Technical Service Bulletins

Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Precautions For Module Reprogramming (01-030/08)
Air Bag, SRS
- Stopper Plates For Air Bag Module Connectors Have Been Established As New Service Parts (SA-068/17)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Correct Application For ATF M-V (Type M5), MERCON®V, MERCON®LV, And JWS3309 (T-IV) Automatic Transmission Fluids (05-005/08)
- Delayed Automatic Transmission Engagement (05-003/08)
- MERCON® ATF Is Being Replaced By MERCON® V As A Service Fluid For Automatic Transmission/Transaxle And Power Steering Applications (05-007/06)
- Automatic Transmission Service Part Level Change/COMPATIBILTY - Service Tip (05-015/06)
- Unable To Shift The Transmission Out Of Park With Brake Pedal Engaged (05-008/06)
Brakes Control Systems
- Intermittent Abs, Mil On, Int. Fog Lights/No A/C (5785)
- Precautions For Module Reprogramming (01-030/08)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
Clutch
- Noise From Clutch Release Cylinder When Clutch Is Engaged / Disengaged (05-013/06)
Cooling Fan
- Malfunction Indicator Lamp (Mil) On With DTC P0128 (Coolant Thermostat) (01-043/08)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
Engine Control Systems
- Mil On - DTC P0111 After Using Block Heater (01-011/10)
- Engine Idle (Noise) DROAN/Moan/Vibration In Cab (01-048/09)
- High Idle At Cold Start Or Depressing Clutch (01-037/09)
- Ids/PDS B-52 & Later Calibration Updates (6077)
- Malfunction Indicator Lamp (Mil) On With DTC P0128 (Coolant Thermostat) (01-043/08)
- Intermittent Long Crank (01-042/08)
- Precautions For Module Reprogramming (01-030/08)
Entertainment Systems
- SIRIUS Satellite Radio Activation (09-025/06)
Exhaust
- Replacing Engine Check Intake And Exhaust Debris (6758)
Exterior Body Panels
- 2004-2008 Additional Truck Box Drainage Protection (5893)
Exterior Lights
- Intermittent Abs, Mil On, Int. Fog Lights/No A/C (5785)
Front Suspension
- 2007 B-Series - Pop/Click/Clunk Noise From Front End When Turning At Slow Speeds (06-004/08)
Fuel System
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Ids/PDS B-52 & Later Calibration Updates (6077)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
HVAC Control Systems
- Poor Blower Performance / Wet Passenger Floor (5767)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Spark Plug Installation / Removal Caution (01-036/06)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
Lubrication System
- 2.3L Oil Pump Lower Chain Guide Deleted (6838)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- 2.3L Oil Pump Lower Chain Guide Deleted (6838)
- Replacing Engine Check Intake And Exhaust Debris (6758)
- No Start / Loss Of Engine Timing / Scraping Noise At Crankshaft Pulley - Possible Engine Damage (01-031/08)
- Front Crankshaft Bolt Service Warning (01-040/07)
Mechanical - Hydraulic
- On-Car Brake Lathe (ST-001/11)
- Grabbing Condition From Rear Drum Brakes (04-007/09)
Procedures
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Restraints Control Systems
- B1342 Occupant Classification System Module (5776)
Schedule
- MAZDA Guidelines For Factory Scheduled Maintenance (00-004/12)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- Crank / No Start With DTC P1260, U2510, And B1318 - No Malfunction Indicator Lamp (Mil) (01-030/07)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
Steering Column
- 2007 B-Series - Pop/Click/Clunk Noise From Front End When Turning At Slow Speeds (06-004/08)
Steering Control Systems
- Precautions For Module Reprogramming (01-030/08)
Suspension Control Systems
- Precautions For Module Reprogramming (01-030/08)
- Tire Pressure Monitoring System (TPMS) Indicator Light On - Tire Pressure Sensor Training Procedure (02-003/06)
System
- Mil On - DTC P0111 After Using Block Heater (01-011/10)
- Engine Idle (Noise) DROAN/Moan/Vibration In Cab (01-048/09)
- High Idle At Cold Start Or Depressing Clutch (01-037/09)
- Ids/PDS B-52 & Later Calibration Updates (6077)
- Crank / No Start With DTC P1260, U2510, And B1318 - No Malfunction Indicator Lamp (Mil) (01-030/07)
- Mil Comes On With DTC P0607 (01-005/07)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- Transmission Delayed Engagement - Park-Drive, Neutral-Drive And/Or Neutral-Reverse (05-003/10)
- Precautions For Module Reprogramming (01-030/08)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- TPMS Cannot Be Turned Off Or Reprogrammed (5754)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
- Tire Pressure Monitoring System (TPMS) Indicator Light On - Tire Pressure Sensor Training Procedure (02-003/06)