Technical Service Bulletins

A/C Compressor
- Alternate Refrigerants And A/C Retrofit (AC003-96)
- Service Hints For Refrigerant Leak Detection - Info (AC95-001)
- Avoiding A/C Compressor Failure: Lube Oil REQTS. (AC93-005)
- A/C Service - Evacuation Procedure Revision (VOL. 10, A/C, NO. 007)
- A/C Not Cooling - REPL A/C Compressor Line O-Rings (VOL. 8, ACC, NO. 003)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- A/C Refrigerant Pressure Conversion Reference Chart (AC92-005)
- Air Conditioner System O-Ring Color Change (AC92-004)
- Air Conditioning System Service Procedure (AC93-003)
Accessories Control Systems
- Battery Maintenance For Vehicles In Storage (EL92-001)
- New Corrosion Resistant Fuel Sender Wiring Connector (VOL. 7, ELC, NO. 005)
Accessory Drive Belts
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Anti-Theft Systems
- Battery Maintenance For Vehicles In Storage (EL92-001)
- VIN Plates And Certification Labels - Information (VOL. 10, PGI, NO. 015)
- Key Code And Key Cutter Information (VOL. 9, PGI, NO. 022)
Automatic Trans
- Transmission Number And Location Information (VOL. 7, TRN, NO. 018)
- Engine Support Bar Improvements (SS95-003)
- Torque Converter To FLEXPLATE Mounting Bolt Warnings (VOL. 10, TRN, NO. 036)
- A13/A24 Series & A140 Trans Harsh 2-3 Shift Hot/Cold (VOL. 10, TRN, NO. 025)
- Trans/Cooler Flushing Procedure (VOL. 10, TRN, NO. 006)
- AISIN-WARNER/TOYOTA Trans - Oil Pump/Stator Info (VOL. 8, TRN, NO. 014)
- A140E A130L And A131L Automatic Transaxle Diagnosis (VOL. 7, TRN, NO. 025)
- Formed In Place Gasket For Transaxle Case (VOL. 7, TRN, NO. 019)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Auxiliary Emission Control Systems
- Sulfur Odor From Exhaust (EG003-03)
- Emission Control Label OREDERING Information (PG95-005)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Axle Shafts
- Revised Drive Shaft Grease (TC002-99)
- Two-Piece Driveshaft Replacement Parts - RWD Models (VOL. 7, NVH, NO. 002)
- Propeller Shaft Tightening Bolt And Nut Modification (VOL. 7, AXL, NO. 006)
Blowers, Superchargers & Turbochargers
- 1.5/1.6L Eng Crankshaft Damper Pulley Improvement (VOL. 7, ENG, NO. 017)
- V-Ribbed Drive Belts - Introduction Information (VOL. 7, ENG, NO. 013)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Body Interior
- Air Conditioning Evaporator Odor (AC002-97)
- A/C Evaporator Odor - New Treatment/Part Number (VOL. 8, ELC, NO. 012)
- New Corrosion Resistant Fuel Sender Wiring Connector (VOL. 7, ELC, NO. 005)
Brakes Control Systems
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Charging Systems
- MIDTRONICS Battery Tester Software Update (SS002-02)
- 1.5/1.6L Eng Crankshaft Damper Pulley Improvement (VOL. 7, ENG, NO. 017)
- 1.6/2.0/2.8L Eng Improved Alternator Cooling (VOL. 7, ELC, NO. 010)
- V-Ribbed Drive Belts - Introduction Information (VOL. 7, ENG, NO. 013)
Communication Devices
- Mobile Communication System Installation:Precautions (AU93-001)
Cooling Fan
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Cooling System (Mechanical)
- Radiator Cap Inspection (EG014-05)
- Recycled Coolants - TOYOTAS Disclaimer (PI91-006)
- TOYOTA Silicone Formed In Place Gasket For Oil Pans (VOL. 7, ENG, NO. 011)
- Correct Oil Filter Replacement Procedure (VOL. 7, ENG, NO. 009)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Cruise Control Systems
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Differentials & Drive Axles
- Revised Drive Shaft Grease (TC002-99)
- Two-Piece Driveshaft Replacement Parts - RWD Models (VOL. 7, NVH, NO. 002)
- Propeller Shaft Tightening Bolt And Nut Modification (VOL. 7, AXL, NO. 006)
Driveshaft & Universal Joints
- Revised Drive Shaft Grease (TC002-99)
- Two-Piece Driveshaft Replacement Parts - RWD Models (VOL. 7, NVH, NO. 002)
- Propeller Shaft Tightening Bolt And Nut Modification (VOL. 7, AXL, NO. 006)
Electronic Steering
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Electronic Suspension
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Engine Control Systems
- Sulfur Odor From Exhaust (EG003-03)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Entertainment Systems
- Cigarette Lighter Service (EL002-98)
- Cleaning Cassette Tape Heads (AU001-97 REV)
- Am Static Noise On Vehicles With Power Antennas (AU002-96)
- Identification Number On Audio Units - Information (VOL. 10, AUD, NO. 006)
- Radio Antenna Feeder Cable (VOL. 8, ACC, NO. 020)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Exhaust
- Sulfur Odor From Exhaust (EG003-03)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Exterior Body Panels
- Rivet Nut Tool (SS003-98)
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- Adjustment Of New Headrests (BO91-010)
Exterior Lights
- Battery Maintenance For Vehicles In Storage (EL92-001)
Frames, Subframes & Crossmembers
- Paint Repairs On Polyurethane Bumper - Information (PA95-001)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
- Adjustment Of New Headrests (BO91-010)
Front Suspension
- Coil Spring Compressor Tool: Proper Use (SS93-001)
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Fuel System
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Fuses & Circuit Breakers
- Wire Harness Repair Kit "B": New Tool (SS94-002)
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Radio Antenna Feeder Cable (VOL. 8, ACC, NO. 020)
- New Corrosion Resistant Fuel Sender Wiring Connector (VOL. 7, ELC, NO. 005)
Gauges & Instrument Panels
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- VIN Plates And Certification Labels - Information (VOL. 10, PGI, NO. 015)
- New Corrosion Resistant Fuel Sender Wiring Connector (VOL. 7, ELC, NO. 005)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- Adjustment Of New Headrests (BO91-010)
Headlights
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
HVAC Control Systems
- Air Conditioning Evaporator Odor (AC002-97)
- Alternate Refrigerants And A/C Retrofit (AC003-96)
- A/C Compressor Maintenance For Stored Vehicles (AC002-96)
- Service Hints For Refrigerant Leak Detection - Info (AC95-001)
- Avoiding A/C Compressor Failure: Lube Oil REQTS. (AC93-005)
- A/C Service - Evacuation Procedure Revision (VOL. 10, A/C, NO. 007)
- A/C Evaporator Odor - New Treatment/Part Number (VOL. 8, ELC, NO. 012)
- A/C Not Cooling - REPL A/C Compressor Line O-Rings (VOL. 8, ACC, NO. 003)
- A/C O-Ring Kit Available (VOL. 8, ELC, NO. 006)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- A/C Refrigerant Pressure Conversion Reference Chart (AC92-005)
- Air Conditioner System O-Ring Color Change (AC92-004)
- Air Conditioning System Service Procedure (AC93-003)
Identification
- Replacement Certification Labels And VIN Plates (T-SB-0032-20 REV2)
- Replacement VIN Plates (PG009-02)
- Replacement VIN Plates (PG005-97)
- Replacement Certification Labels (PG004-97)
- VIN Plates & Certification Labels: Replacements (PG93-002)
- CALIFORNIA Vehicle Emission Control Info. Labels (PI91-008)
- VIN Plates & Certification Labels - Information (PI91-002)
- Key Number New Location Stamp (VOL. 7, PGI, NO. 002)
Ignition Switch/Steering Lock
- Key Code And Key Cutter Information (VOL. 9, PGI, NO. 022)
Ignition System
- Signal Generator Resistance Specifications (EN91-007)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
Infotainment
- Am Static Noise On Vehicles With Power Antennas (AU002-96)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Interior/Exterior Trim
- Refinishing Replacement Bumper Covers (PA003-02 REV.)
- Rivet Nut Tool (SS003-98)
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- SEATBELT Retractor INOP - Undercoat Application Info (VOL. 9, PGI, NO. 018)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
- Adjustment Of New Headrests (BO91-010)
Interior/Illumination Lights
- Battery Maintenance For Vehicles In Storage (EL92-001)
Locking Hubs
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Lubrication System
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- TOYOTA Silicone Formed In Place Gasket For Oil Pans (VOL. 7, ENG, NO. 011)
- Correct Oil Filter Replacement Procedure (VOL. 7, ENG, NO. 009)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Manual Steering
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Manual Trans
- Revised Drive Shaft Grease (TC002-99)
- Transmission Number And Location Information (VOL. 7, TRN, NO. 018)
- Engine Support Bar Improvements (SS95-003)
- Replacement Parts For S5# Model Manual Transaxles (TC95-003)
- Transaxle Side Gear Shaft Installation Procedures (VOL. 7, TRN, NO. 022)
- Formed In Place Gasket For Transaxle Case (VOL. 7, TRN, NO. 019)
- T40/T50 Trans Modified Bearings, Shafts, Gears (VOL. 7, TRN, NO. 010)
Mechanical
- Engine Support Bar Improvements (SS95-003)
- Standard Bolt Torque Specifications (PG95-006)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- 1.6/1.8/2.0L Eng Valve SPRNG Compressor - Tool Table (VOL. 8, SST, NO. 004)
- Engine Mounting Insulator (VOL. 7, ENG, NO. 026)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- 1.5/1.6L Eng Crankshaft Damper Pulley Improvement (VOL. 7, ENG, NO. 017)
- TOYOTA Silicone Formed In Place Gasket For Oil Pans (VOL. 7, ENG, NO. 011)
- Correct Oil Filter Replacement Procedure (VOL. 7, ENG, NO. 009)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Mechanical - Hydraulic
- Brake Booster Push Rod Gauge (SST) (SS002-97)
- Introduction Of Brake Shim Kit & Brake Fitting Kits (BR95-003)
- Brake Vibration/Pulsation: Corrective Measures (BR94-002)
- Introduction Of New Disc Brake Pad Kit (BR94-004)
- TOYOTA Brake Pads-Proper Balance Of Friction & Force (TSN93-46-3)
- Brake Disc Anti-Rust Cover Removal (VOL. 7, BRK, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Memory Modules
- Battery Maintenance For Vehicles In Storage (EL92-001)
Mirrors
- Wire Type Window REGUALTOR Assembly - New Part (BO94-015)
Paint & Coatings
- Paint Repairs On Polyurethane Bumper - Information (PA95-001)
- Acid Rain Damage - Condition/Cause/Inspection/Repair (VOL. 10, BOD, NO. 043R)
- New Vehicle Washing Schedule For Paint Protection (BO91-019)
- Iron Particle Contamination Repair (VOL. 10, BOD, NO. 045)
- Pearl Mica Paint Care/Scratch Removal (VOL. 9, BOD, NO. 015)
- Urethane Adhesive Sealant For Fixed Glass Install (VOL. 8, BOD, NO. 032)
- Paint Codes For All 1983 Models (VOL. 7, PNT, NO. 001)
Parking Brake System
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Passive Restraints
- Seat Belt Tongue Plate Stopper Replacement (T-SB-0258-08)
- Child Restraint Seat Top Strap Bracket Installation (BO010-02)
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Rear Suspension
- Coil Spring Compressor Tool: Proper Use (SS93-001)
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Schedule
- Battery Maintenance For In-Stock Vehicles - Info (EL95-001)
Seats
- Child Restraint Seat Top Strap Bracket Installation (BO010-02)
- Seat Belt Extenders - Information And Order Process (BO92-003)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Seat Belt Extender - Information (VOL. 10, BOD, NO. 017)
- SEATBELT Retractor INOP - Undercoat Application Info (VOL. 9, PGI, NO. 018)
- Seat Belt Extender Description/Ordering Info (VOL. 8, BOD, NO. 044)
- Original TOYOTA Seat Cover Material (VOL. 8, BOD, NO. 042)
- Seat Belt Replacement Guide (VOL. 8, BOD, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- TOYOTA Locking Clip For Child Restraint Seats (VOL. 7, BOD, NO. 001)
- Adjustment Of New Headrests (BO91-010)
- Rear Seat 3-Point Belts - Availability/Installation (VOL. 9, BOD, NO. 011)
- Seat Belt Extenders Availability (BO93-006)
- Wire Type Window REGUALTOR Assembly - New Part (BO94-015)
Solar Ventilation
- Avoiding A/C Compressor Failure: Lube Oil REQTS. (AC93-005)
- A/C Service - Evacuation Procedure Revision (VOL. 10, A/C, NO. 007)
- A/C Not Cooling - REPL A/C Compressor Line O-Rings (VOL. 8, ACC, NO. 003)
Starter
- MIDTRONICS Battery Tester Software Update (SS002-02)
- Battery Maintenance For In-Stock Vehicles - Info (EL95-001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Steering Column
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Steering Column Switches
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Steering Control Systems
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
Steering Gear
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Steering Linkage
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Sun Roof/T-Top/Convertible Top
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- Adjustment Of New Headrests (BO91-010)
Suspension Control Systems
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
System
- Sulfur Odor From Exhaust (EG003-03)
- Emission Control Label OREDERING Information (PG95-005)
- Signal Generator Resistance Specifications (EN91-007)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Sulphur Odor From Exhaust Emission (VOL. 7, EMS, NO. 001)
- TOYOTA Silicone Formed In Place Gasket For Oil Pans (VOL. 7, ENG, NO. 011)
- 1983 New Car Pre-Delivery Service (VOL. 7, PGI, NO. 001)
Towing
- Emergency Tow Procedures - All Models (VOL. 10, PGI, NO. 035)
Transfer Case
- Revised Drive Shaft Grease (TC002-99)
Transmission Control Systems
- Torque Converter To FLEXPLATE Mounting Bolt Warnings (VOL. 10, TRN, NO. 036)
- A13/A24 Series & A140 Trans Harsh 2-3 Shift Hot/Cold (VOL. 10, TRN, NO. 025)
Vacuum Pumps/Lines/Tanks/Water Trap
- TOYOTA Silicone Formed In Place Gasket For Oil Pans (VOL. 7, ENG, NO. 011)
- Correct Oil Filter Replacement Procedure (VOL. 7, ENG, NO. 009)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Wheel Alignment
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
Wheels & Tire System
- Wheel Balance Adapter Kit (SU002-96 REV)
- Steering Wobble - New Strut Bar Bushing (VOL. 7, SUS, NO. 002)
- Aluminum Disc Wheel Clear Coating (VOL. 7, AXL, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Window Motors & Regulators
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Urethane Adhesive Sealant For Fixed Glass Install (VOL. 8, BOD, NO. 032)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
- Adjustment Of New Headrests (BO91-010)
- Wire Type Window REGUALTOR Assembly - New Part (BO94-015)
Wiper/Washer Systems
- Wiper Linkage Improvement - New Ball Socket Joint (VOL. 9, BOD, NO. 001)
- Vehicle Vibration Table/Repair Guide (VOL. 7, NVH, NO. 001)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wire Harness Repair Kit "B": New Tool (SS94-002)
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Radio Antenna Feeder Cable (VOL. 8, ACC, NO. 020)
- New Corrosion Resistant Fuel Sender Wiring Connector (VOL. 7, ELC, NO. 005)