Technical Service Bulletins: Other Variant
WARNING: This page is about the Impala Base, 3.4 E, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- New PAG Oil Released (02-01-39-004B)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Refrigerant Dye Added To A/C System At Assembly Plant (00-01-38-009B)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Part and Accessory Replacement Policy (04-00-89-011)
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Loud Pop Or Snap Noise Coming From Instrument Panel (IP) In High Or Low Ambient Temperatures (Replace Instrument Panel Upper Pad) (03-08-49-023A)
- Set-up/Programming BCM for Remote Keyless Entry (RKE) (04-08-52-001)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Power Seat Adjuster Inoperative (Reconnect Or Replace Adjuster Cables) (02-08-50-010)
- SMU - Revised Communication Interface Module Replacement Reconfiguration Procedure (02-08-46-012)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Programming The HOMELINK(R) Transmitter (01-08-97-002)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Various DRIVEABILITY Symptoms - Malfunction Indicator Lamp (Mil) Illuminates Intermittently, Abs Light On, DTCS Set, Engine Will Not Start (Repair Wire(S)) (00-06-04-049B)
- Intermittent/Constant Abs Mil Illuminated (Replace Both Front Wheel Speed Harnesses) (03-05-25-008)
- Unwanted Abs Activation (PI00875)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Set-up/Programming BCM for Remote Keyless Entry (RKE) (04-08-52-001)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Correct Use Of Labor Operation R4490 RKE Transmitter Replace (01-00-89-013)
- Replacement Keys/Key Numbers &/Or Security Chips (01-00-89-009)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Normal Maintenance Or Warranty Service For 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade (08-07-30-040C)
- 4T65E Transmission 1-2 Shift Shudder At Light To Moderate Acceleration (Replace 2ND Clutch Plates And Sealing Rings) (06-07-30-023E)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Information On 4T65-E MN7, M15 and M76 Front Wheel Drive Automatic Transmission Valve Body Reconditioning, DTCs P0741, P0742, P0757, P842, Harsh Shifts or Slips (08-07-30-002A)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- 2006 Interim Model Year Change for 4T65-E Automatic Transmissions (RPOs M15, M76, MN7) - Input Carrier Assembly Lube Dam & Bearing (06-07-30-011)
- New Product Feedback Form and Process For Automatic Transmission Core Returns (01-07-30-029A)
- 4T65-E Automatic Transmission Fluid Leak From Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Incorrect Transmission Shifts, Poor Engine Performance, Harsh 1-2 Upshifts, Slips 1ST and Reverse, Torque Converter Clutch (TCC) Stuck Off/On, DTCs P0730, P0756, P0757, P0741, P0742 (Clean Transaxle Valve Body and Case Oil Passages of Debris) (02-07-30-013E)
- Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
- Grind Noise Or No Vehicle Movement When Shifting Into Drive Or Reverse (Inspect Transaxle, Replace Various Transaxle Components) (03-07-30-017)
- Pressure Control Solenoid Replacement For 4T65-E, 4T40-E And 4T45-E Transmission/Transmission (02-07-30-048)
- Servicing 4T65-E Transaxle Spacer Plate And Gaskets (02-07-30-014A)
- Slips, Harsh Upshift Or Garage Shifts, Launch Shudders, Flares, Erratic Shifts And Intermittent Concerns, DTC P1811 Or P0748 Set (Replace Pressure Control Solenoid Valve Assembly) (00-07-30-002B)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Check Engine Light On, DTC P0410 Set, Water In Air Pump (Replace Air Pump, Install New Hose And Shield) (04-06-04-037)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Axle Shafts
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Diagnostic Tip - B1001 With Sir Mil And/Or SVS Mil And/Or Locked Radio (PIC5913)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Set-up/Programming BCM for Remote Keyless Entry (RKE) (04-08-52-001)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Power Seat Adjuster Inoperative (Reconnect Or Replace Adjuster Cables) (02-08-50-010)
- SMU - Revised Communication Interface Module Replacement Reconfiguration Procedure (02-08-46-012)
- SMU - Revised DTCS B1000, B1004, B1007, B1009, B1013 (02-08-47-001)
- Brakes Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Various DRIVEABILITY Symptoms - Malfunction Indicator Lamp (Mil) Illuminates Intermittently, Abs Light On, DTCS Set, Engine Will Not Start (Repair Wire(S)) (00-06-04-049B)
- Intermittent/Constant Abs Mil Illuminated (Replace Both Front Wheel Speed Harnesses) (03-05-25-008)
- Unwanted Abs Activation (PI00875)
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Unable Place An ONSTAR Call With Ignition In On Position After 15-08-44-001 CANADA Upgrade (PIT5485B)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Red Led And B2455 After Performing CANADA Upgrade Bulletin 15-08-44-001 (PIC6140A)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Information On Upgrading Certain ONSTAR® Analog/Digital-Ready Systems To ONSTAR® Generation 6 Digital-Capable System (05-48-46-006G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Servicing Vehicles Upgraded To ONSTAR® Generation 6 Digital-Capable System (Follow Information Below) (09-08-46-001)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- Addition of DTC U1500 for Generation 4 (F1) OnStar® (02-08-46-005A)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Unable to Connect to OnStar® After a Dropped Cellular Call During Vehicle Configuration (01-08-46-005A)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Cellular Error Messages Received When Trying to Connect to OnStar(R) (02-08-46-004A)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- OnStar(R) Microphone Inoperative (Replace OnStar(R) Microphone) (05-08-46-010)
- Programming of Replacement OnStar(R) Vehicle Communication and Interface Modules (VCIM) (01-08-46-002D)
- Addition of OnStar(R) Microphone Replacement Procedure (05-08-46-007)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- SMU - Revised Communication Interface Module Replacement Reconfiguration Procedure (02-08-46-012)
- Revised ONSTAR(R) Antenna Coupling Replacement Procedures (01-08-46-006A)
- Cooling Fan
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Engine Overheating And/Or Excessive Noise From Electric Cooling Fan Motor (Install Cooling Fan Shield And Cooling Fan Module Motor Shroud Assembly, If Necessary) (02-06-02-011A)
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- DEX-COOL(R) Engine Coolant Information (736214)
- Low Engine Coolant Level Indicator Always On (Diagnose Low Coolant Level System Operation/Check Sensor for Oil Contamination) (04-06-02-007)
- Engine Overheating And/Or Excessive Noise From Electric Cooling Fan Motor (Install Cooling Fan Shield And Cooling Fan Module Motor Shroud Assembly, If Necessary) (02-06-02-011A)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Whistle Noise On Light Acceleration (Replace Throttle Body) (05-06-04-002)
- Security Light On, Engine Will Not Crank, Diagnostic Trouble Codes B2958 and/or B2960 (Repair Poor Terminal Connections at Body Control Module) (04-08-47-003)
- Low Engine Coolant Level Indicator Always On (Diagnose Low Coolant Level System Operation/Check Sensor for Oil Contamination) (04-06-02-007)
- Check Engine Light On, DTC P0410 Set, Water In Air Pump (Replace Air Pump, Install New Hose And Shield) (04-06-04-037)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Powertrain Control Module (PCM) Will Not Properly Communicate On-Board Diagnostic Freeze Frame Information to Non-TECH2(R) (Generic) Service or Test Equipment (Reprogram PCM) (04-06-04-024)
- Various DRIVEABILITY Symptoms - Malfunction Indicator Lamp (Mil) Illuminates Intermittently, Abs Light On, DTCS Set, Engine Will Not Start (Repair Wire(S)) (00-06-04-049B)
- SMU - Revised Electronic Ignition (EI) System Diagnosis (03-06-04-006)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Service Engine Soon (SES) Light On With DTCS P0716 And/Or P0717, P0730, P0753, P0758, P1860, P1887 Or Other Miscellaneous Transmission Trouble Codes Set (Repair Wiring At Transaxle Wiring Pass-Thru Connector (02-07-30-022)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- Information On Procedure To Unlock DELCO Radio With THEFTLOCK (PIC4696E)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Radio Knobs Available for Service (05-08-44-029A)
- XM Radio Labor Operation Codes (03-08-44-001A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Cigarette Lighter May Be Inoperative (Install New Lighter Element) (01-08-49-016)
- Cd Cannot Be Inserted Into Cd Player Or Ejected (Reset Radio) (01-08-44-011)
- Radio Bass Level Too High (Adjust Bass Level Using Tech 2) (01-08-44-012)
- Exhaust
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Availability of Exhaust Muffler for Service (04-06-05-008)
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- New Vehicle Door Edge Protection (01-08-51-002)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Clicking/Creaking Noise from Front of Vehicle (Apply Penetrating Threadlocker) (02-08-61-001B)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- Information - New Frame Insulator Remover/Installer From KENT MOORE (01-08-61-003)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Revised Outer Tie Rod End Nut Tightening Specification/Tie Rod End Jam Nut Tightening Specification Added (05-02-32-003)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Whistle Noise On Light Acceleration (Replace Throttle Body) (05-06-04-002)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Ash Tray Will Not Open (Reposition Ash Tray Reflector Flap, Replace Ash Tray, if Necessary) (04-08-49-031)
- Broken Console or Storage Compartment Lid Latch (Replace Latch) (03-08-49-018B)
- Instrument Panel Gap Appearance (Remove Tape) (04-08-110-007)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- HVAC Horizontal Vent Louvers Loose or Inoperative (Reinstall Louver Tabs Into Thumbwheel/Deflector Housing) (06-01-39-010A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- HVAC Control Knob Replacement (04-01-37-001)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Automatic Air Conditioning Control Operation (99-01-39-007B)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Key Replacement Due To Incorrect Keys Purchased (16-NA-260)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Replacement Keys/Key Numbers &/Or Security Chips (01-00-89-009)
- Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- SMU - Revised Electronic Ignition (EI) System Diagnosis (03-06-04-006)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Sunshade (Visor) Vanity Mirror Bulb Inoperative (Replace Vanity Mirror Bulb Only) (06-08-42-002A)
- Radio Knobs Available for Service (05-08-44-029A)
- Ash Tray Will Not Open (Reposition Ash Tray Reflector Flap, Replace Ash Tray, if Necessary) (04-08-49-031)
- Broken Console or Storage Compartment Lid Latch (Replace Latch) (03-08-49-018B)
- Instrument Panel Gap Appearance (Remove Tape) (04-08-110-007)
- Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
- Loud Pop Or Snap Noise Coming From Instrument Panel (IP) In High Or Low Ambient Temperatures (Replace Instrument Panel Upper Pad) (03-08-49-023A)
- Glove Box Door Contacts Door Trim Panel (03-08-110-008)
- Front Door Glass Snapping Noise When Raising (Replace Door Glass Run Channel) (03-08-64-034)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Roof Panel Joint (Ditch) Molding (01-08-111-003)
- New Vehicle Door Edge Protection (01-08-51-002)
- Interior/Illumination Lights
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Engine Crankcase Flush (02-06-01-028)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Overview of Steering System Noises (06-02-32-009B)
- Guidelines For Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Revised Cylinder Head Bolt Torque Specification and Tightening Sequence (02-06-01-003B)
- Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal using Revised Rear Main Seal Installer) (05-06-01-019B)
- Whistle Noise On Light Acceleration (Replace Throttle Body) (05-06-04-002)
- Powertrain Quality Center For Performance Parts Engine Replacements (03-06-01-006)
- New Polymer Coated Piston And Rod Assembly (03-06-01-002)
- SMU - Revised Rocker Arm Bolt Fastener Tightening Specification (02-06-01-034)
- Engine Crankcase Flush (02-06-01-028)
- Engine Identification Information (02-06-01-026)
- Information On A New Engine PRELUBER Tool (02-06-01-008)
- SMU - Revised Lower Intake Manifold Installation (02-06-01-014)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Brake Rotor Minimum Allowable Thickness After Refinish Specification Correction (04-05-23-002A)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Brake Rotor Minimum Allowable Thickness After Refinish Specification Correction (VSS20040090)
- Memory Modules
- Mirrors
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- New Vehicle Door Edge Protection (01-08-51-002)
- Parking Brake System
- Passive Restraints
- Procedures
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- DTCS B1001, B1271 Or B1780 Set When Replacing/Reprogramming Other Modules (99-06-03-010A)
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Power Seat Adjuster Inoperative (Reconnect Or Replace Adjuster Cables) (02-08-50-010)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Intermittent No Crank, No Start (03-06-03-006A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
- Steering Column
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Clunk Felt/Noise Heard From Steering Column, Steering Gear and/or Front Of Vehicle During Turning Maneuver and/or Steering Wheel Rotation (Replace Intermediate Shaft As Directed) (01-02-32-001P)
- Overview of Steering System Noises (06-02-32-009B)
- Steering Control Systems
- Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Release of Steering Gear Stub Shaft Bearing Kit for Service (04-02-32-001F)
- Clunk Noise from Front of Vehicle During Turning Maneuver/Steering Wheel Rotation (04-02-35-004F)
- Steering Linkage
- Clunk Felt/Noise Heard From Steering Column, Steering Gear and/or Front Of Vehicle During Turning Maneuver and/or Steering Wheel Rotation (Replace Intermediate Shaft As Directed) (01-02-32-001P)
- Revised Outer Tie Rod End Nut Tightening Specification/Tie Rod End Jam Nut Tightening Specification Added (05-02-32-003)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Prior To Any Circuit Testing (PIP5094A)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001G)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Incorrect Transmission Shifts, Poor Engine Performance, Harsh 1-2 Upshifts, Slips 1ST and Reverse, Torque Converter Clutch (TCC) Stuck Off/On, DTCs P0730, P0756, P0757, P0741, P0742 (Clean Transaxle Valve Body and Case Oil Passages of Debris) (02-07-30-013E)
- Whistle Noise On Light Acceleration (Replace Throttle Body) (05-06-04-002)
- Security Light On, Engine Will Not Crank, Diagnostic Trouble Codes B2958 and/or B2960 (Repair Poor Terminal Connections at Body Control Module) (04-08-47-003)
- Check Engine Light On, DTC P0410 Set, Water In Air Pump (Replace Air Pump, Install New Hose And Shield) (04-06-04-037)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Powertrain Control Module (PCM) Will Not Properly Communicate On-Board Diagnostic Freeze Frame Information to Non-TECH2(R) (Generic) Service or Test Equipment (Reprogram PCM) (04-06-04-024)
- Various DRIVEABILITY Symptoms - Malfunction Indicator Lamp (Mil) Illuminates Intermittently, Abs Light On, DTCS Set, Engine Will Not Start (Repair Wire(S)) (00-06-04-049B)
- SMU - Revised Electronic Ignition (EI) System Diagnosis (03-06-04-006)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- SMU - Revised Lower Intake Manifold Installation (02-06-01-014)
- Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001G)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Pressure Control Solenoid Replacement For 4T65-E, 4T40-E And 4T45-E Transmission/Transmission (02-07-30-048)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Servicing 4T65-E Transaxle Spacer Plate And Gaskets (02-07-30-014A)
- Slips, Harsh Upshift Or Garage Shifts, Launch Shudders, Flares, Erratic Shifts And Intermittent Concerns, DTC P1811 Or P0748 Set (Replace Pressure Control Solenoid Valve Assembly) (00-07-30-002B)
- Service Engine Soon (SES) Light On With DTCS P0716 And/Or P0717, P0730, P0753, P0758, P1860, P1887 Or Other Miscellaneous Transmission Trouble Codes Set (Repair Wiring At Transaxle Wiring Pass-Thru Connector (02-07-30-022)
- SMU - Revised DTC P0713 (02-07-30-015)
- Wheel Alignment
- Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Tire Sidewall Damage (01-03-10-011)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Front Door Glass Snapping Noise When Raising (Replace Door Glass Run Channel) (03-08-64-034)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Various DRIVEABILITY Symptoms - Malfunction Indicator Lamp (Mil) Illuminates Intermittently, Abs Light On, DTCS Set, Engine Will Not Start (Repair Wire(S)) (00-06-04-049B)
- Intermittent/Constant Abs Mil Illuminated (Replace Both Front Wheel Speed Harnesses) (03-05-25-008)