Technical Service Bulletins: Other Variant
WARNING: This page is about the SW2 Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- New PAG Oil Released (02-01-39-004B)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- Information On Serpentine Belt Wear (04-06-01-013)
- A/C System R-134A Refrigerant Ultra Violet (UV) Dye Usage (02-T-75)
- A/C Inoperative (00-T-34)
- HVAC Whistle Noise At Hi Speeds W/System In RECIRC. (99-T-33A)
- A/C INOPERATVE - Replace A/C Compressor Clutch (00-T-34)
- Procedures Involving Thermal Expansion Valve Connect (99-T-42)
- Oil Accumulation At Set Screw On A/C Compressor Rear (99-T-32)
- Accessories & Equipment
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Essential Service Tool Update # 2 (U.S. Retailers Only) (08-00-89-020)
- Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
- Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
- Accessories Control Systems
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Security Indicator Illuminated Or Flashing, Engine Starts Then Stalls And/Or Disabled For 10 Minutes, Diagnostic Trouble Code P1632 Set (Follow Bulletin Diagnostic Table) (03-08-56-003)
- Any Of The Following Components Or Circuits Are Inoperative Or Intermittently Inoperative - Rear Washer Pump, Rear Wiper, Speakers Cutting Out, Vehicle Cranks But May Not Start, Mil SES Light On (00-T-43A)
- Service Manual Update For 2000 And 2001 S Series Body/Electrical Volume II Service Manual Due To Revision Changes In Circuit Function Of Connectors (00-T-67)
- Audible Warning Chime Distorted-Install Foam Block Tape In Body Control Module (01-T-59)
- Accessory Drive Belts
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- Service Manual Update For 2000 And 2001 S Series Restraints Service Manuals (01-T-03)
- Service Manual Update For 2000/2001 S-Series Restraints Service Manuals (01-T-03)
- Anti-Lock Brakes
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Mil Service Engine Soon Telltale Lamp On, Abs Telltale Lamp May Come On Intermittently And/Or Stay On With DTCS U1000, U1040 And C0550 Present (02-T-59)
- Service Procedure For Brake Pressure Modulator Valves Equipped With 8 Degree Accumulator Plates (00-T-25)
- Anti-Theft Systems
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Theft Deterrent Feature Will Not Set On Cassette Single Cd Player Radio (RPO Up0) (Replace Radio) (04-08-44-013)
- Security Indicator Illuminated Or Flashing, Engine Starts Then Stalls And/Or Disabled For 10 Minutes, Diagnostic Trouble Code P1632 Set (Follow Bulletin Diagnostic Table) (03-08-56-003)
- Valet Key Opens Rear Compartment Lid (00-T-79)
- Intermittent Operation And/Or Difficulty Programming RKE Transmitter (00-T-10)
- Intermittent Operation And/Or Difficulty Programming RKE (99-T-10)
- Front Door Handle Contacts Outer Door Panel (99-T-45)
- Front Door Outside Handle Contacts Front Door Outer Panel When Open (99-T-45)
- Automatic Trans
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Quick Tips for Warranty Administration (05-00-89-007)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- Info - Remanufactured Transmission And Remanufactured Valve Body Information Requirements (04-07-30-026)
- (SES) Service Engine Soon Light On With Diagnostic Trouble Code (DTC) P0731, No Movement In Drive During Cold Ambient Temperatures (Replace Oil Pump Or 1ST Gear Sprag Clutch Assembly) (03-07-30-008A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Service Information Regarding Service Applications For Automatic Transaxle Shift Solenoids (00-T-74)
- Delayed And/Or Harsh Engagement Into Reverse Or Drive, Erratic Shifting Between 1ST/2ND, Bind Up In Reverse, No 2ND Or 3RD Gears, And/Or Transaxle DTCS P0731, P0732, P0733 Or P0734 Stored In Pcm (00-T-24)
- Service Manual Update For 2000/2001 S Series Automatic Transaxle Service Manuals (00-T-65)
- (Mil) Service Engine Soon Telltale Illuminated With DTC P0711 After Vehicle Is Flat-Towed With All Four Wheels On The Ground (Clear DTC & Retest) (01-T-28)
- Service Information Regarding New Design Automatic Transaxle Solenoids (00-T-74)
- Service Manual Update For 2000/2001 S-Series Automatic Transaxle Service Manuals (00-T-65)
- SMU - DTC P0731, P0732, P0733, P0734, P0741 (99-T-67)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- SES Lamp On with DTC P0442 "EVAP System Small Leak Detected" Set (Diagnose Evaporative Emission [EVAP] System, Repair as Necessary) (05-06-04-049)
- SMU For Powertrain And Engine Service Manuals Regarding Evaporative Emission Flowcharts And EVAP Pressure/Purge Diagnostic Cart Test Procedure (02-T-02)
- Mil Service Engine Soon Telltale Lamp On, Abs Telltale Lamp May Come On Intermittently And/Or Stay On With DTCS U1000, U1040 And C0550 Present (02-T-59)
- Mil Service Soon Telltale On With DTC P0133 - O2S Slow Response (00-T-02B)
- SMU For S-Series Eng DTC'S P0231,P0232,P0418,P1418 (99-T-63)
- Emission Requirements For M.Y. 2000 (99-I-10)
- Axle Shafts
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Steering Wheel Shake Or Vibration At 100-109 Km/H (62-68 Mph) (Follow Vibration Complaint Flow Chart, Replace Hub Assembly, If Necessary) (04-03-10-008)
- Squeak Or Squeal Noise From Intermediate Axle Shaft Bearing (01-T-11)
- Squeak Or Squeal Noise From Intermediate Axle Shaft Bearing (Replace Intermediate Axle Shaft Seal With New Service Part) (01-T-11)
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Body Interior
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Security Indicator Illuminated Or Flashing, Engine Starts Then Stalls And/Or Disabled For 10 Minutes, Diagnostic Trouble Code P1632 Set (Follow Bulletin Diagnostic Table) (03-08-56-003)
- Battery Dead After Being Towed Behind RV With All Wheels On The Ground (00-T-33)
- Brakes Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Mil Service Engine Soon Telltale Lamp On, Abs Telltale Lamp May Come On Intermittently And/Or Stay On With DTCS U1000, U1040 And C0550 Present (02-T-59)
- Service Manual Update For All The 2000 S Series Brakes Service Manuals Regarding DTC B0005 (00-T-05)
- Service Procedure For Brake Pressure Modulator Valves Equipped With 8 Degree Accumulator Plates (00-T-25)
- SMU - Brake Service Manual Regarding DTC B0005 (00-T-05)
- SMU - DTC C0267 Low Brake Fluid Indicated (99-T-53)
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Information On Serpentine Belt Wear (04-06-01-013)
- Battery Charger For Critical Image Equipment Program (99-I-07)
- Communication Devices
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Component Locations
- Cooling System (Mechanical)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- Information On Serpentine Belt Wear (04-06-01-013)
- Objectionable Engine Vibration At Idle (Check Engine Mount, Cooling Module Mounts, Engine Strut Cradle Bracket, Muffler Hanger And Strap, A/C Suction Hose, And Adjust Or Replace As Required) (95-T-36A)
- Engine Coolant Leak At Intake Manifold Gasket (01-T-15A)
- Engine Coolant Recovery Reservoir Discoloration Due To Engine Cooling System Sealer (97-T-04A)
- Engine Cooling System Sealer Usage (97-T-40A)
- Engine Coolant Leak In Or Around Spark Plug Well Area Of Cylinder Head (Add One 10 Gram Pellet Of Engine Cooling System Sealer) (01-T-47)
- Engine Coolant Leak At Intake Manifold Gasket (Replace Intake Manifold Gasket With New Design 2-Piece Gasket) (01-T-15)
- Engine Coolant Temperature Sensor Diagnostic Trouble Code(S) &/Or The Following Conditions: Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low &/Or Leaking Coolant, &/Or Service Engine Soon Lamp Illuminated (01-T-07)
- SMU For S-Series Eng DTC'S P0231,P0232,P0418,P1418 (99-T-63)
- Cruise Control Systems
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- Differentials & Drive Axles
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Squeak Or Squeal Noise From Intermediate Axle Shaft Bearing (01-T-11)
- Driveshaft & Universal Joints
- Electronic Suspension
- Engine Control Systems
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- SES Lamp On with DTC P0442 "EVAP System Small Leak Detected" Set (Diagnose Evaporative Emission [EVAP] System, Repair as Necessary) (05-06-04-049)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM, and TCM) for All Models and All Model Years (05-06-04-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Security Indicator Illuminated Or Flashing, Engine Starts Then Stalls And/Or Disabled For 10 Minutes, Diagnostic Trouble Code P1632 Set (Follow Bulletin Diagnostic Table) (03-08-56-003)
- Engine Coolant Leak At Intake Manifold Gasket (01-T-15A)
- Engine Hesitation And/Or Vehicle Lacks Power With DTC P0326 Knock Sensor System Performance Set (Install Pcm Calibration) (03-T-02)
- Mil Service Engine Soon Telltale Lamp On, Abs Telltale Lamp May Come On Intermittently And/Or Stay On With DTCS U1000, U1040 And C0550 Present (02-T-59)
- DTC P0603 May Be Stored When Battery Voltage Is Removed From The Pcm With Ignition Off (00-T-55)
- Mil Service Soon Telltale On With DTC P0133 - O2S Slow Response (00-T-02B)
- Service Information Regarding 2000-2001 S Series Powertrain Control Module Calibrations (00-T-71)
- Engine Coolant Temperature Sensor Diagnostic Trouble Code(S) &/Or The Following Conditions: Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low &/Or Leaking Coolant, &/Or Service Engine Soon Lamp Illuminated (01-T-07)
- Service Information Regarding 2000-2001 SATURN S-Series Powertrain Control Module (Pcm) Calibrations (00-T-71)
- SMU For S-Series Eng DTC'S P0231,P0232,P0418,P1418 (99-T-63)
- Entertainment Systems
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Information On Procedure To Unlock DELCO Radio With THEFTLOCK (PIC4696E)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Compact Disc (CD) Player Inoperative - Will Not Load, Will Not Eject or Will Not Play (Remove Both Radio Fuses to Reset Radio) (04-08-44-018)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Info - Return Form For Compact Discs (CDS) Or Digital Versatile Discs (DVDS) That Are Stuck In Cd Player When Returned As A Core Return (04-08-44-015)
- Theft Deterrent Feature Will Not Set On Cassette Single Cd Player Radio (RPO Up0) (Replace Radio) (04-08-44-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- COMPACT DISCS (CDs) SKIP IN SINGLE CD PLAYER (REPLACE RADIO ASSEMBLY) (03-08-44-016A)
- Info - Changes To The U1C Radio On-Board Diagnostic Modes And Cd Load Operation (03-08-44-017)
- Radio Upgrade Service Procedures (00-T-20)
- Any Of The Following Components Or Circuits Are Inoperative Or Intermittently Inoperative - Rear Washer Pump, Rear Wiper, Speakers Cutting Out, Vehicle Cranks But May Not Start, Mil SES Light On (00-T-43A)
- Radio Upgrade Service Procedure (00-T-20)
- Exhaust
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Info - Service Procedure For Replacement Of Resonator And Intermediate Pipe (04-06-05-010)
- Objectionable Engine Vibration At Idle (Check Engine Mount, Cooling Module Mounts, Engine Strut Cradle Bracket, Muffler Hanger And Strap, A/C Suction Hose, And Adjust Or Replace As Required) (95-T-36A)
- Excessive Exhaust System Noise And/Or Exhaust System Leak (00-T-78)
- Exhaust System Noises During Deceleration on SOHC Engines with Manual Transaxles (Install a DOHC Service Replacement Intermediate Exhaust Pipe with Resonator) (99-T-41A)
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- GM Training - Changes to Saturn Service Training Standards (STS) Requirements for 2009 and 2010 (U.S. Dealers) (09-00-89-021)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- SES Lamp On with DTC P0442 "EVAP System Small Leak Detected" Set (Diagnose Evaporative Emission [EVAP] System, Repair as Necessary) (05-06-04-049)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- SMU For Powertrain And Engine Service Manuals Regarding Evaporative Emission Flowcharts And EVAP Pressure/Purge Diagnostic Cart Test Procedure (02-T-02)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Service Information on New Torque Specification and Installation Procedure for the Outer Tie Rod-to-Steering Knuckle Joint on vehicles Equipped with a Torque Prevailing Nut (99-T-05A)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- SMU For Powertrain And Engine Service Manuals Regarding Evaporative Emission Flowcharts And EVAP Pressure/Purge Diagnostic Cart Test Procedure (02-T-02)
- Any Of The Following Components Or Circuits Are Inoperative Or Intermittently Inoperative - Rear Washer Pump, Rear Wiper, Speakers Cutting Out, Vehicle Cranks But May Not Start, Mil SES Light On (00-T-43A)
- SMU For S-Series Eng DTC'S P0231,P0232,P0418,P1418 (99-T-63)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Battery Dead After Being Towed Behind RV With All Wheels On The Ground (00-T-33)
- Gauges & Instrument Panels
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Instrument Cluster Lens And Bulb Replacement (00-T-27)
- Rattle Noise From Front Of Dash Area (00-T-39)
- Rattle Noise From Front Of Dash Area - Install Foam Shim (00-T-39)
- Engine Cranks But Will Not Start Or Engine Starts But Fuel Gauge And Tachometer Are Inoperative. Scan Tool Is Also Unable To Communicate With Pcm And DTC (01-T-26)
- Service Information On Instrument Cluster Lens & Bulb Replacement (00-T-27)
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- Odor from A/C at Vehicle Start-Up (Remove Debris from Evaporator Case, Disinfect Evaporator or Apply Cooling Coil Coating, and/or Enable Afterblow Function) (99-T-44A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- A/C System R-134A Refrigerant Ultra Violet (UV) Dye Usage (02-T-75)
- A/C Inoperative (00-T-34)
- Rattle Noise From Front Of Dash Area (00-T-39)
- Rattle Noise From Front Of Dash Area - Install Foam Shim (00-T-39)
- Loss Of Air Flow Through Right Side Air Vent Outlet And/Or Rattle Coming From Right Side Of Instrument Panel (Refasten Right Side Knee Beam Liner With Retainer) (01-T-31)
- Windows Fog Up (Open Front Of Dash Drains And Replace Air Inlet Screen If Required) (01-T-27)
- HVAC Whistle Noise At Hi Speeds W/System In RECIRC. (99-T-33A)
- Sizzling/Hissing Noise After A/C Use - New CONTROLER (99-T-65)
- Procedures Involving Thermal Expansion Valve Connect (99-T-42)
- Service Info On Liquid/Suction Line TVX Connector (99-T-42)
- Oil Accumulation At Set Screw On A/C Compressor Rear (99-T-32)
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Ignition Key Binds Or Does Not Turn Out Of The Lock Position (Replace Ignition Lock Cylinder, Tumblers & Springs) (01-T-23)
- Infotainment
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Whistle Type Wind Noise At Highway Speeds, Or Groaning Type Noise During Periods Of Precipitation (Replace Radio Antenna Mast) (94-T-25F)
- Interior/Exterior Trim
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Front And Rear Side Door Window Frame Appliques And/Or Windshield Frame Filler Panel Appliques Exhibiting Top Coat Paint Peeling (02-T-71)
- Instrument Cluster Lens And Bulb Replacement (00-T-27)
- Front Door Trim Insert Cracking At Armrest (00-T-53)
- Loose Or Detached Inner Mirror Trim Panel Assembly (00-T-75)
- Abnormal Wear Or Cut On Inboard Edge Of Seat Back Cover (00-T-38)
- Rattle Noise From Front Of Dash Area (00-T-39)
- Loose Or Detached Inner Mirror Trim Assembly (Install Shims On Mirror Trim Panel Assembly Tabs) (00-T-75)
- Front Door Trim Insert Cracking At Armrest (Replace Door Trim Insert) (00-T-53)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Popping Noise - Steering Column - Low Speed MANUEVER (00-T-03)
- Front Door Handle Contacts Outer Door Panel (99-T-45)
- Interior/Illumination Lights
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- Internal Engine Cleaning Products (99-I-08)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Power Steering System Noise and/or Leak Diagnosis (02-T-46)
- Information On Serpentine Belt Wear (04-06-01-013)
- Service Manual Update Regarding DTCS P0636 And P0637 (00-T-15)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Mechanical
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- Objectionable Engine Vibration At Idle (Check Engine Mount, Cooling Module Mounts, Engine Strut Cradle Bracket, Muffler Hanger And Strap, A/C Suction Hose, And Adjust Or Replace As Required) (95-T-36A)
- Engine Coolant Leak At Intake Manifold Gasket (01-T-15A)
- Service Information Regarding Engine Rear Main Oil Seal Assembly (00-T-45)
- Valve Train Noise (00-T-56)
- Engine Cooling System Sealer Usage (97-T-40A)
- Engine Coolant Leak In Or Around Spark Plug Well Area Of Cylinder Head (Add One 10 Gram Pellet Of Engine Cooling System Sealer) (01-T-47)
- Service Information Regarding Upper Engine Mount Assembly (01-T-30A)
- Vehicle Vibration At Speeds Between 77-87 Km/H (48-54 Mph) (Install Powertrain Damper Kit) (00-T-57A)
- Engine Coolant Leak At Intake Manifold Gasket (Replace Intake Manifold Gasket With New Design 2-Piece Gasket) (01-T-15)
- Valve Train Noise (Loosen & Re-Torque Camshaft Bearing Cap Bolts) (00-T-56)
- Mobile Engine Lift Table (99-I-11)
- Internal Engine Cleaning Products (99-I-08)
- Mechanical - Hydraulic
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Disc Brake Warranty Service and Procedures - Lateral Runout (LRO), Rotor Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Corrosion, Squeak, Grind, Groan (05-05-22-002E)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
- Service Procedure For Brake Pressure Modulator Valve (00-T-25)
- Mirrors
- Paint & Coatings
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004A)
- Info - Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004)
- Front And Rear Side Door Window Frame Appliques And/Or Windshield Frame Filler Panel Appliques Exhibiting Top Coat Paint Peeling (02-T-71)
- Bumps or Iron Dust on Paint Surface (Apply Buffered Oxalic Acid Spray or a Clay Type Non-Acid Based Product Using Manufacturer's Recommendations) (99-08-51-006C)
- 2000 Model Year Paint Information (99-T-27)
- Parking Brake System
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Service Manual Update For All The 2000 S Series Brakes Service Manuals Regarding DTC B0005 (00-T-05)
- Service Information On Park Brake Lever Button Replacement (01-T-04A)
- SMU - Brake Service Manual Regarding DTC B0005 (00-T-05)
- Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Seat Belt Latch Falls To Floor Or Is Difficult To Retrieve (Install New Replacement Seat Belt Stow Button Kit) (01-T-44)
- SMU - Coupe Front Safety Belt Procedures (99-T-23)
- Rear Suspension
- Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Service Manual Update For 2000 And 2001 S Series Restraints Service Manuals (01-T-03)
- Service Manual Update For 2000/2001 S-Series Body/Electrical Volume II Service Manuals (00-T-67A)
- Service Manual Update For 2000/2001 S-Series Restraints Service Manuals (01-T-03)
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Squeak Noise From Driver Or Passenger Seat Back (00-T-48)
- Abnormal Wear Or Cut On Inboard Edge Of Seat Back Cover (00-T-38)
- Squeak Noise From Driver Or Passenger Seat Back (Install Seat Frame Insulator) (00-T-48)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- Engine Cranks But Will Not Start Or Engine Starts But Fuel Gauge And Tachometer Are Inoperative. Scan Tool Is Also Unable To Communicate With Pcm And DTC (01-T-26)
- Battery Charger For Critical Image Equipment Program (99-I-07)
- Steering Column
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Power Steering System Noise and/or Leak Diagnosis (02-T-46)
- Steering Wheel Shake Or Vibration At 100-109 Km/H (62-68 Mph) (Follow Vibration Complaint Flow Chart, Replace Hub Assembly, If Necessary) (04-03-10-008)
- Popping Noise From Steering Column During Low Speed Maneuvers (00-T-03)
- Service Manual Update For All S Series 2000 Restraint Service Manuals For Inspecting The Steering Column For Accident Damage (00-T-13)
- SMU - Inspecting Steering Column For Accident Damage (00-T-13)
- Popping Noise - Steering Column - Low Speed MANUEVER (00-T-03)
- Steering Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Service Manual Update Regarding DTCS P0636 And P0637 (00-T-15)
- Service Manual Update For The 2000 S-Series Chassis Service Manual Regarding DTCS P0636 & P0637 Steering Assist Solenoid Control Circuit Low/High (00-T-15)
- SMU - DTC P0636 & P0637 Steering Assist Solenoid (00-T-15)
- Steering Gear
- Steering Linkage
- Power Steering System Noise and/or Leak Diagnosis (02-T-46)
- Steering Wheel Shake Or Vibration At 100-109 Km/H (62-68 Mph) (Follow Vibration Complaint Flow Chart, Replace Hub Assembly, If Necessary) (04-03-10-008)
- Service Information on New Torque Specification and Installation Procedure for the Outer Tie Rod-to-Steering Knuckle Joint on vehicles Equipped with a Torque Prevailing Nut (99-T-05A)
- Sun Roof/T-Top/Convertible Top
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Front Door Handle Contacts Outer Door Panel (99-T-45)
- Suspension Control Systems
- System
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- SES Lamp On with DTC P0442 "EVAP System Small Leak Detected" Set (Diagnose Evaporative Emission [EVAP] System, Repair as Necessary) (05-06-04-049)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM, and TCM) for All Models and All Model Years (05-06-04-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SMU For Powertrain And Engine Service Manuals Regarding Evaporative Emission Flowcharts And EVAP Pressure/Purge Diagnostic Cart Test Procedure (02-T-02)
- Engine Coolant Leak At Intake Manifold Gasket (01-T-15A)
- Engine Hesitation And/Or Vehicle Lacks Power With DTC P0326 Knock Sensor System Performance Set (Install Pcm Calibration) (03-T-02)
- Mil Service Engine Soon Telltale Lamp On, Abs Telltale Lamp May Come On Intermittently And/Or Stay On With DTCS U1000, U1040 And C0550 Present (02-T-59)
- DTC P0603 May Be Stored When Battery Voltage Is Removed From The Pcm With Ignition Off (00-T-55)
- Mil Service Soon Telltale On With DTC P0133 - O2S Slow Response (00-T-02B)
- Service Information Regarding 2000-2001 S Series Powertrain Control Module Calibrations (00-T-71)
- Any Of The Following Components Or Circuits Are Inoperative Or Intermittently Inoperative - Rear Washer Pump, Rear Wiper, Speakers Cutting Out, Vehicle Cranks But May Not Start, Mil SES Light On (00-T-43A)
- Engine Coolant Leak At Intake Manifold Gasket (Replace Intake Manifold Gasket With New Design 2-Piece Gasket) (01-T-15)
- Engine Coolant Temperature Sensor Diagnostic Trouble Code(S) &/Or The Following Conditions: Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low &/Or Leaking Coolant, &/Or Service Engine Soon Lamp Illuminated (01-T-07)
- SMU For S-Series Eng DTC'S P0231,P0232,P0418,P1418 (99-T-63)
- Emission Requirements For M.Y. 2000 (99-I-10)
- Towing
- Trailer, Recreational and Disabled Vehicle Towing Information (03-00-89-033B)
- Information On Flat-Towing SATURN S-Series With All Four Wheels On The Ground (97-I-19A)
- (Mil) Service Engine Soon Telltale Illuminated With DTC P0711 After Vehicle Is Flat-Towed With All Four Wheels On The Ground (Clear DTC & Retest) (01-T-28)
- Transfer Case
- Transmission Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In September (04-00-89-044)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In May, 2004 (04-00-89-023)
- (SES) Service Engine Soon Light On With Diagnostic Trouble Code (DTC) P0731, No Movement In Drive During Cold Ambient Temperatures (Replace Oil Pump Or 1ST Gear Sprag Clutch Assembly) (03-07-30-008A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Service Information Regarding Service Applications For Automatic Transaxle Shift Solenoids (00-T-74)
- Delayed And/Or Harsh Engagement Into Reverse Or Drive, Erratic Shifting Between 1ST/2ND, Bind Up In Reverse, No 2ND Or 3RD Gears, And/Or Transaxle DTCS P0731, P0732, P0733 Or P0734 Stored In Pcm (00-T-24)
- Service Information Regarding 2000-2001 S Series Powertrain Control Module Calibrations (00-T-71)
- (Mil) Service Engine Soon Telltale Illuminated With DTC P0711 After Vehicle Is Flat-Towed With All Four Wheels On The Ground (Clear DTC & Retest) (01-T-28)
- Harsh Shifts, No Shifts &/Or No TCC Operation With Transaxle Related DTCS Set (Replace Transaxle Connector & Harness) (01-T-09)
- Service Information Regarding 2000-2001 SATURN S-Series Powertrain Control Module (Pcm) Calibrations (00-T-71)
- Service Information Regarding New Design Automatic Transaxle Solenoids (00-T-74)
- SMU - DTC P0731, P0732, P0733, P0734, P0741 (99-T-67)
- Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- Info - New Measuring Wheel Alignment Procedure For Labor Operation Numbers E2020 And E2000 (04-03-07-003)
- Wheel Hubs
- Wheels & Tire System
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- GM New Vehicle Tire Warranty Program (U.S. Only) (05-03-10-009)
- Quick Tips for Warranty Administration (05-00-89-007)
- Steering Wheel Shake Or Vibration At 100-109 Km/H (62-68 Mph) (Follow Vibration Complaint Flow Chart, Replace Hub Assembly, If Necessary) (04-03-10-008)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In April, 2004 (04-00-89-017)
- CALIF. VEH. Code Requirements Regarding Tire Chains (99-I-09)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Rear Side Door Glass Will Not Go Up Or Down, Or Will Fall Down Unintentionally (03-T-05)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Driver Side Power Window Switch Intermittent - REPL Switch Assembly (99-T-64)
- Front Door Handle Contacts Outer Door Panel (99-T-45)
- Wiper/Washer Systems
- Windshield Wiper Performance, Cleaning Instructions And Maintenance (06-08-43-003E)
- New Design Front Wiper System Information (00-T-12)
- Any Of The Following Components Or Circuits Are Inoperative Or Intermittently Inoperative - Rear Washer Pump, Rear Wiper, Speakers Cutting Out, Vehicle Cranks But May Not Start, Mil SES Light On (00-T-43A)
- Service Information Regarding Wiper-Related Diag & Service Procedures (00-T-12)
- Clogged Windshield Washer Nozzle &/Or Poor Windshield Washer Spray (Replace Windshield Washer Pump Seal & Affected Washer Nozzles) (01-T-35)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Any Of The Following Components Or Circuits Are Inoperative Or Intermittently Inoperative - Rear Washer Pump, Rear Wiper, Speakers Cutting Out, Vehicle Cranks But May Not Start, Mil SES Light On (00-T-43A)
- Service Manual Update For 2000 And 2001 S Series Body/Electrical Volume II Service Manual Due To Revision Changes In Circuit Function Of Connectors (00-T-67)
- Engine Cranks But Will Not Start Or Engine Starts But Fuel Gauge And Tachometer Are Inoperative. Scan Tool Is Also Unable To Communicate With Pcm And DTC (01-T-26)
- Service Manual Update For 2000/2001 S-Series Body/Electrical Volume II Service Manuals (00-T-67A)