MT 1094-13)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- Power Door Lock Knob Malfunction (T022/96)
- Windshield Stone Chipping Inspection (S037/96)
- Creak / Rattle Noise From Passenger Side Wiper (S006/96)
- Glove Box Lid Squeak During Operation - Cold Weather (CAT. S, NO. 032/95)
- Glove Box Lid Squeaks/Cold Weather - Lube Hinge Pin (CAT. S, NO. 95-32)
- Film Or Residue On Glass - Removal (MT 05-05)
- Water Leak In Trunk - Tighten Bumper Screws (MT 05-02)
- Power Antenna Mast Replacement (CANADIAN) (CAT. T, NO. 95-06)
- Power Antenna Mast Replacement (CAT. T, NO. 005/95)
- Film/Residue On Glass - Polish Glass With Compound (MT 0195-10)
- Power Antenna Mast - Repair Procedure (MT 0195-08)
- Front Windshield Cracks - Improper Installation (MT 1194-08)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Creak / Rattle Noise From Passenger Side Wiper (S006/96)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Creak/Rattle Noise From PASSSENGER Wiper (CAT. S, NO. 95-28)
- Creak/Rattle Noise From Passenger Side Wiper (CAT. S, NO. 028/95)
- Windshield Wiper - Rattle Or Creak Noise At Cowl (MT 07-01)
- Windshield Wiper Rattle Noise - Install Bolts/Nuts (MT 0695-01)
- Low Washer Fluid Light - Production Change (MT 0195-02)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Power Sunroof SILDE Or Tilt Inoperative (S033/96)
- CPU/Fuse Block/Connector Diagnostic/Troubleshooting (MT 1395-01)
- Headlight Switch Replacement Parts Information (MT 1295-10)
- Headlight Switch Replacement (T005/96)
- Broken "Hold" Or "O/D" Switch Wire (CAT. K, NO. 003/95)
- Broken Hold Or Overdrive Switch Wire (CAT. J, NO. 95-05)
- Erratic Climate Control Variations - LOGICON Fault (MT 0995-01)
- Headlight Switch Replacement (MT 0595-06)
- Spark Plug Wire V-6 Applications - Correct Part No. (MT 0595-07)
- Dome Lamp Flickers/Inoperative - Repair Procedure (MT 1294-05)