Technical Service Bulletins

A/C Compressor
- Campaign 83 - Inspect/Replace Leaking A/C Compressor (GROUP 87, NO. 0010)
Accessories & Equipment
- Gloves For High Voltage Battery (33644.1.0)
- VIDA Hardware, Subscription, Infrastructure Requirements (SMB00-261 REV)
Accessories Control Systems
- Control Module Swapping (TJ 31946.1.2)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- IMMO Failure In Cable Terminals, Start Prevented, DTC 233, 234, 321 (RTJ 4523)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- Rear Windshield, Alarm Wire, Repair (36-0019)
- Immobilizer Terminals, Intermittent No Start (36-0015)
- Rear Window Defroster, Repair (GROUP 84, NO. 0014)
- Supplement To Service Manual 8(87)/ECC Module Update (GROUP 87, NO. 0013)
- Supplementing Service Manual 8(87)/ECC Module Update (GROUP 87, NO. 0012)
Air Bag, SRS
- R10058/R10125/R10136 Driver Airbag Returns - Shipping Instruction (SMB88-010)
- R10058 Driver Airbag Returns - Shipping Instruction (PB88-010)
- Used Airbag Return/Disposal Pilot Program (SMB88-026)
- Extended Supplemental Restraint System (SRS) Lifetime (88-41)
- Campaign No. 96 - Passenger Air Bag SRS (GROUP 88, NO. 0016)
- New Tool For Fault-Tracing In Passenger Airbag (GROUP 88, NO. 824)
Anti-Lock Brakes
- New Tool To Install Abs Sensor Wheel (STB 109)
Anti-Theft Systems
- IMMO Failure In Cable Terminals, Start Prevented, DTC 233, 234, 321 (RTJ 4523)
- Rear Windshield, Alarm Wire, Repair (36-0019)
- Immobilizer Terminals, Intermittent No Start (36-0015)
- Door Lock, Installation Of Protective Cover (GROUP 83, NO. 0032)
- Sill Trim Panel, Paint Protection (GROUP 84, NO. 0025)
- Tailgate Handle - Moisture In License Plate Light (GROUP 83, NO. 0011)
- Door Handle - Improved Cold Climate Operation (GROUP 83, NO. 0001)
- Corrective Action For Wind Draft - Inner Door Opener (GROUP 83, NO. 827)
- VGLA Remote Control, Tailgate Button Sensitive (GROUP 36, NO. 0001)
- Replacing Tailgate Lock Mechanism & Lock Button (GROUP 83, NO. 825)
- Instructions For Programming Alarm (GROUP 83, NO. 826)
- Modifying Tailgate When Replacing (GROUP 83, NO. 823)
Automatic Trans
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Transmission Serial Number Records When Replacing Transmission Components (RTJ 22900)
- Automatic Transmission Cooler/Lines Flushing (TJ19495)
- Automatic Transmission Cooler/Lines Flushing (RTJ 19495)
- Retailer Technical Journal 16724 Coolant Contamination In Automatic Transmissions (43-48)
- Automatic Transmission Cooler/Lines Flushing (43-56)
- Automatic Transmission Diagnostic Sheet (43-08)
- CANBUS Network Information (RTJ 16386)
- Transmission And AWD Lubricants (40-04)
- Automatic Transmission Aw 50-42, Hard Lockup Engagement And Disengagement. (GROUP 43, NO. 0029)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
- New Gear Selector Assembly For Automatic Trans (GROUP 43, NO. 816)
Auxiliary Emission Control Systems
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
- Cancellation Of Bulletin 23-0059 Dated July 2002 (GROUP 23, NO. 0059)
- Establishing Readiness For OBD II (GROUP 23, NO. 0056)
- New Routing Of Wiring For O2 Sensors (25-0010)
- New Routing Of Wiring For O2 Sensors (GROUP 25, NO. 0010)
- M 4.4 Software Upgrade (GROUP 28, NO. 0003)
- Updated Users Manual - Flash Programming Equipment (GROUP 28, NO. 0006)
- Service CAMPAIGB 87 - Emission Label (GROUP 89, NO. 0001)
- Vehicle Emission Control Information Label (GROUP 89, NO. 87)
- Diagnosing Fault Codes EF-611, EFI-612 (GROUP 23, NO. 0007)
- MOTRONIC 4.4 Onboard Refueling Vapor Recovery (GROUP 23, NO. 0006)
- Engine Management System Reference Chart (GROUP 00, NO. 106)
Axle Shafts
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Viscous Coupling Housing/Coupling, Rotating Sound (GROUP 46, NO. 0004)
- New Drive Shaft Nut (GROUP 77, NO. 0004)
- Rear Axle/Final Drive, Whining Noise (GROUP 46, NO. 0001)
- Ball Joint/Steering Knuckle, Removing (GROUP 61, NO. 0002)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
Blowers, Superchargers & Turbochargers
- B5254T Engine - Turbo Boost Pressure - Checking/Adj (GROUP 25, NO. 810)
Body Electrical
- B+ Cable, Battery-To-Fuse Box, Replacement (37-0015)
Body Interior
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- CANBUS Network Information (RTJ 16386)
- Rear Windshield, Alarm Wire, Repair (36-0019)
- Supplement To Service Manual 8(87)/ECC Module Update (GROUP 87, NO. 0013)
- Changes In Service Manual Section 8(87) (GROUP 87, NO. 0001)
- Supplement To Service Manual Section 8(87) (GROUP 87, NO. 0002)
- Supplementing Service Manual 8(87)/ECC Module Update (GROUP 87, NO. 0012)
Brakes Control Systems
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- VIDA Upcoming Technology (SMB00-290)
- CANBUS Network Information (RTJ 16386)
- New Tool To Install Abs Sensor Wheel (STB 109)
Charging Systems
- Positive Battery Cable & Alternator Cable Available (GROUP 37, NO. 0001)
Clutch
- Clutch Pedal, Auxiliary Spring (GROUP 41, NO. 0004)
- Campaign No. 92 - Clutch Control Cylinder (GROUP 41, NO. 0006)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
- New & Modified Clutch Tools (GROUP 00, NO. 99-A)
- New Clutch For Turbo Engines (GROUP 41, NO. 807)
Communication Devices
- Control Module Swapping (TJ 31946.1.2)
- VOLVO On Call Plus Activation Procedure Changes (39-53)
Cooling System (Mechanical)
- Fuel Delivery System - Fuel Rail Replacement (GROUP 23, NO. 0018)
Differentials & Drive Axles
- Transmission And AWD Lubricants (40-04)
- Viscous Coupling Housing/Coupling, Rotating Sound (GROUP 46, NO. 0004)
- New Drive Shaft Nut (GROUP 77, NO. 0004)
- Viscous Coupling Housing / Viscous Coupling, Rotating (46-0004)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
Driveshaft & Universal Joints
- Updated Procedure, Propeller Shaft, Removal/Installation (TJ19917)
- Viscous Coupling Housing/Coupling, Rotating Sound (GROUP 46, NO. 0004)
- New Drive Shaft Nut (GROUP 77, NO. 0004)
- Rear Axle/Final Drive, Whining Noise (GROUP 46, NO. 0001)
- New V70 AWD Tools For Propeller Shaft Flanges (STB NO. 100-C)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
Electronic Steering
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
Electronic Suspension
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
Engine Control Systems
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- VIDA Upcoming Technology (SMB00-290)
- Pressure Washing Engines (TJ21507)
- CANBUS Network Information (RTJ 16386)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
- Cancellation Of Bulletin 23-0059 Dated July 2002 (GROUP 23, NO. 0059)
- Establishing Readiness For OBD II (GROUP 23, NO. 0056)
- B+ Cable, Battery-To-Fuse Box, Replacement (37-0015)
- Immobilizer Terminals, Intermittent No Start (36-0015)
- New Routing Of Wiring For O2 Sensors (25-0010)
- New Routing Of Wiring For O2 Sensors (GROUP 25, NO. 0010)
- Fuel Sending Unit, Replacement (GROUP 23, NO. 0046)
- M 4.4 Software Upgrade (GROUP 28, NO. 0003)
- Updated Users Manual - Flash Programming Equipment (GROUP 28, NO. 0006)
- Fuel Cap, Test Equipment (GROUP 23, NO. 0028)
- Engine Management System Reference Chart (GROUP 00, NO. 106)
Entertainment Systems
- Control Module Swapping (TJ 31946.1.2)
- Stuck CDS In Audio Units (All Models) (TNN 39-51)
- Rear Window Defroster, Repair (GROUP 84, NO. 0014)
- VOLVO Compact Disc System (GROUP AUDIO, NO. 1)
- Audio - Central Speaker - Amplifier (GROUP 35, NO. 810)
Exhaust
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
- Cancel Notice / 25-25 (25-25)
- Exhaust System Mounting (25-26)
- New Routing Of Wiring For O2 Sensors (GROUP 25, NO. 0010)
- Recall 89 - Tailpipe Adjustment (RECALL 89)
Exterior Body Panels
- Repairing Tailgate Panel Attachment (GROUP 85, NO. 0004)
- Replacing The Fuel Tank (GROUP 23, NO. 0047)
- Fuel Sending Unit, Replacement (GROUP 23, NO. 0046)
- Fuel Tank EVAP Hoses, Replacement (GROUP 23, NO. 0031)
- Tailgate Opening Angle, Adjusting (GROUP 83, NO. 0009)
- Y-Fitting On Fuel Tank, New Method (GROUP 23, NO. 0026)
- Fuel Cap, Test Equipment (GROUP 23, NO. 0028)
- Fuel Pump Connector, Replacing (GROUP 37, NO. 0002)
- Supplement To Bodywork Methods (GROUP 81, NO. 0001)
- Body Dimension Details - AWD (GROUP 81, NO. 815)
- Replacing Tailgate Lock Mechanism & Lock Button (GROUP 83, NO. 825)
- Modifying Tailgate When Replacing (GROUP 83, NO. 823)
Exterior Lights
- Campaign No. 94 - Headlight Switch (GROUP 36, NO. 0014)
- Headlamp, Support Bracket (GROUP 35, NO. 0004)
- Turn Signal Lens Condensation (GROUP 35, NO. 0006)
- Tailgate Handle - Moisture In License Plate Light (GROUP 83, NO. 0011)
Frames, Subframes & Crossmembers
- Jack Attachment Point - Adapting Brake Line ATTACHME (GROUP 81, NO. 0003)
- Mud Guard, Rear Jacking Point (GROUP 81, NO. 0002)
- Supplement To Bodywork Methods (GROUP 81, NO. 0001)
- Body Dimension Details - AWD (GROUP 81, NO. 815)
- Installing Support For Rear Bumpers (GROUP 86, NO. 0001)
- Body & Glass - New Bumper Mounting & Quarter Window (GROUP 81, NO. 811)
Front Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Rear Suspension, Squeaking Noise (GROUP 72, NO. 0001)
- Ball Joint/Steering Knuckle, Removing (GROUP 61, NO. 0002)
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
- Wheel Imbalance Due To Snow - Accessory Bracket/Lug (GROUP 65, NO. 802)
Fuel System
- E10 Petrol Fuel Requirements (SMB23-035)
- E10 Petrol Fuel Requirements (RTJ 24461)
- Connecting The Quick Release Connector, Updated Method (GROUP 23, NO. 0052)
- Replacing The Fuel Tank (GROUP 23, NO. 0047)
- Fuel Sending Unit, Replacement (GROUP 23, NO. 0046)
- Fuel Tank EVAP Hoses, Replacement (GROUP 23, NO. 0031)
- Y-Fitting On Fuel Tank, New Method (GROUP 23, NO. 0026)
- Fuel Cap, Test Equipment (GROUP 23, NO. 0028)
- Fuel Pump Connector, Replacing (GROUP 37, NO. 0002)
- INTERCOOLER, Installing Nipple (GROUP 26, NO. 0002)
Fuses & Circuit Breakers
- B+ Cable, Battery-To-Fuse Box, Replacement (37-0015)
- New Routing Of Wiring For O2 Sensors (GROUP 25, NO. 0010)
- Modified Wiring Diagram For Power Seats (GROUP 39, NO. 0003)
- Campaign No. 96 - Passenger Air Bag SRS (GROUP 88, NO. 0016)
- Fuel Pump Connector, Replacing (GROUP 37, NO. 0002)
- Positive Battery Cable & Alternator Cable Available (GROUP 37, NO. 0001)
Gauges & Instrument Panels
- Campaign 83A/B - Front Panel-MCC, Removing Diode Kit (GROUP 87, NO. 0009)
Headlights
- Digital Head Light Instrument For L.E.D., Halogen, Xenon Vehicles (32242.3.0)
- Campaign No. 94 - Headlight Switch (GROUP 36, NO. 0014)
- Headlamp, Support Bracket (GROUP 35, NO. 0004)
- Turn Signal Lens Condensation (GROUP 35, NO. 0006)
Heated Glass/Defoggers
- Rear Window Defroster, Repair (GROUP 84, NO. 0014)
HVAC Control Systems
- Animation: Evaporator Climate Unit, Cleaning (SPJ32811.2.0)
- Retailer Technical Journal 19292 Climate Control System, Cleaning (TJ 19292)
- Service Campaign 83A/B - MCC Panel Interferes A/C (GROUP 87, NO. 83A/B)
- Campaign 83 - Inspect/Replace Leaking A/C Compressor (GROUP 87, NO. 0010)
- Campaign 83A/B - Front Panel-MCC, Removing Diode Kit (GROUP 87, NO. 0009)
- Installation Of Evaporator Dryer To Avoid Odor (GROUP 87, NO. 836)
Identification
- Vehicle Type And Platform Identification (TJ19245.1.19)
- Expendable Items Parts List (SMB00-108D)
- New Shipping Address And Label (SMB00-012)
- VIN Plate And VIN Specific Labeling Ordering Procedure (SMB89-005)
- Transmission Serial Number Records When Replacing Transmission Components (RTJ 22900)
- VOLVO Model Designations (00-20.A)
- Service CAMPAIGB 87 - Emission Label (GROUP 89, NO. 0001)
- Vehicle Emission Control Information Label (GROUP 89, NO. 87)
Ignition Switch/Steering Lock
- Replacing The Steering Wheel Lock (GROUP 64, NO. 0011)
- Service Campaign 83 - Ignition Switch Replacement (GROUP 33, NO. 0002)
Ignition System
- Fuel Delivery System - Fuel Rail Replacement (GROUP 23, NO. 0018)
Infotainment
- Control Module Swapping (TJ 31946.1.2)
- Map Upgrade Warranty Policy (SMB00-427)
- GARMIN® 765 Power Issue And SW Updates (TJ21291)
Interior/Exterior Trim
- PUR Bonded Windows, New Adhesive Kit (84-0033)
- Door Panel, Bonding Adjustment (GROUP 85, NO. 0027)
- Door Panel Insert, Replacement (85-0015)
- Rails & Load Arches, Modification (GROUP 84, NO. 0013)
- Windshield Moulding, Upper, Noise (GROUP 84, NO. 0024)
- Door Opener Bezel, Removing (GROUP 83, NO. 0004)
- Replacing Power Window Switch(S) (GROUP 36, NO. 0011)
- Door Handle - Improved Cold Climate Operation (GROUP 83, NO. 0001)
- Replacing Loose Dashboard Seals (GROUP 88, NO. 0004)
- Corrective Action For Wind Draft - Inner Door Opener (GROUP 83, NO. 827)
- Body & Glass - New Bumper Mounting & Quarter Window (GROUP 81, NO. 811)
- Correction In Service Manual - Securing Badge (GROUP 84, NO. 820X)
- New Gear Selector Assembly For Automatic Trans (GROUP 43, NO. 816)
Interior/Illumination Lights
- Campaign No. 94 - Headlight Switch (GROUP 36, NO. 0014)
- Headlamp, Support Bracket (GROUP 35, NO. 0004)
- Turn Signal Lens Condensation (GROUP 35, NO. 0006)
Locking Hubs
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
Lubrication System
- Expendable Items Parts List (SMB00-108D)
- Engine Oil Consumption Test FAQ (SMB22-006)
- Required Engine Oils (7,500 Miles/12,000 Km Intervals) (SMB22-003)
- Oil Pump Attachment Screws, Copper Washer Installation (GROUP 21, NO. 0023)
- Recommended Engine Oils (GROUP 22, NO. 3)
- Fuel Delivery System - Fuel Rail Replacement (GROUP 23, NO. 0018)
Manual Steering
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
Manual Trans
- Transmission And AWD Lubricants (40-04)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
- New M56 Transmission Tools - 9995687-2 & 9995688-0 (NO. 71-B)
Mechanical
- VOLVO Engine Oil Consumption (SMB22-007)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Required Engine Oils (7,500 Miles/12,000 Km Intervals) (SMB22-003)
- Pressure Washing Engines (TJ21507)
- Piston Rings, Replacing (21-0050)
- Rear Crankshaft Seal, Replacing (SB21-0049-0403)
- Oil Pump Attachment Screws, Copper Washer Installation (GROUP 21, NO. 0023)
- Connecting The Quick Release Connector, Updated Method (GROUP 23, NO. 0052)
- Adjusting Mechanical Camshaft Belt TENSIONER (GROUP 21, NO. 0015)
- INTERCOOLER, Installing Nipple (GROUP 26, NO. 0002)
- Oil Pan Front Edge Screws (GROUP 21, NO. 0014)
- New Tappets (Valve Depressors) (GROUP 21, NO. 0009)
- Amended Procedure For Compression Test (GROUP 21, NO. 842)
- Fuel Delivery System - Fuel Rail Replacement (GROUP 23, NO. 0018)
- CAMSHFT Housing Cover Removal (GROUP 21, NO. 823)
- Crankshaft Rear Seal Tool (STB 107)
Mechanical - Hydraulic
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Improved Front Pads For 800 Series Cars With 15" Brakes (RTJ 24800)
- Jack Attachment Point - Adapting Brake Line ATTACHME (GROUP 81, NO. 0003)
- Installing Clamp On Vacuum Hose Under Air Cleaner (GROUP 52, NO. 0001)
- Brake Hose AWD, New Spare Part (GROUP 52, NO. 0005)
Memory Modules
- Control Module Swapping (TJ 31946.1.2)
Mirrors
- Modified Wiring Diagram For Power Seats (GROUP 39, NO. 0003)
- Replacing Power Window Switch(S) (GROUP 36, NO. 0011)
Paint & Coatings
- Polishing New Vehicles When Necessary (TJ20089)
- Sill Trim Panel, Paint Protection (GROUP 84, NO. 0025)
- Corrective Action For Wind Draft - Inner Door Opener (GROUP 83, NO. 827)
Passive Restraints
- Seat Belt Extender - 850, 900, S90, V90, V90CC, S/V40, V50, S/V60, V60CC, S/V70, XC70, C30, C70, S80, XC40, XC60, XC90 (SMB88-001A)
- Electrically Operated Seat, Minimizing Lateral Movement (GROUP 85, NO. 0013)
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
Procedures
- Data Requests From Lea (Police) And/Or Customers (TJ 28941.5.0)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- High Voltage (HV) Module Balancer Cart (ST-251)
- VIDA Updated Graphical Plotter Functionality Applications - VIDA (SJ1000785)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Newsletter 105: Mandatory Tools (ST-237)
- Recall Compliance Clearance Letter Requests (SMB00-440)
- GDPR - Information Notice (SPJ34864.2.0)
- Not Possible To Left Click Ecus In The Network Image For Non-Spa Cars (US34753.1.0 EN-US)
Rear Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Rear Suspension, Squeaking Noise (GROUP 72, NO. 0001)
- Ball Joint/Steering Knuckle, Removing (GROUP 61, NO. 0002)
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
- Wheel Imbalance Due To Snow - Accessory Bracket/Lug (GROUP 65, NO. 802)
Restraints Control Systems
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- VIDA Upcoming Technology (SMB00-290)
- CANBUS Network Information (RTJ 16386)
- Supplement To Service Manual 8(87)/ECC Module Update (GROUP 87, NO. 0013)
- New Tool For Fault-Tracing In Passenger Airbag (GROUP 88, NO. 824)
- Supplementing Service Manual 8(87)/ECC Module Update (GROUP 87, NO. 0012)
Seats
- Interior Seat Protection Kit (SMB85-002)
- Electrically Operated Seat, Minimizing Lateral Movement (GROUP 85, NO. 0013)
- Modified Wiring Diagram For Power Seats (GROUP 39, NO. 0003)
- Front Seat, Height Adjuster Knob (GROUP 85, NO. 0007)
- Replacing Power Window Switch(S) (GROUP 36, NO. 0011)
- Seat Belt Extender Availability (GROUP 88, NO. 1A)
Starter
- Spare Part Battery Date Codes (SMB31-003)
- Safety Precautions When Working With Lead Acid Batteries (RTJ 24188)
- B+ Cable, Battery-To-Fuse Box, Replacement (37-0015)
- Positive Battery Cable & Alternator Cable Available (GROUP 37, NO. 0001)
- Fuel Delivery System - Fuel Rail Replacement (GROUP 23, NO. 0018)
- Digital Battery Analyzer (STB 111)
Steering Column
- Interior Seat Protection Kit (SMB85-002)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Lower Steering Shaft Joint Replacement (64-29)
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
- Steering Column Knocking/Grinding Sound (GROUP 64, NO. 0006)
- Removal & Installation Of Steering Column (GROUP 64, NO. 823)
Steering Control Systems
- Control Module Swapping (TJ 31946.1.2)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- CANBUS Network Information (RTJ 16386)
Steering Gear
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
Steering Linkage
- Ball Joint/Steering Knuckle, Removing (GROUP 61, NO. 0002)
- Installing Rear Shock Absorber Bearing (GROUP 76, NO. 0002)
Sun Roof/T-Top/Convertible Top
- Door Handle - Improved Cold Climate Operation (GROUP 83, NO. 0001)
Suspension Control Systems
- Control Module Swapping (TJ 31946.1.2)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- CANBUS Network Information (RTJ 16386)
System
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- E10 Petrol Fuel Requirements (RTJ 24461)
- IMMO Failure In Cable Terminals, Start Prevented, DTC 233, 234, 321 (RTJ 4523)
- Pressure Washing Engines (TJ21507)
- CANBUS Network Information (RTJ 16386)
- VCT 2000 (9511500 And 9511540) And Cable 9511535 Troubleshooting, Firmware Upgrade, VCT 2000 Recovery (30-05)
- Cancellation Of Bulletin 23-0059 Dated July 2002 (GROUP 23, NO. 0059)
- Establishing Readiness For OBD II (GROUP 23, NO. 0056)
- B+ Cable, Battery-To-Fuse Box, Replacement (37-0015)
- Immobilizer Terminals, Intermittent No Start (36-0015)
- New Routing Of Wiring For O2 Sensors (25-0010)
- New Routing Of Wiring For O2 Sensors (GROUP 25, NO. 0010)
- Replacing The Fuel Tank (GROUP 23, NO. 0047)
- Fuel Sending Unit, Replacement (GROUP 23, NO. 0046)
- Fuel Tank EVAP Hoses, Replacement (GROUP 23, NO. 0031)
- M 4.4 Software Upgrade (GROUP 28, NO. 0003)
- Updated Users Manual - Flash Programming Equipment (GROUP 28, NO. 0006)
- Y-Fitting On Fuel Tank, New Method (GROUP 23, NO. 0026)
- Fuel Cap, Test Equipment (GROUP 23, NO. 0028)
- Fuel Pump Connector, Replacing (GROUP 37, NO. 0002)
- INTERCOOLER, Installing Nipple (GROUP 26, NO. 0002)
- Service CAMPAIGB 87 - Emission Label (GROUP 89, NO. 0001)
- Vehicle Emission Control Information Label (GROUP 89, NO. 87)
- B5254T Engine - Turbo Boost Pressure - Checking/Adj (GROUP 25, NO. 810)
- Fuel Delivery System - Fuel Rail Replacement (GROUP 23, NO. 0018)
- Diagnosing Fault Codes EF-611, EFI-612 (GROUP 23, NO. 0007)
- MOTRONIC 4.4 Onboard Refueling Vapor Recovery (GROUP 23, NO. 0006)
- Engine Management System Reference Chart (GROUP 00, NO. 106)
Transfer Case
- Bevel Gear Oil, Replacement (GROUP 43, NO. 0004)
- Viscous Coupling Housing / Viscous Coupling, Rotating (46-0004)
- Whining Sound From The Transmissions Final Drive (GROUP 43, NO. 0005)
Transmission Control Systems
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- VIDA Upcoming Technology (SMB00-290)
- CANBUS Network Information (RTJ 16386)
- MIDTRONICS PSC-550 Vehicle Power Supply Use Required During Software Download. Includes Mobile Technician Program (30-04)
Wheel Alignment
- Retailer Technical Journal 19674 Wheel Alignment Specifications (TJ19674)
- Alignments: 'BEFORE' And 'AFTER' Measurements Required (60-09)
Wheels & Tire System
- VOLVO Wheel Repair Guidelines (SMB77-008)
- Winter Wheel Applications (PB77-006)
- VOLVO Recommended Winter Tires (77-013)
- Tire Rotation (SMB77-007)
- Tire Pressures, Requirements And Recommendations (77-18)
- AWD Wheels/Tires, Information & Function Test (GROUP 46, NO. 0005)
- Ball Joint/Steering Knuckle, Removing (GROUP 61, NO. 0002)
- Wheel Imbalance Due To Snow - Accessory Bracket/Lug (GROUP 65, NO. 802)
Window Motors & Regulators
- Windshield Cleaning (SMB00-444)
- Windshield POWERCURE Dispenser And Adhesive (SMB84-001)
- PUR Bonded Windows, New Adhesive Kit (84-0033)
- Rear Windshield, Alarm Wire, Repair (36-0019)
- Modified Wiring Diagram For Power Seats (GROUP 39, NO. 0003)
- Tailgate Opening Angle, Adjusting (GROUP 83, NO. 0009)
- Windshield Moulding, Upper, Noise (GROUP 84, NO. 0024)
- Windshield, New Type (GROUP 84, NO. 0006)
- Replacing Power Window Switch(S) (GROUP 36, NO. 0011)
- Door Handle - Improved Cold Climate Operation (GROUP 83, NO. 0001)
- Replacing Tailgate Lock Mechanism & Lock Button (GROUP 83, NO. 825)
- Modifying Tailgate When Replacing (GROUP 83, NO. 823)
Wiper/Washer Systems
- Adjusting Wiper Arm (36-0022)
- Rear Windshield, Alarm Wire, Repair (36-0019)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- B+ Cable, Battery-To-Fuse Box, Replacement (37-0015)
- New Routing Of Wiring For O2 Sensors (GROUP 25, NO. 0010)
- Modified Wiring Diagram For Power Seats (GROUP 39, NO. 0003)
- Campaign No. 96 - Passenger Air Bag SRS (GROUP 88, NO. 0016)
- Fuel Pump Connector, Replacing (GROUP 37, NO. 0002)
- Positive Battery Cable & Alternator Cable Available (GROUP 37, NO. 0001)