Technical Service Bulletins

Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- Special Tool Shipment - February 2006 (ST-001/06)
- WDS PTU Battery Warranty And Order Information (ST-001/05)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Precautions For Module Reprogramming (01-030/08)
- Port Or Dealer Installed Auto-Dimming (Electro-Chromic) Mirror, With Electronic Compass, Ambient Temperature (09-001/04)
Air Bag, SRS
- Stopper Plates For Air Bag Module Connectors Have Been Established As New Service Parts (SA-068/17)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Correct Application For ATF M-V (Type M5), MERCON®V, MERCON®LV, And JWS3309 (T-IV) Automatic Transmission Fluids (05-005/08)
- MERCON® ATF Is Being Replaced By MERCON® V As A Service Fluid For Automatic Transmission/Transaxle And Power Steering Applications (05-007/06)
- Automatic Transmission Service Part Level Change/COMPATIBILTY - Service Tip (05-015/06)
Auxiliary Emission Control Systems
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
Axle Shafts
- Thump / Clunk From Driveline On Light Acceleration Or When Stopping (03-001/04)
Body Electrical
- Electrical - Wiring - Soldering And Crimping Repairs - Service Tip (09-024/05)
Brakes Control Systems
- Precautions For Module Reprogramming (01-030/08)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
Clutch
- Noise From Clutch Release Cylinder When Clutch Is Engaged / Disengaged (05-013/06)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
Cruise Control Systems
- Speed Control Diagnostics (01-047/10)
Differentials & Drive Axles
- Limited Slip Axle Chatter, Shudder, Binding Or Vibration During Low Speed Turning Maneuvers (03-001/05)
- Thump / Clunk From Driveline On Light Acceleration Or When Stopping (03-001/04)
Driveshaft & Universal Joints
- Thump / Clunk From Driveline On Light Acceleration Or When Stopping (03-001/04)
Engine Control Systems
- Precautions For Module Reprogramming (01-030/08)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
Exhaust
- Replacing Engine Check Intake And Exhaust Debris (6758)
- Blue Smoke On Start Up (01-017/08)
Exterior Body Panels
- 2004-2008 Additional Truck Box Drainage Protection (5893)
Exterior Lights
- Cab Plus - Brake Lamps Inoperative - Check Center High Mounted Stop Lamp (CHMSL) -Service Tip (09-008/05)
Fuel System
- Special Service Tool Shipment - October 2011 (ST-002/11)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
Fuses & Circuit Breakers
- Cab Plus - Brake Lamps Inoperative - Check Center High Mounted Stop Lamp (CHMSL) -Service Tip (09-008/05)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Port Or Dealer Installed Auto-Dimming (Electro-Chromic) Mirror, With Electronic Compass, Ambient Temperature (09-001/04)
HVAC Control Systems
- Poor Blower Performance / Wet Passenger Floor (5767)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Spark Plug Installation / Removal Caution (01-036/06)
Infotainment
- Port Or Dealer Installed Auto-Dimming (Electro-Chromic) Mirror, With Electronic Compass, Ambient Temperature (09-001/04)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Replacing Engine Check Intake And Exhaust Debris (6758)
Mechanical - Hydraulic
- On-Car Brake Lathe (ST-001/11)
- Grabbing Condition From Rear Drum Brakes (04-007/09)
- Cab Plus - Brake Lamps Inoperative - Check Center High Mounted Stop Lamp (CHMSL) -Service Tip (09-008/05)
Mirrors
- Port Or Dealer Installed Auto-Dimming (Electro-Chromic) Mirror, With Electronic Compass, Ambient Temperature (09-001/04)
Passive Restraints
- Safety Belt Retracts Too Slowly (08-004/05)
- Seat Belt Tongue Stop Button - Service Tip (08-003/05)
Procedures
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Schedule
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
Steering Column
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
Steering Control Systems
- Precautions For Module Reprogramming (01-030/08)
Suspension Control Systems
- Precautions For Module Reprogramming (01-030/08)
System
- No 3RD Gear, P0733 Set And Flashing TCIL (05-007/05)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- 3.0L - Mil On With Various Misfire DTCS Set (01-012/06)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- Precautions For Module Reprogramming (01-030/08)
- No 3RD Gear, P0733 Set And Flashing TCIL (05-007/05)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Removal And Installation Of Bolt-In Type Back Glass - Service Tip (09-013/05)
Wiper/Washer Systems
- Windshield Wiper Blade Maintenance And Cleaning (09-006/06)