Technical Service Bulletins

A/C Compressor
- Precaution Against Unnecessary A/C Compressor Parts Replacement (07-003/09)
- Belt Squeal After Driving Through Water (7416)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
Accessories & Equipment
- Special Tool Shipment - August 2009 (ST-003/09)
- Special Tool Shipment - February 2009 (ST-001/09)
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- Special Tool Shipment - February 2006 (ST-001/06)
- Special Service Tool Shipment - October 2005 (ST-002/05)
- WDS PTU Battery Warranty And Order Information (ST-001/05)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- Special Tool Shipment March 2004 (SST) (ST-001/04)
- Special Tool Shipment December 2003 (SST) (ST 004/03)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Display Shows Inaccurate Ambient Temperature (09-023/14)
- Precautions For Module Reprogramming (01-030/08)
- Information Display Shows Bars (09-036/04)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
Accessory Drive Belts
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Belt Squeal After Driving Through Water (7416)
Aerodynamic Devices
- Engine Undercover Removal Caution (09-012/07)
Air Bag, SRS
- Standard Deployment/Two-Step Deployment For Air Bag System (MT-003/18)
- Airbag Warning Light Comes On With Code B1877/B1881 (08-001/07)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Anti-Theft Systems
- Keyless Entry Remote Transmitter (Key Fob) Battery Replacement Caution (09-041/10)
- Driver Door Lock Inoperative / Room Light Stays On (09-037/04)
- Key Reminder Chime Keeps Chiming Or Keyless Entry Inoperative (09-032/06)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
- Security Access Procedure Change For Coded Access Pats And Advanced Keyless System - Service Tip (09-003/06)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Correct Application For ATF M-V (Type M5), MERCON®V, MERCON®LV, And JWS3309 (T-IV) Automatic Transmission Fluids (05-005/08)
- Engine Will Not Start In P-Range Intermittently (05-002/12)
- Automatic Transmission Diagnostic Procedure (05-004/11)
- Diagnosis And Repair Procedure For ATF Seepage (05-011/10)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Engine Will Not Start In P-Range Intermittently (05-012/08)
- Transaxle Range Switch Removal / Installation Caution (05-011/07)
Auxiliary Emission Control Systems
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Loose Fuel Filler Cap With DTC P0442, P0455, And P0456 (01-020/10)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- Mil Illumination, P0456 (01-039/04)
Axle Shafts
- Clunk Noise From Drive Shaft (03-002/10)
- Special Service Tool Shipment - June 2007 (ST-004/07)
Body Electrical
- Mil Illumination - P0172 / P2178 / P2188 Set (01-006/06)
Body Interior
- As-Built Data Search On Ms3 (00-001/10)
Brakes Control Systems
- As-Built Data Search On Ms3 (00-001/10)
- Precautions For Module Reprogramming (01-030/08)
- Abs Warning Light On With DTC C1141, C1142, C1233, Or C1234/Grinding Noise From Front Wheels (04-001/07)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Belt Squeal After Driving Through Water (7416)
- Drive Belt TENSIONER Pulley Breakage / Charging Warning Light On / Overheating (01-003/05)
Cooling System (Mechanical)
- Water Pump Coolant Leak (01-022/19)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Mil Illumination With DTC P0128 (01-041/07)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
- Mil Illumination With DTC P0128 (01-008/04)
- Splashing Sound From Inside Dash During Cold Start (09-017/04)
Cruise Control Systems
- 2.0L Mt - Fed / Can Only - Cruise Surge (01-008/06)
Driveshaft & Universal Joints
- Drive Shaft Click Noise (03-003/05)
Electronic Steering
- Electro Hydraulic Power Assist Steering (EHPAS) Technical Supplement (06-001/11)
- Abnormal Whine Noise Of Steering System (06-002/04)
Engine Control Systems
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- Mil Comes On With DTC P2006/Variable Tumble Shutter Valve Cannot Completely Close (01-024/08)
- As-Built Data Search On Ms3 (00-001/10)
- Loose Fuel Filler Cap With DTC P0442, P0455, And P0456 (01-020/10)
- Mil On With DTC P2404 (01-043/09)
- Mil Comes On With P2004 / Check Valve Stuck Open (01-012/09)
- Unstable Idling/Engine Stalls Just After Stopping (01-007/09)
- Mil Illumination - DTC P0441 (01-003/09)
- No COMMS Recovery Procedure For Blanked Module (5876)
- Engine Stalls When Driving At Low Speed (01-022/07)
- Precautions For Module Reprogramming (01-030/08)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Engine Rpm Drops/Engine Stalls (01-033/06)
- Fuel Delivery Module (FDM) Installation (01-029/04)
- Mil Illumination With DTC P0128 (01-008/04)
- Mil Illumination, P0456 (01-039/04)
Entertainment Systems
- Audio/Infotainment System Service Information (09-074/09)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
Exhaust
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Replacing Engine Check Intake And Exhaust Debris (6757)
Exterior Body Panels
- Chattering Noise From Cowl Grill When Passing Over A Bump Or Driving On A Rough Road (09-017/09)
- Service Bumper Specification Change (09-022/09)
- Engine Undercover Removal Caution (09-019/09)
- Loose Door Trim Screw Cap (09-031/04)
- Scraping Noise Over Bumps From Right Rear Wheel (09-018/04)
- Trunk Lid Difficult To Open (09-043/04)
Exterior Lights
- Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
- 2004-2009 MAZDA3 (5-Door) - Hazy Rear Combination Lamp Lens (MT-013/17)
- Condensation/Fog In Front And Rear Combination Lights (09-057/10)
- Water Enters Rear Combination Light (09-012/10)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
- Water Droplets / Moisture Inside Front And Rear Lights (09-024/03)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- License Plate Frame Installation (09-023/03)
Front Suspension
- Front Shock Absorber Noise (02-002/05)
- Rubbing Noise When Turning Steering Wheel (02-005/05)
- Squeaking Noise From Front Suspension When Passing Over A Bump (02-002/06)
Fuel System
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Mil Comes On With DTC P2006/Variable Tumble Shutter Valve Cannot Completely Close (01-024/08)
- Mil Comes On With P2004 / Check Valve Stuck Open (01-012/09)
- Unstable Idling/Engine Stalls Just After Stopping (01-007/09)
- Mil Illumination - DTC P0441 (01-003/09)
- Replacing Engine Check Intake And Exhaust Debris (6757)
- Fuel System Servicing Procedure Precaution (01-042/07)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
- Engine Hard Start (01-041/04)
- Fuel Delivery Module (FDM) Installation (01-029/04)
Fuses & Circuit Breakers
- No Start Due To Frozen Main Relay (01-018/07)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
- Room Fuse Removal / Installation Caution (09-023/04)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Display Shows Inaccurate Ambient Temperature (09-023/14)
- Engine Will Not Start In P-Range Intermittently (05-002/12)
- Crack Appears In Center Of Dashboard (09-070/09)
- Information Display Shows Bars (09-036/04)
Headlights
- Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
- Headlight Plastic Lens Maintenance Caution (09-035/09)
- Condensation/Fog In Front And Rear Combination Lights (09-057/10)
- Water Droplets / Moisture Inside Front And Rear Lights (09-024/03)
Heated Glass/Defoggers
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
HVAC Control Systems
- Air Conditioning Musty/Mildew Odor (07-006/07)
- Splashing Sound From Inside Dash During Cold Start (01-035/09)
- Poor Blower Performance / Wet Passenger Floor (5768)
- A/C Poor Performance (07-005/04)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
- Use Of A/C Tracer Dye (U-008/97)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition Switch/Steering Lock
- Key Reminder Chime Keeps Chiming Or Keyless Entry Inoperative (09-032/06)
Ignition System
- Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
- Spark Plug Installation / Removal Caution (01-036/06)
Infotainment
- Audio/Infotainment System Service Information (09-074/09)
- Navigation Display Standard For Failed Pixels (09-081/09)
- Reprogramming The "Home" Address (6156)
- Short Antenna (5710)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Room Fuse Removal / Installation Caution (09-023/04)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
- Exterior Trim Heat Damage (MT-038/16)
- Headlight Plastic Lens Maintenance Caution (09-035/09)
- Dashboard Upper Surface Poor Appearance (09-038/12)
- Splashing Sound From Inside Dash During Cold Start (01-035/09)
- Front Windshield Protector - Cowl Removal Service Tip (7370)
- Side Protector Peeling (09-048/09)
- Crack Appears In Center Of Dashboard (09-070/09)
- Establishment Of Front-Side Floor Carpet (Black) (09-031/09)
- Floor Covering (Carpet) Changed (09-032/07)
- Water Drips From Ceiling (09-051/06)
- Information Display Shows Bars (09-036/04)
- Loose Door Trim Screw Cap (09-031/04)
- Passenger Carpet Does Not Fit Properly (09-031/06)
- Splashing Sound From Inside Dash During Cold Start (09-017/04)
Interior/Illumination Lights
- Driver Door Lock Inoperative / Room Light Stays On (09-037/04)
- Passenger Junction Box (PJB) Diagnostic Tips (09-025/05)
Lubrication System
- High Engine Oil Consumption (MT-012/15)
- LF / L3 Engine Oil Pan Removal / Installation Procedure And Suggested Repair Time Update (01-013/09)
- Correct Oil Filter Wrenches For LF And L3 Engines (5728)
Manual Steering
- Belt Squeal After Driving Through Water (7416)
- Heavy Steering Effort/Power Steering Fluid Leakage (06-003/08)
- Abnormal Whine Noise Of Steering System (06-002/04)
Manual Trans
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Grinding Noise When Shifting Into 3RD Gear (05-012/09)
- G35M-R MTX - Caution When Servicing 4TH Gear (5739)
Mechanical
- High Engine Oil Consumption (MT-012/15)
- Replacement Engine Assembly Failure (MT-014/16)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Variable Valve Timing (VVT) Noise When Starting Engine (01-043/07)
- Engine Undercover Removal Caution (09-012/07)
- Body Vibration At Cruise Speed (03-003/10)
- Engine Vibration/Knocking Noise/No.3 Engine Mount Rubber Broken (01-035/07)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Specification Change Of Engine Mount Installation Bolt (01-047/09)
- Service Points For Engine Replacement Due To Engine Noise (01-042/09)
- Engine Compartment Shroud Panel Poor Appearance (09-034/09)
- LF / L3 Engine Oil Pan Removal / Installation Procedure And Suggested Repair Time Update (01-013/09)
- Mil Comes On With P2004 / Check Valve Stuck Open (01-012/09)
- Engine Undercover Removal Caution (09-019/09)
- Correct Oil Filter Wrenches For LF And L3 Engines (5728)
- Engine Hanger Interference On Engine Replacement (5897)
- Special Service Tool Shipment - June 2007 (ST-004/07)
- Front Crankshaft Bolt Service Warning (01-040/07)
- Drive Belt TENSIONER Pulley Breakage / Charging Warning Light On / Overheating (01-003/05)
Mechanical - Hydraulic
- Brake Noise, Judder And Dragging Diagnosis And Servicing (04-007/11)
- On-Car Brake Lathe (ST-001/11)
- Brake Rotor Grooved (04-002/05)
- Front Brake Squeak When Cold (04-007/06)
- Squeak Noise From Rear Brakes (04-003/04)
Mirrors
- Side Mirror Glass Moves Freely (5910)
Paint & Coatings
- Side Protector Peeling (09-048/09)
- Paint Damage - Iron Particles / Industrial Fallout / Acid Rain (09-025/04)
Parking Brake System
- Squeak Noise From Rear Brakes (04-003/04)
Passive Restraints
- Seat Belt Minder Deactivation (08-002/04)
Procedures
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- Establishment Of Rear Trailing Link Bushing (02-009/09)
- Noise From Rear Stabilizer Control Link (02-008/09)
Restraints Control Systems
- Passenger Airbag Deactivation (Pad) Indicator Light Illumination (08-003/11)
- As-Built Data Search On Ms3 (00-001/10)
- Airbag Warning Light Comes On With Code B1877/B1881 (08-001/07)
- Seat Belt Minder Deactivation (08-002/04)
Schedule
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
Seats
- Chattering Noise/Unable To Adjust Driver-Side Manual Seat Lift (09-059/09)
- Driver Seat Rattle Noise When Stopping Or Starting The Vehicle (09-043/12)
- Seat Shakes Back And Forth / Makes Noise When Braking (09-025/12)
- Seat Trim Replacement Procedure (09-076/09)
- Squeaking Noise From Seat Back Due To Frame And Seat Back Pad Contact (09-069/09)
- Rattling Or Chattering Noise From Headrest (09-063/09)
- Squeaking Noise From Seat Back Due To Frame And Spring Contact (09-064/09)
- Squeaking Noise From Under Driver Seat Lifter Link (09-065/09)
- Clunk Noise From Seat When Braking (09-060/09)
- Seat Shakes Back And Forth/Makes Noise When Braking (09-061/09)
- Squeaking Noise From Leather Seats (09-062/09)
- Rear Seat Cushion - Locks Stick To Seat During Removal (09-009/06)
- Seat Belt Minder Deactivation (08-002/04)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- JIS/BCI Standard To CCA Conversion Chart (01-010/10)
- JIS/BCI Standard To CCA Conversion Chart (00-003/09)
- Removal Precaution For Battery Cover (01-055/08)
- Starter Motor Will Not Crank And Engine Does Not Start (Intermittently) (01-037/08)
- No Start Due To Frozen Main Relay (01-018/07)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
- Room Fuse Removal / Installation Caution (09-023/04)
Steering Column
- Steering Column Slightly Moves In Or Out Telescopically (06-003/10)
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
- Rubbing Noise When Turning Steering Wheel (02-005/05)
Steering Control Systems
- Electro Hydraulic Power Assist Steering (EHPAS) Technical Supplement (06-001/11)
- Precautions For Module Reprogramming (01-030/08)
- Abnormal Whine Noise Of Steering System (06-002/04)
Steering Gear
- Abnormal Whine Noise Of Steering System (06-002/04)
Suspension Control Systems
- Precautions For Module Reprogramming (01-030/08)
- TPMS (Tire Pressure Monitoring System) Warning Lamp Illuminated And A Warning Buzzer - No DTCS - Service Tip (02-004/04)
System
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- Mil Comes On With DTC P2006/Variable Tumble Shutter Valve Cannot Completely Close (01-024/08)
- Loose Fuel Filler Cap With DTC P0442, P0455, And P0456 (01-020/10)
- Mil Comes On With P2004 / Check Valve Stuck Open (01-012/09)
- Mil Illumination - DTC P0441 (01-003/09)
- No COMMS Recovery Procedure For Blanked Module (5876)
- Revised Workshop Manual Diagnostic Procedure For P0441 (01-029/08)
- Fuel System Servicing Procedure Precaution (01-042/07)
- Mil Illumination With DTC P0128 (01-041/07)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- DTC P2407 After EVAP Test Performed (01-005/06)
- Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
- Fuel Delivery Module (FDM) Installation (01-029/04)
- Mil Illumination - P0172 / P2178 / P2188 Set (01-006/06)
- Mil Illumination With DTC P0128 (01-008/04)
- Mil Illumination With DTC P0442 / P0455 / P0456 (01-040/06)
- Mil Illumination, P0171 / P0172 / P0441 / P0442 / P0455 / P0456 / P2177 / P2178 / P2187 / P2188 (01-052/06)
- Mil Illumination, P0456 (01-039/04)
- Mil On With DTC P0106 (01-044/06)
- Room Fuse Removal / Installation Caution (09-023/04)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- Automatic Transmission Diagnostic Procedure (05-004/11)
- As-Built Data Search On Ms3 (00-001/10)
- Engine Will Not Start In P-Range Intermittently (05-012/08)
- Precautions For Module Reprogramming (01-030/08)
- 1 - 2 Shift Shock (05-010/05)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Body Vibration Or Steering Wheel Shimmy (MT-012/18)
- Service Caution For TPMS (02-007/09)
- Periodic Tire Rotation Is A Great Help To Prevent This Symptom. (5650)
- Abs Warning Light On With DTC C1141, C1142, C1233, Or C1234/Grinding Noise From Front Wheels (04-001/07)
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
- TPMS (Tire Pressure Monitoring System) Warning Lamp Illuminated And A Warning Buzzer - No DTCS - Service Tip (02-004/04)
Window Motors & Regulators
- Diagnostic Tips For Windshield Flaws/Scratches/Cracks Caused By External Factors (09-002/10)
- Power Window Motor Noise From Front Door (09-078/09)
- Rear Quarter Glass Replacement Precaution (09-023/09)
- Chattering Noise From Cowl Grill When Passing Over A Bump Or Driving On A Rough Road (09-017/09)
- One-Touch Power Window Stops Halfway (09-012/05)
- Power Window Inoperative (09-032/04)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
- Snap Or Clunk Noise From Front Power Windows (09-015/05)
Wiper/Washer Systems
- Multi-Model - Wiper Rubber Insert Replacement (09-009/10)
- Front Wipers Do Not Wipe Well (09-030/04)
- Wiper Arm Hinges Corroded (09-005/08)
- Unusual Noise From Front Wiper Link (09-022/06)
- Windshield Wiper Blade Maintenance And Cleaning (09-006/06)