2.2L/2.5L SPFI Tests/Code
- Description
- Operation
- Removal & Installation
- Testing & Diagnosis
- Diagnostic Trouble Code (DTC) Identification
- No Start Tests
- NS-1, Checking Spark & Fuel At Throttle Body
- NS-2, Checking Injector Flow & Fuel Control Faults
- NS-3, Checking SMEC, Wet Plugs & Timing
- NS-4, Checking IGN. Coil Driver, Open Circuits & SMEC
- NS-5, Checking Coil Primary & Coil
- NS-6, Checking Fuel Pressure, TPS & Circuits
- NS-7, Checking Injector Driver Circuits & Injectors
- NS-8, Checking INJ. Interface Fault & Control Circuit
- NS-9, Flooding Injector Check, CTRL. CKT. & Press. Regulator
- NS-10, Checking System Faults
- NS-11, SYS. Power, Ground, Map, SMEC & Distributor Pick-Up Check
- NS-12, Checking Distributor Pick-Up & Circuits
- NS-13, Checking ASD Relay & Pull In Coil Circuits
- NS-14, Power CKT. To Pull In Coil & ASD Relay Check
- NS-15, Power Feed CKTS. To ASD Relay & Relay Check
- NS-VER, Verification Of No Start
- DRIVEABILITY Tests
- Dr-1, Checking System For Faults
- Dr-2, Checking Output Circuits Of SMEC
- Dr-3, Intermittent Test For Solenoids & Relays
- Dr-4, Intermittent Test For Map Sensor Signal
- Dr-5, Intermittent Test For Sensor Voltages
- Dr-6, Intermittent Test For Injectors & AIS Motor
- Dr-7, Checking For Fault Message "Map Pneumatic Signal"
- Dr-8, Checking For Fault Message "Map Pneumatic Change"
- Dr-9, Checking For Fault Message "Map Voltage Low"
- Dr-10, Checking For Fault Message "Map Voltage Too High"
- Dr-11, Checking For Fault Message "Vehicle Speed Signal"
- Dr-12, Checking For Fault Message "Oxygen Sensor Signal"
- Dr-13, Checking For Fault Message "Coolant Voltage Low"
- Dr-14, Checking For Fault Message "Coolant Voltage High"
- Dr-15, Checking For Fault Message "T/B Temp. Voltage Low"
- Dr-16, Checking For Fault Message "T/B Temp. Voltage High"
- Dr-17, Checking For Fault Message "TPS Voltage Low"
- Dr-18, Checking For Fault Message "TPS Voltage High"
- Dr-19, For Fault Message "AIS Motor Circuits" Check
- Dr-20, Checking For Fault Message "Purge Solenoid Circuits"
- Dr-21, Checking For Fault Message "EGR Solenoid Circuit
- Dr-22, Fault Message "EGR System Failure" Check
- Dr-23, Checking For Fault Message "A/C Clutch Relay Circuit"
- Dr-24, Checking Radiator & A/C Fan Relays
- Dr-25, Checking For Fault Message "Radiator Fan Relay"
- Dr-26, Checking For Fault Message "PTU Solenoid Circuit"
- Dr-27, Checking For Fault Message "FJ2 Voltage Sense"
- Dr-28, Fault Message "EMR Mileage ACCUM & Ee Prom Write Denied" Check
- Dr-29, Checking Sensor Calibrations With Engine Cold
- Dr-30, Sensor Calibrations With Engine Warm (1 Of 3) Check
- Dr-31, EGR Valve With Engine Warm Check
- Dr-32, Checking Secondary Ignition System
- Dr-33, Checking Basic Timing & Fuel System
- Dr-34, Checking Oxygen Sensor
- Dr-35, Checking Throttle Body Minimum Airflow
- Dr-36 - Other Possible Causes Of DRIVEABILITY Related Problems
- DRIVEABILITY Verification Tests
- Speed Control System Tests
- Charging System Tests
- Wiring Diagrams