Problem Symptoms Table
HINT:
- Use the table below to help determine the cause of problem symptoms. If multiple suspected areas are listed, the potential causes of the symptoms are listed in order of probability in the "Suspected Area" column of the table. Check each symptom by checking the suspected areas in the order they are listed. Replace parts as necessary.
- Inspect the fuses and relays related to this system before inspecting the suspected areas below.
SFI SYSTEM
| Symptom | Suspected Area | See |
|---|---|---|
| Engine does not crank (Does not start) | Immobiliser system (w/ Smart Key System) | Refer to HOW TO PROCEED WITH TROUBLESHOOTING |
| Immobiliser system (w/o Smart Key System) | Refer to HOW TO PROCEED WITH TROUBLESHOOTING | |
| Hybrid control system | Refer to HOW TO PROCEED WITH TROUBLESHOOTING | |
| VC output circuit (ECM 5 V output) | Refer to VC Output Circuit | |
| Smart access system with push-button start | Refer to HOW TO PROCEED WITH TROUBLESHOOTING | |
| No initial combustion (Does not start) | ECM power source circuit | Refer to ECM Power Source Circuit |
| VC output circuit (ECM 5 V output) | Refer to VC Output Circuit | |
| Crankshaft position sensor | Refer to INSPECTION | |
| Fuel pump control circuit | Refer to Fuel Pump Control Circuit | |
| Ignition system | Refer to ON-VEHICLE INSPECTION | |
| Fuel injector circuit | Refer to Fuel Injector Circuit | |
| Valve timing | Refer to REASSEMBLY | |
| Engine cranks normally but difficult to start | Fuel pump control circuit | Refer to Fuel Pump Control Circuit |
| Fuel pump | Refer to INSPECTION | |
| Engine coolant temperature sensor | Refer to INSPECTION | |
| Ignition system | Refer to ON-VEHICLE INSPECTION | |
| Fuel injector assembly | Refer to INSPECTION | |
| EGR valve assembly | Refer to INSPECTION | |
| Compression | Refer to ON-VEHICLE INSPECTION | |
| Fuel injector circuit | Refer to Fuel Injector Circuit | |
| Intake system | Refer to ON-VEHICLE INSPECTION | |
| Throttle with motor body assembly | Refer to INSPECTION | |
| ECM Power Source Circuit | Refer to ECM Power Source Circuit | |
| Incomplete intermittent combustion occurs (Does not start) | Fuel pump control circuit | Refer to Fuel Pump Control Circuit |
| Fuel pump | Refer to INSPECTION | |
| Fuel line | - | |
| Ignition system | Refer to ON-VEHICLE INSPECTION | |
| Fuel injector assembly | Refer to INSPECTION | |
| Crankshaft position sensor | Refer to INSPECTION | |
| Valve timing | Refer to REASSEMBLY | |
| High engine speed (Poor idle) | Throttle with motor body assembly | Refer to INSPECTION |
| Throttle with motor body assembly control | - | |
| Engine coolant temperature sensor | Refer to INSPECTION | |
| PCV hose | Refer to ON-VEHICLE INSPECTION | |
| PCV system | Refer to ON-VEHICLE INSPECTION | |
| Low engine speed (Poor idle) | Fuel pump control circuit | Refer to Fuel Pump Control Circuit |
| Throttle with motor body assembly | Refer to INSPECTION | |
| Throttle with motor body assembly control | - | |
| Intake system | Refer to ON-VEHICLE INSPECTION | |
| PCV hose | Refer to ON-VEHICLE INSPECTION | |
| PCV system | Refer to ON-VEHICLE INSPECTION | |
| Engine stalls on deceleration | Idle speed (refer to "Low engine speed") | Refer to ON-VEHICLE INSPECTION |
| EGR valve assembly | Refer to INSPECTION | |
| Rough idle | Compression (engine mechanical) | Refer to ON-VEHICLE INSPECTION |
| Air fuel ratio sensor | Refer to INSPECTION | |
| Heated oxygen sensor | Refer to INSPECTION | |
| Mass air flow meter sub-assembly | Refer to INSPECTION | |
| Ignition system | Refer to ON-VEHICLE INSPECTION | |
| Fuel line | - | |
| Valve timing | Refer to REASSEMBLY | |
| Fuel pump | Refer to INSPECTION | |
| Intake system | Refer to ON-VEHICLE INSPECTION | |
| PCV hose | Refer to ON-VEHICLE INSPECTION | |
| PCV system | Refer to ON-VEHICLE INSPECTION | |
| EGR valve assembly | Refer to INSPECTION | |
| Hunting (Poor idle) | PCV hose | Refer to ON-VEHICLE INSPECTION |
| PCV system | Refer to ON-VEHICLE INSPECTION | |
| Mass air flow meter sub-assembly | Refer to INSPECTION | |
| Air fuel ratio sensor | Refer to INSPECTION | |
| Hesitation/Poor acceleration (Poor driveability) | Fuel line | - |
| Fuel pump | Refer to INSPECTION | |
| Valve timing | Refer to REASSEMBLY | |
| Mass air flow meter sub-assembly | Refer to INSPECTION | |
| Throttle with motor body assembly | Refer to INSPECTION | |
| Knock control sensor | Refer to INSPECTION | |
| Surging (Poor driveability) | Fuel line | - |
| Fuel pump control circuit | Refer to Fuel Pump Control Circuit | |
| Fuel pump | Refer to INSPECTION | |
| Ignition system | Refer to ON-VEHICLE INSPECTION | |
| Fuel injector assembly | Refer to INSPECTION | |
| Engine stalls soon after starting | Mass air flow meter sub-assembly | Refer to INSPECTION |
| Intake system | Refer to ON-VEHICLE INSPECTION | |
| Fuel line | - | |
| EGR valve assembly | Refer to INSPECTION | |
| Unable/difficult to refuel | Refueling valve (canister) | Refer to INSPECTION |