Technical Service Bulletins

A/C Compressor
- Air Conditioning Compressor Noise Upon Initial Operation (SI-0011)
Accessories & Equipment
- Pass-Thru Reprogramming Software Version 1.8.3.0 (TS 04 11106R)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Accessories Control Systems
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
Automatic Trans
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 04022R2)
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 12200)
- Automatic Transmission Shift Lever Is Loose In The Shift Gate And/Or Ignition Key Cannot Be Removed (TS 09 03129R)
- Automatic Transmission Harsh Shift With Mil On And Either Of The Following DTCS; P0783, P0734 (TS 08 12018R)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Automatic Transmission Harsh Shift With Mil On And Either Of The Following DTCS; P0783, P0734 (TS 08 03222R)
Auxiliary Emission Control Systems
- Improper Diagnosis Of Catalytic Converter Failure When DTC P0420 Is Present. (TS 29 09071)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Catalyst System (TS 28 10220)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: EGR (Exhaust Gas RECIRCULATION) (TS 26 10200)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Evaporative Emission System (TS 27 10210)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor Heater (TS 25 10190)
Cooling System (Mechanical)
- Correct Coolant Usage (TS 01 12086R2)
- Water Pump Leak (TS 06 03296)
Engine Control Systems
- Throttle Position Sensor Replacement (TS 31 10064R1)
- Oil Pump Pressure Switch Relocation When Replacing The Oil Pump (TS 30 06263)
- Extended Cranking Time (Hard Starting) (TS 33 10251)
- Improper Diagnosis Of Catalytic Converter Failure When DTC P0420 Is Present. (TS 29 09071)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Catalyst System (TS 28 10220)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: EGR (Exhaust Gas RECIRCULATION) (TS 26 10200)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Evaporative Emission System (TS 27 10210)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor Heater (TS 25 10190)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor (TS 24 10180)
- Counter-Measure Procedure For DTC P2138 (TS 23 08020)
- Counter-Measure Procedure For DTC P2138 (TS 23 06110)
- Counter-Measure Procedure For DTC P2135 (TS 22 05040)
- P0441 Or P0496 (Evaporative Emission System Continuous Purge Flow) (TS 08 12177R)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Extended Cranking Time Or Hard Start Condition After Performing TSB Engine 09 10056 Reprogram (TS 13 02237)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- VIN # Registration After ECM Replacement (TS 04 10214)
- Counter-Measure Procedure For DTC P2138 (TS 23 08020R)
Exterior Lights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
- Pigtail Installation For DRL Module And/Or Signal Switch (TS 15 10244)
Front Suspension
- Inspection And Maintenance Reminder Lower Arm Ball Joint (TS 01 11298)
- Noise From The Front Stabilizer Bar Bushings (TS 02 08317R2)
Fuel System
- Throttle Position Sensor Replacement (TS 31 10064R1)
- Counter-Measure Procedure For DTC P2138 (TS 23 08020)
- Counter-Measure Procedure For DTC P2135 (TS 22 05040)
- Hard To Find Fuel Odor; Diagnostic Information (TS 19 05028)
- No Fuel Pump Prime Before Start Up (TS 14 04067)
- Counter-Measure Procedure For DTC P2138 (TS 23 08020R)
- Counter-Measure Procedure For DTC P2138 (TS 23 06110)
Headlights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
- Pigtail Installation For DRL Module And/Or Signal Switch (TS 15 10244)
Identification
- VIN # Registration After ECM Replacement (TS 04 10214)
Ignition Switch/Steering Lock
- Automatic Transmission Shift Lever Is Loose In The Shift Gate And/Or Ignition Key Cannot Be Removed (TS 09 03129R)
Interior/Exterior Trim
- Technician/Vehicle Owner "Best Practices": Inspecting, Removing, And Installing Floor Mats In SUZUKI Vehicles (TS 03 07210)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Lubrication System
- Oil Pump Pressure Switch Relocation When Replacing The Oil Pump (TS 30 06263)
- Oil Leak Identification (TS 07 07018)
Manual Steering
- Power Steering Oil Leak Identification (TS 02 10278)
Manual Trans
- Manual Transmission Stuck In 5TH Gear Model(S): FORENZA Sedan/Wagon, RENO (RQ420) (TS 07 07188)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Mechanical
- Oil Pump Pressure Switch Relocation When Replacing The Oil Pump (TS 30 06263)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Rubbing Noise Coming From Front (Timing Belt Cover) Area Of Engine (TS 21 03259)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Mechanical - Hydraulic
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Steering Gear
- Power Steering Oil Leak Identification (TS 02 10278)
System
- Throttle Position Sensor Replacement (TS 31 10064R1)
- Extended Cranking Time (Hard Starting) (TS 33 10251)
- Improper Diagnosis Of Catalytic Converter Failure When DTC P0420 Is Present. (TS 29 09071)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Catalyst System (TS 28 10220)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: EGR (Exhaust Gas RECIRCULATION) (TS 26 10200)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Evaporative Emission System (TS 27 10210)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor Heater (TS 25 10190)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor (TS 24 10180)
- Counter-Measure Procedure For DTC P2138 (TS 23 08020)
- Counter-Measure Procedure For DTC P2138 (TS 23 06110)
- Counter-Measure Procedure For DTC P2135 (TS 22 05040)
- Engine Has No Power, Hesitates, Stumbles On Acceleration, Check Engine Light Is On With Multiple DTCS With P161B (Control Module Torque Performance) As The Primary DTC (TS 18 02228)
- P0133 (Front Oxygen Sensor Slow Response) (TS 12 12177R)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Extended Cranking Time Or Hard Start Condition After Performing TSB Engine 09 10056 Reprogram (TS 13 02237)
- Counter-Measure Procedure For DTC P2138 (TS 23 08020R)
Transmission Control Systems
- Automatic Transmission Harsh Shift With Mil On And Either Of The Following DTCS; P0783, P0734 (TS 08 12018R)
- Required Automatic Transmission Control Module Initialization Procedure (TS 06 01238)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- VIN # Registration After ECM Replacement (TS 04 10214)
Wiper/Washer Systems
- Rear Window Washer Does Not Spray (TS 12 02088)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Pigtail Installation For DRL Module And/Or Signal Switch (TS 15 10244)