Technical Service Bulletins

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
Air Bag, SRS
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Anti-Lock Brakes
- Abs Hydraulic Units - PREINSTALLATION Service (P004/96)
- Abs INDICATIOR Lamp Stays On - Repair Ground Connect (P002/96)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Wind Noise Around Doors (S018/98)
- Keyless Entry Transmitter Inoperative (T011/97)
- Door Lock Knob Sinks Into Door Trim (S048/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Key Cylinder Replacement - REKEY Cylinders To Match (MT 0995-10)
- Poor A/T Performance - Check Aftermarket Alarm (MT 05-04)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
Automatic Trans
- Unusual Noise From Drive Shaft (L001/97)
- Slippage In Forward & Reverse Due To Low ATF Level (K005/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Torque CONVERTOR/Bolt Replacement Information (MT 1295-09)
- A/T Change Lever Knob Cracking (K004/96)
- A/T Oil Cooler Flushing Equipment Guideline (CAT. J, NO. 96-01)
- Recommended A/T Cooler Line Flushing Equipment (CAT. ST, NO. 009/95)
- A/T Center Bushing Deleted (MT 07-08)
- A/T Throttle Cable Adjustment (MT 05-06)
Auxiliary Emission Control Systems
- Year 2000 Compliance (01-018/99)
- Hard To Start Cold Engine - Install Modified Pcm (01-006/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- Rough Idle - Black Smoke After Hot Engine Restart (F027/96)
- OBDII - Mil DTC P0440 & Fuel Filler Cap Installation (F025/96)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Tapping / Ticking Noise At Idle (F018/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Noisy/Tapping Purge Solenoid Valve (MT 0596-08)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Room Fuse Installation - With Ignition Key Off (MT 0995-09)
Axle Shafts
- Unusual Noise From Drive Shaft (L001/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Abs Hydraulic Units - PREINSTALLATION Service (P004/96)
- Abs INDICATIOR Lamp Stays On - Repair Ground Connect (P002/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
Charging Systems
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
Clutch
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Cooling System (Mechanical)
- Coolant Leakage From Water Pump (E004/96)
- Cylinder Head Gasket Modification (CAT. B, NO. 013/95)
Cruise Control Systems
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
Differentials & Drive Axles
- Unusual Noise From Drive Shaft (L001/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Driveshaft & Universal Joints
- Unusual Noise From Drive Shaft (L001/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Electronic Steering
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
Electronic Suspension
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
Engine Control Systems
- No Start, Rough Idle, Lack Of Power After Timing Belt Replacement (CAT. 01, NO. 001/00R)
- Year 2000 Compliance (01-018/99)
- Hard To Start Cold Engine - Install Modified Pcm (01-006/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Rough Idle - Black Smoke After Hot Engine Restart (F027/96)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
Entertainment Systems
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Audio System Poor Sound Quality - Too Much Bass (T021/96)
- Cigarette Lighter Element Discontinued (MT 1295-02)
Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- OBDII - Mil DTC P0440 & Fuel Filler Cap Installation (F025/96)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
Exterior Lights
- Headlights Come On Automatically - Light Unit Switch (T007/98)
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Front Combination Lamp Falls Out Of Body (T014/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Sports Appearance Pkg. Service Install Instructions (S010/97)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Static ELECTRICTY Buildup - Solutions (MT 1095-11)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
Front Suspension
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Fuel System
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Fuses & Circuit Breakers
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Replacement Connectors For ECAT Solenoid Harness (K001/97)
- Checking Points For Dead Battery - Dark Current Draw (G003/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Tach Needle Stuck On Wrong Side Of Stopper Pin (T012/97)
Headlights
- Headlights Come On Automatically - Light Unit Switch (T007/98)
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Front Combination Lamp Falls Out Of Body (T014/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
HVAC Control Systems
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- HFC-134A A/C Recovery & Recycling Training/Equipment (CAT. ST, NO. 008/95)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
Infotainment
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Interior/Exterior Trim
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Loose Sun Visor - Modified SUNVISOR Stay & Adapter (09-005/99)
- Sports Appearance Pkg. Service Install Instructions (S010/97)
- Roof Rack Noise - Cross Bar Rubber Strip INSTALATION (MT 1196-06)
- Power Window Switch Panel Lifting (S040/96)
- Audio Storage Compartment Removal Procedure (S038/96)
- Poor Carpet Fit - Add Felt Padding (MT 9513-05)
- Meter Hood Removal Procedure (S027/96)
Interior/Illumination Lights
- Headlights Come On Automatically - Light Unit Switch (T007/98)
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Front Combination Lamp Falls Out Of Body (T014/97)
- Modified Interior Dome Light Bulb Application (MT 0897-05)
Locking Hubs
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
Lubrication System
- Cylinder Head Gasket Modification (CAT. B, NO. 013/95)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Manual Trans
- Unusual Noise From Drive Shaft (L001/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- V6 - 60,000 Mile Inspection - TENSIONER Pulley (CAT 01, NO. 002/00R)
- 60,000 Mile Inspection - TENSIONER Pulley (01-002/00)
- No Start, Rough Idle, Lack Of Power After Timing Belt Replacement (CAT. 01, NO. 001/00R)
- Hydraulic Lash Adjuster Noise (B001/98)
- HLA Type Rocker Arm Assembly Identification (MT 0697-05)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Tapping / Ticking Noise At Idle (F018/96)
- Cylinder Head Gasket Modification (CAT. B, NO. 013/95)
Mechanical - Hydraulic
- Brake Drum/Rotor Resurfacing Machinery Selection (MT 0897-06)
- Protective Film For Brake Disc Plate (P006/96)
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Caliper Bolt Corrosion - Clean & Seal (MT 0995-11)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Memory Modules
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Mirrors
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Door Mirror Modified Due To Distortion (MT 0397-08)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 031/95)
- Replacement Bumpers - Grease Removal Precautions (MT 08-03)
- Pre-Painting Preparation For Front And Rear Bumpers (CAT.S NO. 031/95)
Passive Restraints
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
Schedule
- V6 - 60,000 Mile Inspection - TENSIONER Pulley (CAT 01, NO. 002/00R)
Seats
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Seat Belt Extender Description/Ordering Info (CAT. S, NO. 032/96)
- Dirt On Seat Belt And Anchor (CAT. S, NO. 028/96)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
- Battery Recharging - Disconnect Negative Terminal (MT 08-10)
Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/96)
Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
- NGS System Message - Data Link Error (MT 06-02)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
Steering Linkage
- Squeak Noise From Rear Suspension (CAT. R, NO. 005/96)
- High Steering Wheel Effort - Verify Condition (MT 0995-05)
Sun Roof/T-Top/Convertible Top
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Water Leak From Sliding Sunroof (S003/98)
Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
System
- No Start, Rough Idle, Lack Of Power After Timing Belt Replacement (CAT. 01, NO. 001/00R)
- Year 2000 Compliance (01-018/99)
- Hard To Start Cold Engine - Install Modified Pcm (01-006/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- Rough Idle - Black Smoke After Hot Engine Restart (F027/96)
- OBDII - Mil DTC P0440 & Fuel Filler Cap Installation (F025/96)
- Data Link Connector Terminal Location LABLE DISCONT (T018/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Tapping / Ticking Noise At Idle (F018/96)
- OBD II Code - DTC P1794 Stored In Memory - Mil ILLUM (T012/96)
- DRIVEABILITY Concerns Related To Fuel Volatility (F013/96)
- Noisy/Tapping Purge Solenoid Valve (MT 0596-08)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- Cylinder Head Gasket Modification (CAT. B, NO. 013/95)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
- OBDII Description Freeze Frame Data Explanation (MT 1095-06)
- Room Fuse Installation - With Ignition Key Off (MT 0995-09)
Towing
- Vehicle Towing Precautions (CAT. AD, NO. 003/96)
Transfer Case
- Unusual Noise From Drive Shaft (L001/97)
- Four Wheel Drive - Popping Noise On Engagement (MT 07-07)
Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Torque CONVERTOR/Bolt Replacement Information (MT 1295-09)
- Special Tools October 1995 - NGS Program Card (CAT. MC, NO. 96-01)
- October 1995 Special Tools Shipment (CAT. ST, NO. 007/95)
- NGS System Message - Data Link Error (MT 06-02)
Warning Systems
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Wheel Balance Tips For Higher Precision Results (MT 0897-08)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Protective Film For Brake Disc Plate (P006/96)
- Four Wheel Drive - Popping Noise On Engagement (MT 07-07)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Wind Noise Around Doors (S018/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- Windshield Stone Chipping Inspection (S037/96)
- Film Or Residue On Glass - Removal (MT 05-05)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Replacement Connectors For ECAT Solenoid Harness (K001/97)
- Mil Light On/Multiple Codes Retrieved (MT 1195-07)