Technical Service Bulletins

Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- Special Tool Shipment - February 2006 (ST-001/06)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Precautions For Module Reprogramming (01-030/08)
Air Bag, SRS
- Stopper Plates For Air Bag Module Connectors Have Been Established As New Service Parts (SA-068/17)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
Auxiliary Emission Control Systems
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
Axle Shafts
- Special Service Tool Shipment - June 2007 (ST-004/07)
Body Electrical
- "Ten" Terminal On 17-Pin Diagnostic Connector (5810)
Brakes Control Systems
- Precautions For Module Reprogramming (01-030/08)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
Cooling System (Mechanical)
- Pre-Mixed Long-Life "Fl22" Engine Coolant (01-033/07)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
Engine Control Systems
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- "Ten" Terminal On 17-Pin Diagnostic Connector (5810)
- Precautions For Module Reprogramming (01-030/08)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Engine Rpm Drops Or Engine Stalls At Idle (01-019/06)
Entertainment Systems
- Audio/Infotainment System Service Information (09-074/09)
- SIRIUS Satellite Radio Activation (09-025/06)
Exhaust
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Replacing Engine Check Intake And Exhaust Debris (6758)
Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Mil Illumination - DTC P0455/P0442/P0456 (01-045/08)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
Front Suspension
- Revised Front Stabilizer Bushing Replacement Procedure And Repair Time (02-005/06)
Fuel System
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
Fuses & Circuit Breakers
- Power Windows Inoperative - Blown Fuse (09-011/05)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
HVAC Control Systems
- Air Conditioning Musty/Mildew Odor (07-006/07)
- Poor Blower Performance / Wet Passenger Floor (5767)
- Use Of A/C Tracer Dye (U-008/97)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition Switch/Steering Lock
- Cannot Pull Key Out Of Ignition Switch (05-006/06)
Ignition System
- Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
- Spark Plug Installation / Removal Caution (01-036/06)
Infotainment
- Audio/Infotainment System Service Information (09-074/09)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
- Front Windshield Protector - Cowl Removal Service Tip (7370)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Replacing Engine Check Intake And Exhaust Debris (6758)
- Camshaft Ticking Noise (01-032/06)
- Special Service Tool Shipment - June 2007 (ST-004/07)
Mechanical - Hydraulic
- On-Car Brake Lathe (ST-001/11)
- Squeaking / Grinding Noise From Rear Brakes (04-007/04)
- Front Brake Clunking Noise (04-003/06)
Paint & Coatings
- MAZDA Paint Program (MPP02) - Paint OVERSPRAY On Exterior Surfaces (09-017/06)
Procedures
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Restraints Control Systems
- Passenger Airbag Deactivation (Pad) Indicator Light Illumination (08-003/11)
- AIRBAG (SAS UNIT) REPLACEMENT CAUTION - DTCs B1342 / B2477 (08-002/06)
Schedule
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
Steering Column
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
Steering Control Systems
- Precautions For Module Reprogramming (01-030/08)
Suspension Control Systems
- Precautions For Module Reprogramming (01-030/08)
System
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- "Ten" Terminal On 17-Pin Diagnostic Connector (5810)
- Engine Misfire Diagnostic Procedures - Service Tip (01-002/06)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- Precautions For Module Reprogramming (01-030/08)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Body Vibration Or Steering Wheel Shimmy (MT-012/18)
- Body Vibration Or Steering Wheel Shimmy (CAT. 02, NO. 001/03)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Power Windows Inoperative - Blown Fuse (09-011/05)
Wiper/Washer Systems
- Windshield Wiper Blade Maintenance And Cleaning (09-006/06)