Bulbs, Control Modules, Charging - Design And Function

• Climate Control Module (CCM) (2005-2007)
  • Diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off input and output signals
    • Reading off extended fault-tracing information
    • Programming the climate control module (CCM), customer adaptation
    • Identifying the damper motors
    • Calibration of climate control module (CCM)
  • Downloading software and replacing the control module
  • Function
    • Controlling the climate in the passenger compartment
    • Regulating seat heat
    • Recirculation control (electronic climate control only)
    • Heated rear windshield and door mirrors
    • Switch functions, dashboard environment panel, (lower section)
  • System overview
    • Control module
    • Signals
• Combustion PREHEATER Module (CPM) (2005-2007)
  • Information
    • General
• Control Module For The Steering Wheel Angle Sensor (2001-2004)
  • Design
    • Control module for the steering wheel angle sensor
    • Steering wheel angle sensor
  • Function
  • SAS diagnostic functions
    • Notes
    • Description of parameters (steering angle sensor)
      • Introduction / status
        • Introduction
        • Steering wheel angle
        • LED IY status
        • LED IX status
        • LED A status
        • LED B status
        • LED R1 status
        • LED R2 status
        • LED R3 status
        • LED R4 status
        • Power supply, steering wheel angle sensor module (SAS)
        • Power supply, central electronic module (CEM)
        • LED circuit 1 status
        • LED circuit 2 status
        • Signal voltage, signal A
        • Signal voltage, signal B
        • LED circuit 1 current
        • LED circuit 2 current
  • Software downloading
  • System overview
    • Control module
    • Signals for the control module for the steering wheel angle sensor
• DENSO Engine Management System (B5244S; 2001-2002)
  • Design
    • Ignition switch
    • Brake lamp switch
    • brake pedal position switch
    • Accelerator pedal (AP) position sensor
    • Clutch pedal position sensor (manual transmissions only)
    • Electronic throttle unit
    • Electronically controlled throttle system
    • Air conditioning (A/C) compressor
    • Heated oxygen sensors (HO2S)
    • Engine coolant temperature (ECT) sensor
    • Engine cooling fan (FC) / engine cooling fan (FC) control module
    • Mass air flow (MAF) sensor
    • Outside temperature sensor
    • Engine speed (RPM) sensor
    • Camshaft position (CMP) sensor
    • Knock sensor (KS)
    • Engine coolant level sensor
    • Main relay (system relay)
    • Air conditioning (A/C) relay
    • Fuel pump (FP) relay
    • Air distribution valve
    • Injectors
    • Evaporative emission system (EVAP) valve
    • Camshaft reset valve (Continuous variable valve timing (CVVT))
    • Ignition coils
    • Emissions warning lamp
    • Manifold absolute pressure (MAP) sensor
    • Fuel tank pressure sensor (certain markets only)
    • EVAP canister shut-off valve (certain markets only)
  • Diagnostic functions
    • Throttle diagnostics
    • Misfire diagnostic
    • Heated oxygen sensor (HO2S) diagnostic
    • Three-way catalytic converter (TWC) diagnostic
    • Leak diagnostic
    • Throttle diagnostic
  • Downloading software and replacing the control module
  • Function
    • Camshaft control (CVVT)
    • Knock control
    • Ignition control
    • Cruise control
    • Air Flow Adaptation (Turbo Only)
    • Air Leakage Flow Via Throttle Unit
  • System overview
    • Control module
    • Signals
• Diagnosis (2001-2007)
  • Background
    • General
    • Legal requirements emissions
  • Diagnostic versions and communication methods
    • General
    • Volvo Diagnostics I - first version
    • Volvo Diagnostics I - second version
    • Non-standardized serial communication
    • Volvo Diagnostics II - first version
    • Volvo Diagnostics II - second version
    • Generic Global Diagnostics (GGD)
  • Diagnostics and services
    • General
    • Diagnostic trouble codes (malfunction indicator)
    • Parameters
    • Activations
    • Quick-tests, calibrations
    • Software downloading
    • Erasing diagnostic trouble codes
    • Driving cycle/operation cycle
    • Readiness Monitor (certain markets only)
    • Frozen values
    • Emergency mode, back-up mode "Limp-home"
    • Designation of trouble codes
    • Conditions for diagnosis to find a malfunction
    • Classification of diagnostic trouble codes
    • Counter
      • General
      • Counter Volvo Diagnostics II
      • Counter Generic Global Diagnostics (GGD)
    • Status identifier
      • General
      • Status identifier Volvo Diagnostics II
      • Status identifier Generic Global Diagnostics (GGD)
  • Introduction
  • Practical use of diagnostics
    • General
    • To decide the intensity of a malfunction
    • To decide diagnostic trouble code test's status
    • To decide operation conditions when the malfunction was detected
  • Tools for diagnostics
    • General
    • Tools for Off Board Diagnostics
    • Tools for On Board Diagnostics
  • Where do I find the information in VIDA
    • General
    • Counter, status identifier and frozen values
    • Parameters
    • Activations, Quick-tests
• Differential Electronic Module (DEM) (Aw50/51 AWD; M66 AWD; 2005-2007)
  • Design
  • Diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off input and output signals
    • Reading off the control module identification
  • Downloading software and replacing the control module
  • Function
  • System overview
• Differential Electronic Module (DEM) (TF-80SC AWD; 2006-2007)
  • Design
  • Diagnostic functions
  • Downloading software and replacing the control module
  • Function
  • System overview
• Driver Door Module (DDM) And Passenger Door Module (PDM) (2001-2007)
  • Design
    • The door lock
    • The power window mechanism
    • Door mirror
    • Door open warning lamp
  • Diagnostic functions
    • Driver's door module
    • Passenger door module (PDM)
    • Diagnostic functions, passenger door module (PDM)
      • General
      • Diagnostic trouble codes (DTCs)
      • Reading and erasing diagnostic trouble codes (DTCs)
      • Reading off input and output signals
      • Activating components and functions
      • Reading off and programming data
      • Reading off the control module identification
    • Diagnostic functions, driver's door module (DDM)
      • General
      • Diagnostic trouble codes (DTCs)
      • Reading and erasing diagnostic trouble codes (DTCs)
      • Reading off input and output signals
      • Activating components and functions
      • Reading off and programming data
      • Reading off the control module identification
  • Downloading software and replacing the control module
  • Function
    • Central locking
    • Operating windows
    • Functions in the door mirrors
    • Door open warning lamp
  • System overview
    • Control module
    • Signals
• Driver Information Module (2001)
  • Diagnostic functions in the combined instrument panel
    • Description of the scrolling values (lamps)
    • Description of the scrolling values (other signals)
    • Description of the customer parameters in the combined instrument panel (driver information module)
    • Description of component / function activation
  • Downloading software and replacing the control module
  • Function
    • Text messages
    • Outside temperature
    • Clock
    • Seat belt reminder
    • Trip odometer / odometer
    • Service reminder indicator (SRI)
    • Engine coolant temperature (ECT) gauge
    • Handbrake
    • SRS lamp
    • Brake warning lamp
    • Fuel gauge
    • Speedometer
    • Tachometer
    • Lamp for low oil pressure (only applies to versions with oil pressure sensor)
    • General warning lamp
    • Malfunction indicator lamp (MIL)
  • System overview
    • Control module
    • Signals
• Driver Information Module (Dim). (2002-2007)
  • Design
    • Illumination in Driver Information Module (DIM)
  • Diagnostic functions
    • Description of the scrolling values (lamps)
    • Description of the scrolling values (other signals)
    • Description of the customer parameters in the driver information module (DIM)
    • Description of component / function activation
  • Downloading software and replacing the control module
  • Function
  • System overview
• Engine Control Module (ECM) (B5244S; 2003-2007)
  • Design
    • Ignition switch
    • Immobilizer
    • Oil pressure sensor
    • Fuel pump control module (only vehicles with demand controlled fuel pumps)
    • Fuel pump (only vehicles with demand controlled fuel pumps)
    • Brake light switch
    • Clutch pedal sensor (manual transmissions only)
    • Air conditioning (A/C) compressor
    • Heated oxygen sensors (HO2S)
    • Engine coolant temperature (ECT) sensor
    • Engine cooling fan (FC) control module
    • Cooling fan for control modules
    • Mass air flow (MAF) sensor with integrated temperature sensor
    • Manifold absolute pressure (MAP) sensor
    • Leak diagnostic unit (certain markets only)
    • Outside temperature sensor
    • Engine speed (RPM) sensor
    • Camshaft position (CMP) sensor
    • Knock sensor (KS)
    • Electronic throttle unit
    • Throttle position (TP) sensor
    • Accelerator pedal (AP) position sensor
    • Engine coolant level sensor
    • Fuel pressure sensor / fuel temperature sensor (only vehicles with demand controlled fuel pumps)
    • Oil level sensor (2005-, certain markets only)
    • Main relay (system relay)
    • Air conditioning (A/C) relay
    • Injectors
    • Evaporative emission system (EVAP) valve
    • Camshaft reset valve (Continuous variable valve timing (CVVT))
    • Ignition coils
    • Emissions warning lamp
  • Diagnostic functions
    • Overview
      • Overview
      • General
      • Conditions for diagnosis
      • Emission-related diagnostic functions
      • Diagnostic trouble code memory
      • Substitute value
      • Lighting the malfunction indicator lamp (MIL)
    • Misfire diagnostics
      • Overview
      • Misfiring
      • Diagnostics
      • Diagnostic trouble code (DTC) management
      • Misfire affecting emission levels
      • Catalytic converter damage
    • Camshaft diagnostics (CVVT)
    • Leak diagnostics (only certain markets)
    • Heated oxygen sensor diagnostics
    • Three-way catalytic converter (TWC) diagnostics
    • Fuel pressure control, diagnostics (2003-2004 only certain markets, 2005-)
    • Fuel pressure control, diagnostics
    • Leak diagnostic
  • Downloading software and replacing the control module
  • Function
    • Camshaft control (CVVT)
    • Knock control
    • Ignition control
    • Regulating the cruise control
    • Oil monitoring (2005-, certain markets only)
    • Fuel trim
    • Fuel pressure regulation (only vehicles with demand controlled fuel pumps)
  • System overview
    • Control module
    • Signals
• Engine Control Module (ECM) (B5244S6; 2003-2006)
  • Design
  • Diagnostic functions
  • Downloading software and replacing the control module
  • Function
  • System overview
• GDL Bulbs (2002-2004)
  • Design
    • Headlamp system, Bi-Xenon
    • Bulb
    • Ballast
  • Function
    • Headlamps, Bi-Xenon
    • Lighting the headlamp
    • Combined high and low beam
    • Automatic level control
    • Safety
    • High voltage unit
  • System overview
    • Headlamps, Bi-Xenon
    • Control
• GDL Bulbs (2005-2007)
  • Design
    • Bi-Xenon headlight system
    • Lamp
    • Ballast
  • Function
    • Bi-Xenon headlights
    • Lighting the lamp
    • Combined high and low beam
    • Automatic level control
    • Safety
    • High voltage unit
  • System overview
    • Bi-Xenon headlights
    • Control
• Generator (Gen) (2001-2004)
  • Design
    • Generator (GEN) design
    • Stator
    • Rotor with slip rings
    • Cooling fans
    • Rectifier
    • Charge regulator
    • Freewheel
  • Function
    • Charging
  • System overview
    • General
• Generator (Gen) (2005-2007)
  • Design
    • Generator (GEN) design
    • Alternator structure, engine B8444S
    • Stator
    • Rotor with slip rings
    • Cooling fans
    • Rectifier
    • Charge regulator (Alternator control module (ACM))
    • Freewheel
  • Function
    • General
    • Charging
    • Current limiting
  • System overview
    • General
• Headlight Control Module (HCM) (2007)
  • Design
    • Left headlight control unit (LHCU) / right headlight control unit (RHCU)
  • Diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off input and output signals
    • Activating components
    • Reading off the control module identification
  • Downloading software and replacing the control module
  • Function
    • Active headlights
    • Shift light beam and limit active control for right-hand/left-hand traffic ("tourist mode")
  • System overview
    • Control module
    • Signals
• Immobilizer (2005-2007)
  • Design
    • General
    • Central electronic module (CEM)
    • Antenna ring
    • Ignition key
    • Engine control module (ECM)
    • Driver information module (DIM)
  • Diagnostic functions
    • General
    • Programming
    • Programming ignition keys
  • Function
    • The immobilizer system
    • Error message in the Driver information module (DIM).
  • System overview
    • General
    • Signals
• Immobilizer (2001-2004)
  • Design
    • General
    • Central electronic module (CEM)
    • Antenna ring
    • Ignition key
    • Engine control module (ECM)
    • Driver information module (DIM)
  • Diagnostic functions
    • General
    • Programming
    • Programming ignition keys
  • Function
    • The immobilizer system
    • Error message in the Driver information module (DIM).
  • System overview
    • General
    • Signals
• Lin - Local Interconnect Network (2001-2007)
  • Control modules that communicate via LIN
  • Error management in the Local Interconnect Network (LIN)
    • Electrical faults
    • Communication failure
    • Faults discovered by slave nodes
    • Software downloading
  • LIN (Local Interconnect Network)
    • General
    • Wiring
    • LIN message
  • Network
    • General
    • Advantages of a network
  • Network structure
    • General
    • Terminating resistor
• Phone Module (PHM) (2001-2007)
  • Design
    • Carphone antenna/GPS antenna
    • Handset
    • Handsfree equipment
  • Diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off the control module identification
    • Reading off extended diagnostic trouble code (DTC) information
    • Reading off the parameter values
    • Activating/deactivating Volvo On Call Plus (USA only)
    • Service check for Volvo On Call / Volvo On Call Plus
    • Resetting the reserve battery
    • Resetting the carphone code
    • Reading off extended diagnostic trouble code (DTC) information, carphone module
  • Downloading software and replacing the control module
  • Function
    • Carphone
    • Volvo On Call Plus
  • System overview
    • Control module
    • Signals
• Power Seat Module (2001-2004)
  • Design
    • Control panel
  • Downloading software and replacing the control module
  • Function
    • Seat programming
    • Maneuvering seats with memory
    • Remote operation of seats
    • Maneuvering seats without memory
  • Power seat module diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off control module identification
  • System overview
    • Control module
    • Signals
• Power Seat Module (PSM) (2005-2007)
  • Design
    • Control panel
  • Diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off control module identification
  • Downloading software and replacing the control module
  • Function
    • Seat programming
    • Maneuvering seats with memory
    • Remote operation of seats
    • Maneuvering seats without memory
  • System overview
    • Control module
    • Signals
• Rear Electronic Module (Rem) (2001-2004)
  • Design
    • Locks
    • Inclination sensor module (ISM)
    • Headlamp range adjustment position sensors (Bi-Xenon)
    • Fuel level (Gasoline/Diesel)
    • Fuel level (Bi-fuel)
    • Shut-off valve (Bi-fuel)
    • Diesel filter preheating (Diesel)
    • Rear fog lamp
    • Back-up lamp
    • Brake light
    • High level stop lamp
    • Rear windshield wiper/washers
    • Rear demist
    • Rear 12 V socket
    • Parking assistance
  • Diagnostic functions
    • General
    • Diagnostic functions
      • General
      • Diagnostic trouble codes (DTC)
      • Reading and erasing diagnostic trouble codes (DTCs)
      • Reading off input and output signals
      • Activating components and functions
      • Reading off static data
      • Reading off the control module identification
  • Downloading software and replacing the control module
  • Function
    • Alarm
    • Locks
    • Fuel level (Gasoline/Diesel)
    • Fuel level (Bi-fuel)
    • Shut-off valve (Bi-fuel)
    • Diesel filter preheating (Diesel)
    • Rear fog lamp
    • Back-up lamp
    • Brake light
    • High level stop lamp
    • Rear demist
    • Rear 12 V socket
    • Parking assistance
  • System overview
    • Control module
    • Signals
• Rear Electronic Module (Rem) (2005-2007)
  • Design
    • Alarm
    • Central locking
    • Inclination sensor module (ISM)
    • Headlamp range adjustment position sensors (Bi-Xenon)
    • Fuel level (Bi-fuel)
    • Shut-off valve (Bi-fuel)
    • Diesel filter preheating (Diesel)
    • Rear fog lamp
    • Rear parking lamps/license plate lighting
    • Back-up lamp
    • Brake light
    • High level stop lamp
    • Rear windshield wiper/washers
    • Rear demist
    • Rear 12V socket
    • Parking assistance system (optional extra)
    • Tow hitch (optional extra)
    • Rear window lift mechanisms
  • Diagnostic functions
    • General
    • Diagnostic trouble codes (DTCs)
    • Reading and erasing diagnostic trouble codes (DTCs)
    • Reading off the control module identification
    • Reading off extended diagnostic trouble code (DTC) information
    • Reading off the parameter values
    • Activating components and functions
    • Description of frozen values, rear electrical module
      • Explanation
      • Battery voltage, value
      • Distance, value
      • Passenger compartment temperature, value
      • Outside temperature, value
      • Engine running, status
      • Time, value
  • Downloading software and replacing the control module
  • Function
    • Alarm
    • Central locking
    • Battery voltage
    • Fuel level (Bi-fuel)
    • Shut-off valve (Bi-fuel)
    • Diesel filter preheating (Diesel)
    • Rear fog lamp
    • Rear parking lamps/license plate lighting
    • Back-up lamp
    • Brake light
    • High level stop lamp
    • Rear windshield wiper/washers
    • Rear demist
    • Rear 12V socket
    • Parking assistance system (optional extra)
    • Tow hitch (optional extra)
    • Rear window lift mechanisms
  • System overview
    • Control module
    • Signals