Technical Service Bulletins

A/C Compressor
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- A/C Refrigerant Service Information (TSB-96-55-006)
- A/C System Leak Checking For R-12 & R134A Systems (TSB-94-55-001)
- Air Conditioning Refrigeration Oil Use (TSB-91-55-003)
- R-12 Handling (TSB-90-55-001)
Accessories Control Systems
- Reprogramming With The Mut-III (Except Raider Models) (TSB-06-00-004)
- Changes To Scan Tool Designations (TSB-03-00-001)
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
- Power Door Lock Interface Module Connection (TSB-90-00-007)
- Speaker Troubleshooting Guide - Service Manual Supplement (TSB-90-54-003)
- Defogger Grid Repair Kit Info (STB-83-08-012)
Aerodynamic Devices
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
Air Bag, SRS
- Aftermarket Accessories Installation (TSB-04-00-003)
Anti-Theft Systems
- Common Wind Noise Detection/Repair (TSB-97-42A-001)
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- Power Door Lock Interface Module Connection (TSB-90-00-007)
Automatic Trans
- Tech Talk (TT222)
- Remanufactured Automatic Transmission Program Update (TSB-05-23-003)
- Mut-III STV Version 10.1 New Features (TSB-04-00-010)
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- Auto Trans Oil Cooler BACKFLUSH Alternative (TSB-99-23-011)
- A/T Cooler Flusher Tool - Replacement Fluid/Filter (MTT 0599-07)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Authorized Factory Fluids, Refrigerants, & Materials (TSB-98-00-0004)
- Replacement Automatic Transmission Flow Test (TSB-98-23-004)
- Automatic Transaxle Rear Clutch Improvements (TSB-97-23-009)
- Automatic Transaxle Whining Noise: New Gears (TSB-94-23-001)
- Auto Trans Gear Noise - Gear Shape Change Info (TSB-92-23-001 (A))
- Km176 Trans Pressure Low/Clutch Slip - D-Ring Seal (TSB-91-23-001)
- Km162 Trans No Rev/Downshift To 4 - RESTRICTOR Ball (TSB-90-22-006)
- Center Support Snap Ring Installation Care Info (TSB-90-23-006)
- 1990 Precis Automatic Transmission Fluid Usage - Service Manual Correction (TSB-90-23-003)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
- Recommend Automatic Transmission And Brake Fluids (STB-00-82-02)
Auxiliary Emission Control Systems
- Tech Talk (TT222)
- Sulfur Odor From Exhaust (TSB-03-15-001)
- Changes To Scan Tool Designations (TSB-03-00-001)
- OBD II - New Mut-II ROM Pack Features (TSB-97-00-002)
- Catalytic Converter Emission Recall (EMR-94-001)
- 4 CYL Engine Rough Idle/ECM Adaptive Memory Loss (TSB-93-13-004)
- Multi-Use Tester-II Application (TSB-93-00-004)
- Ordering Vehicle Emission Control Information Labels (MTT 0593-03)
- Vehicle Emission Control Information Label Ordering (TSB-93-17-001)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
- Verifying Codes With Multi-Use Tester - Purpose (TSB-92-00-001)
- "No Problem Found" Parts - (CALIFORNIA Dealers Only) (TSB-91-17-002)
- Oxygen Sensor - Information/Diagnostic Procedure (TSB-91-13-004)
- 1.5L Eng Ck Eng Light/Stalls/No A/C - Wire Loom Fix (TSB-91-13-003)
- Multi-Use Tester Part Number Explanation (TSB-89-00-008)
Axle Shafts
- Rear Axle Hub Nut - Service Manual Correction (TSB-90-34-001)
Body Interior
- Changes To Scan Tool Designations (TSB-03-00-001)
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
- Ecu Circuit Testing Precautions - Test Light Warning (TSB-92-00-003)
- Clicking Noise From A/C Relay - Service A/C Kit (TSB-90-55-005)
- Power Door Lock Interface Module Connection (TSB-90-00-007)
Brakes Control Systems
- Wiring Harness Repair Kit (TSB-03-00-023)
- Brake Judder Diagnosis & Repair - All W/Disc Brakes (TSB-97-35-004)
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
Charging Systems
- MIDTRONICS Micro530 Battery/Starting/Charging System Analyzer (TSB-01-00-011REV)
- Window Regulator Out Of Adjustment/Does Not Operate (MTT 0599-09)
Clutch
- Flywheel Resurfacing Limitations Advisory (TSB-93-21-001)
- Manual Transaxle Fix/Droning Noise/Precis (TSB-91-22-001)
Cooling System (Mechanical)
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- Water Pump Leakage Through Vent Hole - Testing (MTT 0599-06)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Authorized Factory Fluids, Refrigerants, & Materials (TSB-98-00-0004)
- Fuel Pump Replacement Procedures (TSB-92-13-011)
- Modification Of Radiator Air Guard For A/C Condenser (TSB-91-55-004)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
Cruise Control Systems
- Changes To Scan Tool Designations (TSB-03-00-001)
Differentials & Drive Axles
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Authorized Factory Fluids, Refrigerants, & Materials (TSB-98-00-0004)
Engine Control Systems
- Tech Talk (TT222)
- Reprogramming With The Mut-III (Except Raider Models) (TSB-06-00-004)
- Wiring Harness Repair Kit (TSB-03-00-023)
- Changes To Scan Tool Designations (TSB-03-00-001)
- OBD II - New Mut-II ROM Pack Features (TSB-97-00-002)
- 4 CYL Engine Rough Idle/ECM Adaptive Memory Loss (TSB-93-13-004)
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
- Verifying Codes With Multi-Use Tester - Purpose (TSB-92-00-001)
- "No Problem Found" Parts - (CALIFORNIA Dealers Only) (TSB-91-17-002)
- 1.5L Eng Ck Eng Light/Stalls/No A/C - Wire Loom Fix (TSB-91-13-003)
- Multi-Use Tester Part Number Explanation (TSB-89-00-008)
Entertainment Systems
- Radio Security Code Online Retrieval Available To Customers (TT-192-54-007)
- Audio System Diagnosis (TSB-98-54-001)
- Cd Player Function Problems (TSB-02-54-009)
- 1.5L Eng Cranks But Will Not Start - Radio Filter (TSB-90-16-002)
- Speaker Troubleshooting Guide - Service Manual Supplement (TSB-90-54-003)
Exhaust
- Sulfur Odor From Exhaust (TSB-03-15-001)
Exterior Body Panels
- Vehicle Receiving Inspection - Road Salt Contamination (TT-191-00-002)
- Common Wind Noise Detection/Repair (TSB-97-42A-001)
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- Left Rear Suspension Arm Protector Safety Recall (SR-94-001)
- Fuel Starvation/Fuel Delivery: Fuel System Diagnosis (TSB-93-13-003)
- Body Water Leak Diagnosis And Repair Procedure (TSB-90-42B-002)
- PDI Door Panel Protector Removal (TSB-90-51-001)
- Electronic Welding Precautions (STB-84-23-001)
Exterior Lights
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
Frames, Subframes & Crossmembers
- Vehicle Receiving Inspection - Road Salt Contamination (TT-191-00-002)
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- Body Water Leak Diagnosis And Repair Procedure (TSB-90-42B-002)
- Electronic Welding Precautions (STB-84-23-001)
Front Suspension
- Left Rear Suspension Arm Protector Safety Recall (SR-94-001)
- Front Suspension Squeak - New Stabilizer Bar Bushing (TSB-92-33A-001)
- New Strut/Shock And Spring Damping Rate (TSB-90-33A-002)
Fuel System
- Tech Talk (TT222)
- Sulfur Odor From Exhaust (TSB-03-15-001)
- Changes To Scan Tool Designations (TSB-03-00-001)
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- "No Problem Found" Parts - (CALIFORNIA Dealers Only) (TSB-91-17-002)
Fuses & Circuit Breakers
- Ecu Circuit Testing Precautions - Test Light Warning (TSB-92-00-003)
Gauges & Instrument Panels
- Speedometer Replacement & Odometer Resetting To Actual Mileage (TSB-06-54-011)
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- 1.5L Eng Ck Eng Light/Stalls/No A/C - Wire Loom Fix (TSB-91-13-003)
Headlights
- Tech Talk (TT222)
Heated Glass/Defoggers
- Rear Window Defogger Grid Repair (TSB-95-54-001)
- Defogger Grid Repair Kit Info (STB-83-08-012)
HVAC Control Systems
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- Musty Odors From A/C - A/C Evaporator Coil Treatment (TSB-02-55-005)
- A/C Refrigerant Service Information (TSB-96-55-006)
- A/C System Leak Checking For R-12 & R134A Systems (TSB-94-55-001)
- Air Conditioner Odor Cause/Correction (TSB-93-55-001)
- 1.5L Eng Ck Eng Light/Stalls/No A/C - Wire Loom Fix (TSB-91-13-003)
- Air Conditioning Refrigeration Oil Use (TSB-91-55-003)
- Modification Of Radiator Air Guard For A/C Condenser (TSB-91-55-004)
- Clicking Noise From A/C Relay - Service A/C Kit (TSB-90-55-005)
- R-12 Handling (TSB-90-55-001)
- Microbial Growth Odor A/C-Heater - Cleaning Info (TSB-88-24-004)
Identification
- Vehicle Payload Carrying Capacity (TSB-00-00-016)
- Ordering Vehicle Emission Control Information Labels (MTT 0593-03)
- Vehicle Emission Control Information Label Ordering (TSB-93-17-001)
- Replacement Vehicle Identification Number Plate (TSB-92-00-010)
- Vehicle Identification Number Master Decoder (TSB-92-00-005)
- Vehicle Identification Number Master Decoder (TSB-91-00-009)
- Manual Transaxle Identification NUMERING System (TSB-90-22-005)
- VIN Breakdown (TSB-90-00-001)
- Revised Vehicle Code Plate Information (TSB-89-00-007)
- Revised Curb Idle Speed (TSB-89-00-006)
- Revised Curb Idle Speed (TSB-89-00-005)
Ignition System
- Hard Start/Rough Idle - Fouled Spark Plug Service (TSB-95-16-003)
- Fuel Pump Replacement Procedures (TSB-92-13-011)
- 1.5L Eng Power Loss Poor Idle - Worn Crank Sprocket (TSB-91-11-011)
Interior/Exterior Trim
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Common Wind Noise Detection/Repair (TSB-97-42A-001)
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- Modification Of Radiator Air Guard For A/C Condenser (TSB-91-55-004)
- Body Water Leak Diagnosis And Repair Procedure (TSB-90-42B-002)
- Windshield & Window Glass INSTALLLATION Procedure (TSB-90-42B-001)
- Rear Shelf Rattle Noise Reduction (TSB-89-52-001)
- Microbial Growth Odor A/C-Heater - Cleaning Info (TSB-88-24-004)
Lubrication System
- Obsolete Engine Oils (TSB-05-12-001)
- Oil Economy Test & Oil Consumption Evaluation (TSB-03-11-001)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Authorized Factory Fluids, Refrigerants, & Materials (TSB-98-00-0004)
- Oil Economy Test - Purpose/Procedure (TSB-96-11-005)
- Fuel Pump Replacement Procedures (TSB-92-13-011)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
Manual Steering
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
Manual Trans
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- M/T Transaxle Gear Oil: Use Only API GL4 (TSB-93-22-001)
- Reverse Gear Idler Shaft INSTALATION - Warning (TSB-91-22-004)
- Manual Transaxle Fix/Droning Noise/Precis (TSB-91-22-001)
- Km162 Trans No Rev/Downshift To 4 - RESTRICTOR Ball (TSB-90-22-006)
- Manual Transaxle Identification NUMERING System (TSB-90-22-005)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
Mechanical
- Obsolete Engine Oils (TSB-05-12-001)
- Oil Economy Test & Oil Consumption Evaluation (TSB-03-11-001)
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Piston Pin Installation Tool Instructions (TSB-96-11-009)
- Oil Economy Test - Purpose/Procedure (TSB-96-11-005)
- Fuel Pump Replacement Procedures (TSB-92-13-011)
- Using Piston Pin Tool (TSB-90-11-007)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
Mechanical - Hydraulic
- Cautionary Instruction For Handling Stop Light Switches - Service Manual Revision (TSB-08-35-001)
- Authorized Genuine MITSUBISHI Fluids, Refrigerants, Chemicals, And Materials (TSB-98-00-004)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Authorized Factory Fluids, Refrigerants, & Materials (TSB-98-00-0004)
- Brake Judder Diagnosis & Repair - All W/Disc Brakes (TSB-97-35-004)
- Brake Rotor Servicing Procedures (TSB-92-35-008)
- Brake Pad Installation - Process/Procedure/HILIGHTS (TSB-92-35-003)
- Recommend Automatic Transmission And Brake Fluids (STB-00-82-02)
Mirrors
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- Engine Block Heater Application & Installation (TSB-96-11-003)
Paint & Coatings
- Vehicle Receiving Inspection - Road Salt Contamination (TT-191-00-002)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Common Wind Noise Detection/Repair (TSB-97-42A-001)
- Paint Damage Identification & Repair Procedures (TSB-92-51-001)
- 1990 MITSUBISHI Exterior Color Codes & Applications (TSB-89-51-003)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
Passive Restraints
- Tech Talk (TT222)
- Aftermarket Accessories Installation (TSB-04-00-003)
Rear Suspension
- Left Rear Suspension Arm Protector Safety Recall (SR-94-001)
- Front Suspension Squeak - New Stabilizer Bar Bushing (TSB-92-33A-001)
- New Strut/Shock And Spring Damping Rate (TSB-90-33A-002)
Restraints Control Systems
- Tech Talk (TT222)
- Wiring Harness Repair Kit (TSB-03-00-023)
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
Seats
- Aftermarket Accessories Installation (TSB-04-00-003)
- Synthetic Resin Parts: Heat Resistance Temp Spec. (TSB-96-42A-015)
- Engine Block Heater Application & Installation (TSB-96-11-003)
- Front Seat Belt Buckle Safety Recall (SR-95-002)
Starter
- Battery Application Guide & Cold Cranking Amps Specifications (TSB-03-54-011)
- Window Regulator Out Of Adjustment/Does Not Operate (MTT 0599-09)
- Fuel Pump Replacement Procedures (TSB-92-13-011)
- Long Term Storage: Battery Servicing (TSB-90-16-001)
- Ignition Off Draw STORGE Connector Information (TSB-90-54-007)
- Long-Term Vehicle Storage Information (TSB-90-54-008)
- Battery REPLACMENT - Test Procedure (TSB-88-08-006)
- Battery Storage Maintenance Procedure (TSB-88-08-001)
- Battery Charging Tips (STB-84-08-006)
Steering Column
- Alignment Procedure For Clock Spring Neutral Point - Service Manual Revision (TSB-08-52B-002)
Steering Control Systems
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
Sun Roof/T-Top/Convertible Top
- Aftermarket Accessories Installation (TSB-04-00-003)
Suspension Control Systems
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
System
- New Mut-III STV Software Features (TSB-06-00-005)
- Sulfur Odor From Exhaust (TSB-03-15-001)
- Wiring Harness Repair Kit (TSB-03-00-023)
- Changes To Scan Tool Designations (TSB-03-00-001)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- OBD II - New Mut-II ROM Pack Features (TSB-97-00-002)
- Hard Start/Rough Idle - Fouled Spark Plug Service (TSB-95-16-003)
- Catalytic Converter Emission Recall (EMR-94-001)
- 4 CYL Engine Rough Idle/ECM Adaptive Memory Loss (TSB-93-13-004)
- Multi-Use Tester-II Application (TSB-93-00-004)
- Ordering Vehicle Emission Control Information Labels (MTT 0593-03)
- Vehicle Emission Control Information Label Ordering (TSB-93-17-001)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
- Fuel Pump Replacement Procedures (TSB-92-13-011)
- Verifying Codes With Multi-Use Tester - Purpose (TSB-92-00-001)
- 1.5L Eng Power Loss Poor Idle - Worn Crank Sprocket (TSB-91-11-011)
- "No Problem Found" Parts - (CALIFORNIA Dealers Only) (TSB-91-17-002)
- Oxygen Sensor - Information/Diagnostic Procedure (TSB-91-13-004)
- 1.5L Eng Ck Eng Light/Stalls/No A/C - Wire Loom Fix (TSB-91-13-003)
- Multi-Use Tester Part Number Explanation (TSB-89-00-008)
- Battery Charging Tips (STB-84-08-006)
- LUBRICANTCS Sealers Adhesives Cleaners Table (STB-83-00-007)
Transmission Control Systems
- Tech Talk (TT222)
- Reprogramming With The Mut-III (Except Raider Models) (TSB-06-00-004)
- Mut-III STV Version 10.1 New Features (TSB-04-00-010)
- Wiring Harness Repair Kit (TSB-03-00-023)
- Changes To Scan Tool Designations (TSB-03-00-001)
- Multi-Use Tester-II Application (TSB-93-00-004)
- MSN-5 Multi-Use Tester ROM Pack Usage (TSB-92-00-009)
Wheel Hubs
- Rear Axle Hub Nut - Service Manual Correction (TSB-90-34-001)
Wheels & Tire System
- Aftermarket Accessories Installation (TSB-04-00-003)
- Wheel Balance Accuracy (TSB-99-31-004)
- Brake Judder Diagnosis & Repair - All W/Disc Brakes (TSB-97-35-004)
- Wheel Lug Nut Torque Specifications (TSB-92-31-001)
Window Motors & Regulators
- Window Regulator Out Of Adjustment/Does Not Operate (MTT 0599-09)
- Sealants, Adhesives, THREADLOCKERS & Undercoating (TSB-99-00-002)
- Common Wind Noise Detection/Repair (TSB-97-42A-001)
- Engine Block Heater Application & Installation (TSB-96-11-003)
- Windshield Film Buildup - Vinyl Chemical Release (TSB-96-42A-007)
- Body Water Leak Diagnosis And Repair Procedure (TSB-90-42B-002)
Wiper/Washer Systems
- Authorized Factory Fluids, Refrigerants, & Materials (TSB-98-00-0004)
Wiring Diagrams
- A/C Relay Relocation - Service Manual Supplement (TSB-90-55-004)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring Harness Repair Kit (TSB-03-00-023)
- Changes To Scan Tool Designations (TSB-03-00-001)
- Ecu Circuit Testing Precautions - Test Light Warning (TSB-92-00-003)
- A/C Relay Relocation - Service Manual Supplement (TSB-90-55-004)